Citation: Li Zhiwei, Zhong Jialiang, Chen Nannan, Xue Bing, Mi Hongyu. Template-Assisted Preparation and Lithium Storage Performance of Nitrogen Doped Porous Carbon Sheets[J]. Acta Chimica Sinica, ;2018, 76(3): 209-214. doi: 10.6023/A17090425 shu

Template-Assisted Preparation and Lithium Storage Performance of Nitrogen Doped Porous Carbon Sheets

a.
Xinjiang Uygur Autonomous Region Key Laboratory of Clean Coal Conversion and Chemical Process, Xinjiang University, Urumqi 830046
b.
Department of Materials Science and Engineering, Jilin University, Changchun 130025

Corresponding author: Mi Hongyu, mmihongyu@163.com
Received Date: 18 September 2017
Available Online: 22 March 2018
Fund Project: Project supported by the National Natural Science Foundation of China (No. 21563029) and the Natural Science Foundation of Xinjiang Uygur Autonomous Region (No. 2014211A015)the Natural Science Foundation of Xinjiang Uygur Autonomous Region 2014211A015the National Natural Science Foundation of China 21563029

Figures(8)

Nitrogen doped porous carbon sheets (NPCSs) having high lithium storage performance were successfully prepared by a template-assisted approach using magnesium oxide/melamine/polyethylene glycol (MgO/melamine/PEG) as raw materials. In a typical procedure, the precursor, which consisted of MgO, melamine and PEG in a mass ratio of 7:3:10, was carbonized at 700℃ for 3 h in a temperature-programmed tubular furnace under N₂ flow with a heating rate of 5℃·min^-1. The intermediate was immersed into 3 mol·L^-1 HCl solution for several times to remove MgO. Subsequently, the sample was rinsed with water and ethanol until a neutral pH was obtained, and then dried at 80℃ in a vacuum oven. The sample was systematically characterized and analyzed by Fourier transform infrared spectrometer (FTIR), X-ray powder diffractometer (XRD), X-ray photoelectron spectrometer (XPS), scanning electron microscope (SEM), transmission electron microscope (TEM), cyclic voltammetry (CV), galvanostatic charge/discharge (GCD) and electrochemical impedance spectroscopy (EIS). The results indicated that NPCSs showed an interconnected porous carbon sheet networks, showing relatively high specific surface area (370.8 m²·g^-1), hierarchical pore channels, and high nitrogen content (8.5 at%). Such a continuous porous structure could enhance the electron transport on three-dimensional direction, shorten the diffusion distance of lithium ions, enlarge the interface area between lithium ion and electrolyte, and provide the place for the accommodation of lithium ions. Additionally, high N-doping level in NPCSs could provide numerous activated sites for the intercalation and deintercalation of lithium ions, and enhance the electronic conductivity. Based on the unique structure, NPCSs electrode could exhibit high initial reversible specific capacities (after excluding the contribution of acetylene black, 914 mAh·g^-1 at 100 mA·g^-1) and good cycling stability (still remaining a specific capacity of 523 mAh·g^-1 at 1000 mA·g^-1 up to 300 cycles). Moreover, NPCSs displayed high rate capability with a reversible capacity of 355 mAh·g^-1 at a current density of 3000 mA·g^-1. Therefore, the NPCSs obtained are expectable to be widely used as anode material in lithium-ion batteries.
- porous carbon sheet,
- carbonization-etching method,
- anode,
- Lithium-ion battery
1. [1]
  Dunn, B.; Kamath, H.; Tarascon, J. M. Science 2011, 334, 928. doi: 10.1126/science.1212741
2. [2]
  Yoshino, A. Angew. Chem. Int. Ed. 2012, 51, 5798. doi: 10.1002/anie.201105006
3. [3]
  Zheng, Z.; Wu, Z. G.; Xiang, W.; Guo, X. D. Acta Chim. Sinica 2017, 75, 501. doi: 10.11862/CJIC.2017.053
4. [4]
  Lv, Z. Y.; Feng, R.; Zhao, J.; Fan, H.; Xu, D.; Wu, Q.; Yang, L. J.; Chen, Q.; Wang, X. Z.; Hu, Z. Acta Chim. Sinica 2015, 73, 1013.
5. [5]
  Palacín, M. R. Chem. Soc. Rev. 2009, 38, 2565. doi: 10.1039/b820555h
6. [6]
  Li, H.; Wang, Z. X.; Chen, L. Q.; Huang, X. J. Adv. Mater. 2009, 21, 4593. doi: 10.1002/adma.v21:45
7. [7]
  Xu, Y. X.; Lin, Z. Y.; Zhong, X.; Papandrea, B.; Huang, Y.; Duan, X. F. Angew. Chem., Int. Ed. 2015, 54, 5345. doi: 10.1002/anie.201500677
8. [8]
  Ou, J. K.; Zhang, Y. Z.; Chen, L.; Zhao, Q.; Meng, Y.; Guo, Y.; Xiao, D. J. Mater. Chem. A 2015, 3, 6534. doi: 10.1039/C4TA06614F
9. [9]
  Du, J.; Lin, N.; Qian, Y. T. Acta Chim. Sinica 2017, 75, 147. doi: 10.3969/j.issn.0253-2409.2017.02.003
10. [10]
  Zhang, N.; Zhao, Q.; Han, X. P.; Yang, J. G.; Chen, J. Nanoscale 2014, 6, 2827. doi: 10.1039/C3NR05523J
11. [11]
  Zhu, X.; Ning, G. Q.; Ma, X. L.; Fan, Z. J.; Xu, C. G.; Gao, J. S.; Xu, C. M.; Wei, F. J. Mater. Chem. A 2013, 1, 14023. doi: 10.1039/c3ta12824e
12. [12]
  Etacheri, V.; Haik, O.; Goffer, Y.; Roberts, G. A.; Stefan, I. C.; Fasching, R.; Aurbach, D. Langmuir 2012, 28, 965. doi: 10.1021/la203712s
13. [13]
  Nan, D.; Huang, Z. Y.; Kang, F. Y.; Shen, W. C. New Carbon Materials 2016, 31, 393.
14. [14]
  Bulusheva, L. G.; Arkhipov, V. E.; Fedorovskaya, E. O.; Zhang, S.; Kurenya, A. G.; Kanygin, M. A.; Asanov, I. P.; Tsygankova, A. R.; Chen, X. H.; Song, H. H.; Okotrub, A. V. J. Power Sources 2016, 311, 42. doi: 10.1016/j.jpowsour.2016.02.036
15. [15]
  Wen, L.; Liu, C. M.; Song, R. S.; Luo, H. Z.; Shi, Y.; Li, F.; Chen, H. M. Acta Chim. Sinica 2014, 72, 333.
16. [16]
  Chen, M.; Yu, C.; Liu, S. H.; Fan, X. M.; Zhao, C. T.; Zhang, X.; Qiu, J. S. Nanoscale 2015, 7, 1791. doi: 10.1039/C4NR05878J
17. [17]
  Zhang, L. J.; Xia, G. L.; Guo, Z. P.; Sun, D. L.; Li, X. G.; Yu, X. B. J. Power Sources 2016, 324, 294. doi: 10.1016/j.jpowsour.2016.05.057
18. [18]
  Li, D. D.; Ding, L. X.; Chen, H. B.; Wang, S. Q.; Li, Z.; Zhu, M.; Wang, H. H. J. Mater. Chem. A 2014, 2, 16617. doi: 10.1039/C4TA03281K
19. [19]
  Roberts, A. D.; Wang, S. X.; Li, X.; Zhang, H. F. J. Mater. Chem. A 2014, 2, 17787.
20. [20]
  Akiyama, T.; Zhu, C. Y. Green Chem. 2016, 18, 2106. doi: 10.1039/C5GC02397A
21. [21]
  Wang, C. Y.; Feng, L. L.; Li, W.; Zheng, J.; Tian, W. H.; Li, X. G. Solar Energy Mater. Solar Cells 2012, 105, 21. doi: 10.1016/j.solmat.2012.05.031
22. [22]
  Zhong, J. L.; Guo, F. J.; Mi, H. Y. Chinese J. Inorg. Chem. 2015, 31, 2128.
23. [23]
  Zhang, X. J.; Zhu, G.; Wang, M.; Li, J. B.; Lu, T.; Pan, L. K. Carbon 2017, 116, 686. doi: 10.1016/j.carbon.2017.02.057
24. [24]
  Guo, N. N.; Li, M.; Wang, H.; Sun, X. K.; Wang, F.; Yang, R. RSC Adv. 2016, 6, 101372. doi: 10.1039/C6RA22426A
25. [25]
  Pumera, M. Energy Environ. Sci. 2011, 4, 668. doi: 10.1039/C0EE00295J
26. [26]
  You, L. J.; Zhang, Y. T.; Xu, S.; Guo, J.; Wang, C. C. ACS Appl. Mater. Interfaces 2014, 6, 15179. doi: 10.1021/am503421z
27. [27]
  Huang, C. W.; Wu, Y. T.; Hu, C. C.; Li, Y. Y. J. Power Sources 2007, 172, 460. doi: 10.1016/j.jpowsour.2007.07.009
28. [28]
  Wang, S. X.; Chen, S. L.; Wei, Q. L.; Zhang, X. K.; Wong, S. Y.; Sun, S. H.; Li, X. Chem. Mater. 2015, 27, 336. doi: 10.1021/cm504042s
29. [29]
  Jeong, H. M.; Lee, J. W.; Shin, W. H.; Choi, Y. J.; Shin, H. J.; Kang, J. K.; Choi, J. W. Nano Lett. 2011, 11, 2472. doi: 10.1021/nl2009058
30. [30]
  Li, Z.; Xu, Z. W.; Tan, X. H.; Wang, H. L.; Holt, C. M. B.; Stephenson, T.; Olsen, B. C.; Mitlin, D. Energy Environ. Sci. 2013, 6, 871. doi: 10.1039/c2ee23599d
31. [31]
  Wang, H. G.; Wang, Y. H.; Li, Y. H.; Wan, Y. C.; Duan, Q. Carbon 2015, 82, 116. doi: 10.1016/j.carbon.2014.10.041
32. [32]
  Sui, Z. Y.; Wang, C. Y.; Yang, Q. S.; Shu, K. W.; Liu, Y. W.; Han, B. H.; Wallace, G. G. J. Mater. Chem. A 2015, 3, 18229. doi: 10.1039/C5TA05759K
33. [33]
  Chang, K.; Chen, W. X. ACS Nano 2011, 5, 4720. doi: 10.1021/nn200659w
34. [34]
  Etacheri, V.; Hong, C. N.; Pol, V. G. Environ. Sci. Technol. 2015, 49, 11191. doi: 10.1021/acs.est.5b01896
35. [35]
  Zhu, C. Y.; Akiyama, T. Green Chem. 2015, 18, 2106.
36. [36]
  Song, R.; Song, H. H.; Zhou, J. S.; Chen, X. T.; Wu, B.; Yang, H. Y. J. Mater. Chem. 2012, 22, 12369. doi: 10.1039/c2jm31910a
37. [37]
  Ou, J. K.; Yang, L.; Zhang, Y. Z.; Chen, L.; Guo, Y.; Xiao, D. Chinese J. Chem. 2015, 33, 1293. doi: 10.1002/cjoc.v33.11
38. [38]
  Qie, L.; Chen, W. M.; Wang, Z. H.; Shao, Q. G.; Li, X.; Yuan, L. X.; Hu, X. L.; Zhang, W. X.; Huang, Y. H. Adv. Mater. 2012, 24, 2047. doi: 10.1002/adma.201104634
39. [39]
  He, B.; Li, W. C.; Lu, A. H. J. Mater. Chem. A 2015, 3, 579. doi: 10.1039/C4TA05056H
40. [40]
  Zhang, W. L.; Yin, J.; Lin, Z. Q.; Lin, H. B.; Lu, H. Y.; Wang, Y.; Huang, W. M. Electrochim. Acta 2015, 176, 1136. doi: 10.1016/j.electacta.2015.08.001
1. [1]
  Xueyu Lin , Ruiqi Wang , Wujie Dong , Fuqiang Huang . Rational Design of Bimetallic Oxide Anodes for Superior Li⁺ Storage. Acta Physico-Chimica Sinica, 2025, 41(3): 100021-0. doi: 10.3866/PKU.WHXB202311005
2. [2]
  Xintong Zhu , Bin Cao , Chong Yan , Cheng Tang , Aibing Chen , Qiang Zhang . Advances in coating strategies for graphite anodes in lithium-ion batteries. Acta Physico-Chimica Sinica, 2025, 41(9): 100096-0. doi: 10.1016/j.actphy.2025.100096
3. [3]
  Jingshuo Zhang , Yue Zhai , Ziyun Zhao , Jiaxing He , Wei Wei , Jing Xiao , Shichao Wu , Quan-Hong Yang . Research Progress of Functional Binders in Silicon-Based Anodes for Lithium-Ion Batteries. Acta Physico-Chimica Sinica, 2024, 40(6): 2306006-0. doi: 10.3866/PKU.WHXB202306006
4. [4]
  Qi Li , Pingan Li , Zetong Liu , Jiahui Zhang , Hao Zhang , Weilai Yu , Xianluo Hu . Fabricating Micro/Nanostructured Separators and Electrode Materials by Coaxial Electrospinning for Lithium-Ion Batteries: From Fundamentals to Applications. Acta Physico-Chimica Sinica, 2024, 40(10): 2311030-0. doi: 10.3866/PKU.WHXB202311030
5. [5]
  Mingyuan Pang , Yiping Su , Haohao Zhang , Laixin Hong , Yue Wang , Yujie Ma , Min Yang , Mengge Guo , Zimai Wang , Zhen Kong , Jiajia Ye , Juan An , Guanglei Wu . Bi₂S₃@Sn_0.904O₂中硫空位与锡空位的协同构筑及其作为长寿命锂离子电池负极材料. Acta Physico-Chimica Sinica, 2026, 42(11): 100368-. doi: 10.1016/j.actphy.2026.100368
6. [6]
  Zhuo WANG , Xiaotong LI , Zhipeng HU , Junqiao PAN . Three-dimensional porous carbon decorated with nano bismuth particles: Preparation and sodium storage properties. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 267-274. doi: 10.11862/CJIC.20240223
7. [7]
  Qingtang ZHANG , Xiaoyu WU , Zheng WANG , Xiaomei WANG . Performance of nano Li₂FeSiO₄/C cathode material co-doped by potassium and chlorine ions. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1689-1696. doi: 10.11862/CJIC.20240115
8. [8]
  Liangliang Song , Haoyan Liang , Shunqing Li , Bao Qiu , Zhaoping Liu . Challenges and strategies on high-manganese Li-rich layered oxide cathodes for ultrahigh-energy-density batteries. Acta Physico-Chimica Sinica, 2025, 41(8): 100085-0. doi: 10.1016/j.actphy.2025.100085
9. [9]
  Yifeng Xu , Jiquan Liu , Bin Cui , Yan Li , Gang Xie , Ying Yang . “Xiao Li’s School Adventures: The Working Principles and Safety Risks of Lithium-ion Batteries”. University Chemistry, 2024, 39(9): 259-265. doi: 10.12461/PKU.DXHX202404009
10. [10]
  Wen Tang , Luyu Sui , Qian Chen , Jun Shao , Xinwen Peng , Jianwen Jiang , Shuiliang Chen . Project-based Teaching of “the Condensed State of Polymers”: Unveiling the Lithium-Ion Battery Separator. University Chemistry, 2025, 40(11): 115-126. doi: 10.12461/PKU.DXHX202412108
11. [11]
  Siyu Zhang , Kunhong Gu , Bing'an Lu , Junwei Han , Jiang Zhou . Hydrometallurgical Processes on Recycling of Spent Lithium-lon Battery Cathode: Advances and Applications in Sustainable Technologies. Acta Physico-Chimica Sinica, 2024, 40(10): 2309028-0. doi: 10.3866/PKU.WHXB202309028
12. [12]
  Chenyue Huang , Hongfei Zheng , Ning Qin , Canpei Wang , Liguang Wang , Jun Lu . Single-Crystal Nickel-Rich Cathode Materials: Challenges and Strategies. Acta Physico-Chimica Sinica, 2024, 40(9): 2308051-0. doi: 10.3866/PKU.WHXB202308051
13. [13]
  Hua Yu , Dingdu Chen , Xuan Wang , Lijun Yang , Geming Wang , Pu Hu . MOF-encapsulated phosphorus/nitrogen ionic liquid as a multifunctional flame-retardant additive for high-safety lithium-ion batteries. Acta Physico-Chimica Sinica, 2026, 42(7): 100201-0. doi: 10.1016/j.actphy.2025.100201
14. [14]
  Ying Li , Yushen Zhao , Kai Chen , Xu Liu , Tingfeng Yi , Li-Feng Chen . Rational Design of Cross-Linked N-Doped C-Sn Nanofibers as Free-Standing Electrodes towards High-Performance Li-Ion Battery Anodes. Acta Physico-Chimica Sinica, 2024, 40(3): 2305007-0. doi: 10.3866/PKU.WHXB202305007
15. [15]
  Aoyu Huang , Jun Xu , Yu Huang , Gui Chu , Mao Wang , Lili Wang , Yongqi Sun , Zhen Jiang , Xiaobo Zhu . Tailoring Electrode-Electrolyte Interfaces via a Simple Slurry Additive for Stable High-Voltage Lithium-Ion Batteries. Acta Physico-Chimica Sinica, 2025, 41(4): 100037-0. doi: 10.3866/PKU.WHXB202408007
16. [16]
  Rongrong Wang , Chen Li , Xiang Ren , Keliang Zhang , Yu Sun , Xianzhong Sun , Kai Wang , Xiong Zhang , Yanwei Ma . Recent advances and challenges of eco-friendly Ni-rich cathode slurry systems in lithium-ion batteries. Acta Physico-Chimica Sinica, 2026, 42(4): 100222-0. doi: 10.1016/j.actphy.2025.100222
17. [17]
  Yuting ZHANG , Zunyi LIU , Ning LI , Dongqiang ZHANG , Shiling ZHAO , Yu ZHAO . Nickel vanadate anode material with high specific surface area through improved co-precipitation method: Preparation and electrochemical properties. Chinese Journal of Inorganic Chemistry, 2024, 40(11): 2163-2174. doi: 10.11862/CJIC.20240204
18. [18]
  Tingliang MAO , Zhong WANG , Wenquan JIANG , Hao WAN , Chaojian XING , Xu WU , Rong ZHANG , Zhimin REN , Yanping YIN , Ning LI , Guohua LI , Xiaohe LIU . Research progress on synthesis technology for lithium-rich manganese-based cathode materials. Chinese Journal of Inorganic Chemistry, 2026, 42(4): 668-692. doi: 10.11862/CJIC.20250319
19. [19]
  Yuanchao LI , Weifeng HUANG , Pengchao LIANG , Zifang ZHAO , Baoyan XING , Dongliang YAN , Li YANG , Songlin WANG . Effect of heterogeneous dual carbon sources on electrochemical properties of LiMn_0.8Fe_0.2PO₄/C composites. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 751-760. doi: 10.11862/CJIC.20230252
20. [20]
  Xinpeng LIU , Liuyang ZHAO , Hongyi LI , Yatu CHEN , Aimin WU , Aikui LI , Hao HUANG . Ga₂O₃ coated modification and electrochemical performance of Li_1.2Mn_0.54Ni_0.13Co_0.13O₂ cathode material. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1105-1113. doi: 10.11862/CJIC.20230488

Get Citation

PDF

XML

Metrics

PDF Downloads(5)
Abstract views(2326)
HTML views(383)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142