Rheological Properties of Waterborne Polyurethane Paints

Citation: Huan-huan Zhang, Ran Niu, Xin-bing Guan, Dong-hua Xu, Tong-fei Shi. Rheological Properties of Waterborne Polyurethane Paints[J]. Chinese Journal of Polymer Science, 2015, 33(12): 1750-1756. doi: 10.1007/s10118-015-1718-8 shu

Rheological Properties of Waterborne Polyurethane Paints

1.
1. State Key Laboratory of Polymer Physics and Chemistry, Changchun Institute of Applied Chemistry, Chinese Academy of Sciences, Changchun 130022, China
2.
2. University of Chinese Academy of Sciences, Beijing 100049, China
3.
4.
Shanghai WaterBased Chemical Co. Ltd, Shanghai 200072, China
5.
State Key Laboratory of Polymer Physics and Chemistry, Changchun Institute of Applied Chemistry, Chinese Academy of Sciences, Changchun 130022, China
基金项目:
This work was financially supported by the National Natural Science Foundation of China(Nos.21274152, 51473168 and 21234007).

摘要: The rheological properties of two specific waterborne polyurethane(PU) paints were studied by both macrorheological and microrheological methods. During the macrorheological measurement on a rotary rheometer, evaporation of solvent cannot be totally excluded, which has an influence on the reliability of rheological results. So, the linear oscillatory frequency sweep results(storage and loss modulus versus frequency) and steady shear results(viscosity versus shear rate) got from the rotary rheometer measurement are only used for qualitative analysis. As the evaporation of solvent can be neglected during microrheological measurements on a diffusing wave spectroscope(DWS), the results of storage modulus(G') and loss modulus(G) versus frequency are more credible than the results obtained from the rotary rheometer measurement. Thus, the results of G' and G versus frequency from DWS measurements are used for quantitative analysis in this work. The G' for both of the waterborne PU paints are larger than G at low frequency and that is opposite at high frequency in the experimental angular frequency range. The values of modulus at same frequency and viscosity at low shear rate for the two PU paints have apparent difference, which determines the difference of their application.

关键词:

English

Rheological Properties of Waterborne Polyurethane Paints

1.
1. State Key Laboratory of Polymer Physics and Chemistry, Changchun Institute of Applied Chemistry, Chinese Academy of Sciences, Changchun 130022, China
2.
2. University of Chinese Academy of Sciences, Beijing 100049, China
3.
4.
Shanghai WaterBased Chemical Co. Ltd, Shanghai 200072, China
5.
State Key Laboratory of Polymer Physics and Chemistry, Changchun Institute of Applied Chemistry, Chinese Academy of Sciences, Changchun 130022, China
Received Date: 15 June 2015
Revised Date: 23 July 2015
Available Online: 05 December 2015
Fund Project:
This work was financially supported by the National Natural Science Foundation of China(Nos.21274152, 51473168 and 21234007).

Abstract: The rheological properties of two specific waterborne polyurethane(PU) paints were studied by both macrorheological and microrheological methods. During the macrorheological measurement on a rotary rheometer, evaporation of solvent cannot be totally excluded, which has an influence on the reliability of rheological results. So, the linear oscillatory frequency sweep results(storage and loss modulus versus frequency) and steady shear results(viscosity versus shear rate) got from the rotary rheometer measurement are only used for qualitative analysis. As the evaporation of solvent can be neglected during microrheological measurements on a diffusing wave spectroscope(DWS), the results of storage modulus(G') and loss modulus(G) versus frequency are more credible than the results obtained from the rotary rheometer measurement. Thus, the results of G' and G versus frequency from DWS measurements are used for quantitative analysis in this work. The G' for both of the waterborne PU paints are larger than G at low frequency and that is opposite at high frequency in the experimental angular frequency range. The values of modulus at same frequency and viscosity at low shear rate for the two PU paints have apparent difference, which determines the difference of their application.

Key words:

1. [1]
  Barletta, M., Vesco, S. and Tagliaferri, V., Colloids Surf., B:Biointerfaces, 2014, 120:71
2. [2]
  Pedna, A., Rosi, L., Frediani, M. and Frediani, P., J. Appl. Polym. Sci., 2015, 132:42323
3. [3]
  Chattopadhyay, D.K. and Raju, K.V.S.N., Prog. Polym. Sci., 2007, 32:352
4. [4]
  Golru, S.S., Attar, M.M. and Ramezanzadeh, B., Appl. Surf. Sci., 2015, 345:360
5. [5]
  Peres, R.S., Armelin, E., Aleman, C. and Ferreira, C.A., Industrial Crops and Products, 2015, 65:506
6. [6]
  Zhou, X., Li, Y., Fang, C.Q., Li, S.J., Cheng, Y.L., Lei, W.Q. and Meng, X.J., J. Mater. Sci. Technol., 2015, 31:708
7. [7]
  Lei, L., Zhong, L., Lin, X.Q., Li, Y.Y. and Xia, Z.B., Chem. Eng. J., 2014, 253:518
8. [8]
  Burja, K., egedin, U., Skale, S., Berce, P., ket, P., Prosen, P. and Kukanja, D., Prog. Org. Coat., 2015, 78:275
9. [9]
  Ma, G.Z., Guan, T.T., Hou, C.Y., Wu, J.B., Wang, G., Ji, X. and Wang, B.J., J. Coat. Technol. Res., 2015, 12:505
10. [10]
  Deka, A. and Dey, N., J. Coat. Technol. Research, 2013, 10(3):305
11. [11]
  Ha, S.K., Na, S., Bang, Y.K. and Lee, H.K., Mater. Struct., 2015, 48:21
12. [12]
  Osterhold, M., Prog. Org. Coat., 2000, 40:131
13. [13]
  Kstner, U., Colloids Surf. A:Physicochem. Eng. Asp., 2001, 183:805
14. [14]
  Bhavsar, R., Raj, R. and Parmar, R., Prog. Org. Coat., 2013, 76:852
15. [15]
  Kuan, H.C., Ma, C.C.M., Chang, W.P., Yuen, S.M., Wu, H.H. and Lee, T.M., Compos. Sci. Technol., 2005, 65:1703
16. [16]
  Scheffold, F., Skipetrov, S. E., Romer, S. and Schurtenberger, P., Phys. Rev. E:Stat., Nonlinear, Soft Matter Phys., 2001, 63:061404
17. [17]
  Cicuta, P. and Donald, A.M., Soft Matter, 2007, 3:1449
18. [18]
  Harden, J.L. and Viasnoff, V., Curr. Opin. Colloid Interface Sci., 2001, 6:438
19. [19]
  Maret, G. and Wolf, P.E., Z. Phys. B:Condens. Matter, 1987, 65:409
20. [20]
  Liu, J.X., Boyko, V., Yi, Z.Y. and Men, Y.F., Langmuir, 2013, 29:14044
21. [21]
  Pine, D.J., Weitz, D.A., Chaikin, P.M. and Herbolzheimer, E., Phys. Rev. Lett., 1988, 60(12):1134
22. [22]
  Rojas-Ochoa, L. F., Romer, S., Scheffold, F. and Schurtenberger, P., Phys. Rev. E:Stat., Nonlinear, Soft Matter Phys., 2002, 65:051403
23. [23]
  Andre Palmer, A., Mason, T.G., Xu, J.Y., Kuo, S.C. and Wirtz, D., Biophys. J., 1999, 76:1063
24. [24]
  Palmer, A., Xu, J.Y. and Wirtz, D., Rheol. Acta, 1998, 37:97
25. [25]
  Mason, T.G. and Weitz, D.A., Phys. Rev. Lett., 1995, 74(7):1250
26. [26]
  Xu, J.Y., Viasnoff, V. and Wirtz, D., Rheol. Acta, 1998, 37:387
27. [27]
  Fraden, S. and Maret, G., Phys. Rev. Lett., 1990, 65(4):512
28. [28]
  Menon, N. and Durian, D.J., Science, 1997, 275(28):1920
29. [29]
  Moschakis, T., Curr. Opin. Colloid Interface Sci., 2013, 18:311
30. [30]
  Weeks, E.R. and Weitz, D.A., Chem. Phys., 2002, 284:361
31. [31]
  Nishinari, K., Prog. Colloid Polym. Sci., 2009, 136:87

扫一扫看文章

计量

PDF下载量: 0
文章访问数: 1275
HTML全文浏览量: 54

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Rheological Properties of Waterborne Polyurethane Paints

English

Rheological Properties of Waterborne Polyurethane Paints

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

Rheological Properties of Waterborne Polyurethane Paints

English

Rheological Properties of Waterborne Polyurethane Paints

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南： 你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

文章相关

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs