TiO2纳米管电极上电化学还原CO2生成CH3OH

引用本文: 裘建平, 童怡雯, 赵德明, 何志桥, 陈建孟, 宋爽. TiO₂纳米管电极上电化学还原CO₂生成CH₃OH[J]. 物理化学学报, 2017, 33(7): 1411-1420. doi: 10.3866/PKU.WHXB201704078 shu

Citation: QIU Jian-Ping, TONG Yi-Wen, ZHAO De-Ming, HE Zhi-Qiao, CHEN Jian-Meng, SONG Shuang. Electrochemical Reduction of CO₂ to Methanol at TiO₂ Nanotube Electrodes[J]. Acta Physico-Chimica Sinica, 2017, 33(7): 1411-1420. doi: 10.3866/PKU.WHXB201704078 shu

TiO₂纳米管电极上电化学还原CO₂生成CH₃OH

1.
浙江工业大学环境学院, 杭州 310032;
2.
金华职业技术学院, 浙江金华 321007;
3.
浙江工业大学化学工程学院, 杭州 310032
基金项目:
国家自然科学基金（21477117）和浙江省自然科学基金（LR14E080001，LQ15E080007，LY15B070005）资助项目

摘要: 采用原位阳极氧化-煅烧法制备TiO₂纳米管（TiO₂NTs）电极，运用X射线衍射（XRD）、电场发射扫描电子显微镜（FESEM）、X射线光电子能谱（XPS）、双电位阶跃测试等对制备电极进行表征，考察了其在0.1 mol·L^-1 KHCO₃水溶液中电化学还原CO₂的催化活性。结果表明TiO₂NTs电极上电化学还原CO₂的主产物为CH₃OH，CH₃OH由HCOOH和HCHO进一步还原而来。电极制备的最佳煅烧温度为450℃（TiO₂NTs-450），电解电位-0.56 V（vs RHE （可逆氢电极））时反应120 min后，生成CH₃OH的法拉第效率和分电流密度分别为85.8%和0.2 mA·cm^-2。与550和650℃煅烧的电极相比，TiO₂NTs-450电极具有更高的催化活性，归因于电极表面更多的三价钛活性位，有利于CO₂吸附，从而对·CO₂^-起到稳定的作用，速率控制步骤转变为·CO₂^-的质子化反应。

关键词:

English

Electrochemical Reduction of CO₂ to Methanol at TiO₂ Nanotube Electrodes

1.
College of Environment, Zhejiang University of Technology, Hangzhou 310032, P. R. China;
2.
Jinhua Polytechnic, Jinhua 321007, Zhejiang Province, P. R. China;
3.
College of Chemical Engineering, Zhejiang University of Technology, Hangzhou 310032, P. R. China
Received Date: 21 December 2016
Revised Date: 24 March 2017
Available Online: 13 April 2017
Fund Project:
The project was supported by the National Natural Science Foundation of China (21477117) and Natural Science Foundation of Zhejiang Province, China (LR14E080001, LQ15E080007, LY15B070005).

Abstract: A series of highly ordered TiO₂ nanotube (TiO₂NTs) electrodes are prepared via potentiostatic anodization of Ti foil followed by calcining in air. X-ray diffraction (XRD), field-emission scanning electron microscopy (FESEM), X-ray photoelectron spectroscopy (XPS), and potential steps determination are used to characterize the electrodes. The electrochemical reduction of CO₂ on these three TiO₂NTs electrodes is investigated by cyclic voltammetry and potentiostatic electrolysis in 0.1 mol·L^-1 KHCO₃ aqueous solution. Methanol is found to be the major product in electrochemical CO₂ reduction, while formic acid, formaldehyde, methane, and CO are formed as minor products. Compared with the electrodes sintered at 550 and 650℃, the optimal TiO₂NTs electrode is found to be the one calcined at 450℃ (TiO₂NTs-450). After 120 min of reaction, the Faradaic efficiency and partial current density of methanol is 85.8% and 0.2 mA·cm^-2 at -0.56 V vs. reversible hydrogen electrode (RHE), respectively. The trivalent titanium in TiO₂ serves as an efficient site for adsorption of CO₂ and stabilization of the adsorbed ·CO₂^- radical. Consequently, the reduction of CO₂ on TiO₂NTs electrodes involves a fast first electron and proton transfer followed by a slow second proton transfer as the rate-limiting step.

Key words:

1. [1]
  (1) Qiao, J. L.; Liu, Y. Y.; Hong, F.; Zhang, J. J. Chem. Soc. Rev. 2014, 43, 631. doi: 10.1039/c3cs60323g
2. [2]
  (2) Ritter, S. K. Chem. Eng. News. 2007, 85(18), 11.
3. [3]
  (3) Mistry, H.; Reske, R.; Zeng, Z.; Zhao, Z. J.; Greeley, J.; Strasser, P.; Cuenya, B. R. J. Am. Chem. Soc. 2014, 136, 16473. doi: 10.1021/ja508879j
4. [4]
  (4) He, Z. Q.; Tang, J. T.; Shen, J.; Chen, J. M.; Song, S. Appl. Surf. Sci. 2016, 364, 416. doi: 10.1016/j.apsusc.2015.12.163
5. [5]
  (5) Liu, Z. F. Acta Phys. -Chim. Sin. 2016, 32, 793. [刘忠范. 物理化学学报, 2016, 32, 793.] doi: 10.3866/PKU.WHXB201602181
6. [6]
  (6) Lee, C. H.; Kanan, M. W. ACS Catal. 2014, 5, 465. doi: 10.1021/cs5017672
7. [7]
  (7) Olah, G. A.; Goeppert, A.; Prakash, G. K. S. J. Org. Chem. 2008, 74, 487. doi: 10.1021/jo801260f
8. [8]
  (8) Canfield, D.; Frese, K. W., Jr. J. Electrochem. Soc. 1983, 130, 1772. doi: 10.1149/1.2120090
9. [9]
  (9) Summers, D. P.; Leach, S.; Frese, K. W., Jr. J. Electroanal. Chem. 1986, 205, 219. doi: 10.1016/0022-0728(86)90233-0
10. [10]
  (10) Seshadri, G.; Lin, C.; Bocarsly, A. B. J. Electroanal. Chem. 1994, 372, 145. doi: 10.1016/0022-0728(94)03300-5
11. [11]
  (11) Le, M.; Ren, M.; Zhang, Z.; Sprunger, P. T.; Kurtz, R. L.; Flake, J. C. J. Electrochem. Soc. 2011, 158, E45. doi: 10.1149/1.3561636
12. [12]
  (12) Qu, J. P.; Zhang, X. G.; Wang, Y. G.; Xie, C. X. Electrochim. Acta 2005, 50, 3576. doi: 10.1016/j.electacta.2004.11.061
13. [13]
  (13) Zhao, F. M.; Yan, F.; Qian, Y.; Xu, Y. H.; Ma, C. A. J. Electroanal. Chem. 2013, 698, 31. doi: 10.1016/j.jelechem.2013.03.014
14. [14]
  (14) Water Quality-Determination of Formaldehyde-Acetylacetone Spectrophotometric Method. GB/T 1397-1991. [水质甲醛的测定—乙酰丙酮分光光度法. GB/T 13197-1991.]
15. [15]
  (15) Liu, L. J.; Li, Y. Aerosol. Air Qual. Res. 2014, 14, 453. doi: 10.4209/aaqr.2013.06.0186
16. [16]
  (16) Zhang, H.; Chen, J. H.; Chen, H. B.; Lin, C. J. J. Mol. Catal. 2006, 20, 249. [张慧, 陈建华, 陈鸿博, 林昌健. 分子催化, 2006, 20, 249.] doi: 10.16084/j.cnki.issn1001-3555.2006.03.013
17. [17]
  (17) Wang, W.; Ni, Y. R.; Lu, C. H.; Xu, Z. Z. RSC Adv. 2012, 2, 8286. doi: 10.1039/c2ra21049e
18. [18]
  (18) Goeppert, A.; Czaun, M.; Jones, J. P.; Prakash, G. K. S.; Olah, G. A. Chem. Soc. Rev.2014, 43, 7995. doi: 10.1039/c4cs00122b
19. [19]
  (19) Chen, X. W. Study on Preparation of Modified TiO₂ Nanotube Photoelectrode and Its Photoelectrocatalytic Degradation of Diclofenac. Ph. D. Dissertation, Harbin Institute of Technology, Harbin, 2014. [程修文. 改性TiO₂纳米管光电极制备及光电催化降解双氯芬酸研究[D]. 哈尔滨: 哈尔滨工业大学, 2014.]
20. [20]
  (20) Russell, P. G.; Kovac, N.; Srinivasan, S.; Steinberg, M. J. Electrochem. Soc. 1977, 124, 1329. doi: 10.1149/1.2133624
21. [21]
  (21) Jitaru, M.; Lowy, D. A.; Toma, M.; Toma, B. C.; Oniciu, L. J. Appl. Electrochem. 1997, 27, 875. doi: 10.1023/a:1018441316386
22. [22]
  (22) Innocent, B.; Pasquier, D.; Ropital, F.; Hahn, F.; Léger, J. M.; Kokoh, K. B. Appl. Catal. B2010, 94, 219. doi: 10.1016/j.apcatb.2009.10.027
23. [23]
  (23) Hori, Y.; Murata, A.; Takahashi, R. J. Chem. Soc., Faraday Trans. 1989, 85, 2309. doi: 10.1039/F19898502309
24. [24]
  (24) Fletcher, S. J. Solid State Electrochem. 2009, 13, 537. doi: 10.1007/s10008-008-0670-8
25. [25]
  (25) Bhattacharyya, K.; Danon, A. K.; Vijayan, B. K.; Gray, K. A.; Stair, P. C.; Weitz, E. J. Phys. Chem. C 2013, 117, 12661. doi: 10.1021/jp402979m
26. [26]
  (26) Xiong, L. B.; Li, J. L.; Yang, B.; Yu, Y. J. Nanomater. 2012, 2012, 1. doi: 10.1155/2012/831524

扫一扫看文章

计量

PDF下载量: 4
文章访问数: 1012
HTML全文浏览量: 118

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

TiO₂纳米管电极上电化学还原CO₂生成CH₃OH

English

Electrochemical Reduction of CO₂ to Methanol at TiO₂ Nanotube Electrodes

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处