Citation: LIU Yide, CHEN Jialian, LI Hongzhou, YANG Songwei, LUO Fubin, CHEN Qinghua. Flame Retardant Properties of Synergistic Flame Retardant Polypropylene[J]. Chinese Journal of Applied Chemistry, ;2019, 36(10): 1165-1171. doi: 10.11944/j.issn.1000-0518.2019.10.190184 shu

Flame Retardant Properties of Synergistic Flame Retardant Polypropylene

LIU Yide ^a,b ,
CHEN Jialian ^a,d ,
LI Hongzhou ^a,, ,
YANG Songwei ^a,b ,
LUO Fubin ^a ,
CHEN Qinghua ^a,b,c

a.
College of Environmental Science and Engineering, Fujian Normal University, Fuzhou 350007, China
b.
Polymer Resources Green Recycling Engineering Research Center of the Ministry of Education, Fuzhou 350007, China
c.
Fuqing Branch of Fujian Normal University, Fuzhou 350300, China
d.
Quangang Petrochemical Research Institute of Fujian Normal University, Quanzhou, Fujian 362000, China

Corresponding author: LI Hongzhou, lihongzhou@fjnu.edu.cn
Received Date: 3 July 2019
Revised Date: 15 August 2019
Accepted Date: 3 September 2019

Fund Project: Supported by the Foundation of Quangang Petrochemical Research Institute, Fujian Normal University(No.2018YJY03)the Foundation of Quangang Petrochemical Research Institute, Fujian Normal University 2018YJY03

Figures(6)

In this paper, the synergistic flame retardant system with ammonium polyphosphate (APP) as the main flame retardant, aluminum hypophosphite (AHP) and melamine cyanurate (MCA) as auxiliary flame retardants was investigated for the flame retardant performance of polypropylene (PP). The flame retardant properties of the prepared flame retardant samples were analyzed by vertical burning test, limiting oxygen index (LOI) test, thermogravimetric analysis, cone calorimeter test and scanning electron microscopy. The results show that the addition of 30% mass fraction of any flame retardant alone can not achieve good flame retardant properties of PP. When the total mass fraction of additives is kept at 30%, mass ratio APP:AHP:MCA=4:1:1, the ideal flame retardancy is obtained, LOI of the flame retardant PP is 33%, the vertical burning test reaches Ⅴ-0 level, and the peak heat release rate (PHRR) is reduced from 765.7 kW/m² to 122.7 kW/m².
- polypropylene,
- synergistic system,
- cone calorimetry,
- flame retardancy
1. [1]
  AN Fangcheng. Development Status and Market Analysis of Polypropylene Industry[J]. Chem Ind Chem Eng Prog, 2012,31(1):246-251.
2. [2]
  LIAO Kairong, LU Zejian, WANG Jian. Modification of Ammonium Polyphosphate and Flame Retardant Effect on Polypropylene[J]. Polym Mater Sci Eng, 1998,14(4):88-93.
3. [3]
  GUAN Yahui, WANG Xiuli, DENG Cong. Research of Flame Retardant Modification of Polypropylene Wood-Plastic Composites Based on Aluminum Phosphate[J]. Chem Res Appl, 2019,31(1):88-89.
4. [4]
  HUANG Weiguang. Application Status and Prospects of Flame Retardants[N]. Sichuan Economic Daily, 2017-12-06(006)(in Chinese).
5. [5]
  ZHANG Yue. Market Analysis of Flame Retardants at Domestic and Foreign[J]. Fine Spec Chem, 2014,22(8):20-24. doi: 10.3969/j.issn.1008-1100.2014.08.004
6. [6]
  Liang J Z, Zhang Y J. A Study of the Flame-Retardant Properties of Polypropylene/Al(OH)₃/Mg(OH)₂, Composites[J]. Polym Int, 2010,59(4):539-542. doi: 10.1002/pi.2733
7. [7]
  Xu M J, Wang J, Ding Y H. Synergistic Effects of Aluminum Hypophosphite on Intumescent Flame Retardant Polypropylene System[J]. Chinese J Polym Sci, 2015,33(2):318-328. doi: 10.1007/s10118-015-1588-0
8. [8]
  YUAN Yizhong. Synthesis of New Halogen-Free Flame Retardant of Melamine Cyanurate(MCA) Containing Silicone and Application in Polypropylene[J]. Zhejiang Chem Ind, 2013,44(9):27-29. doi: 10.3969/j.issn.1006-4184.2013.09.008
9. [9]
  Horst B, Wolfram S. Reactions of Methyl(phenyl)silylene with CO and PH₃-the Formation of Acid-Base Complexes[J]. J Organomet Chem, 2002,641:156-164. doi: 10.1016/S0022-328X(01)01363-8
10. [10]
  WANG Jing. Effect of Aluminum Hypophosphite on Expanded Flame Retardant Polypropylene System[D]. Northeast Forest University, 2012(in Chinese).
11. [11]
  HE Xiaofang, ZHANG Cong, DAI Xin. Research Progress in Application of Ammonium Polyphosphate Intumescent Flame Retardants for Polymer[J]. Plast Add, 2011(2):14-17. doi: 10.3969/j.issn.1672-6294.2011.02.004
12. [12]
  Du B X, Guo Z H, Fang Z P. Effects of Organo-Clay and Sodium Dodecyl Sulfonate Intercalated Layered Double Hydroxide on Thermal and Flame Behavior of Intumescent Flame Retarded Polypropylene[J]. Polym Degrad Stab, 2009,94:1979-1985. doi: 10.1016/j.polymdegradstab.2009.07.024
1. [1]
  Zijian Zhao , Yanxin Shi , Shicheng Li , Wenhong Ruan , Fang Zhu , Jijun Jiang . A New Exploration of the Preparation of Polyacrylic Acid by Free Radical Polymerization Based on the Concept of Green Chemistry. University Chemistry, 2024, 39(5): 315-324. doi: 10.3866/PKU.DXHX202311094
2. [2]
  Junke LIU , Kungui ZHENG , Wenjing SUN , Gaoyang BAI , Guodong BAI , Zuwei YIN , Yao ZHOU , Juntao LI . Preparation of modified high-nickel layered cathode with LiAlO₂/cyclopolyacrylonitrile dual-functional coating. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1461-1473. doi: 10.11862/CJIC.20240189
3. [3]
  Peng XU , Shasha WANG , Nannan CHEN , Ao WANG , Dongmei YU . Preparation of three-layer magnetic composite Fe₃O₄@polyacrylic acid@ZiF-8 for efficient removal of malachite green in water. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 544-554. doi: 10.11862/CJIC.20230239
4. [4]
  Guojie Xu , Fang Yu , Yunxia Wang , Meng Sun . Introduction to Metal-Catalyzed β-Carbon Elimination Reaction of Cyclopropenones. University Chemistry, 2024, 39(8): 169-173. doi: 10.3866/PKU.DXHX202401060
5. [5]
  Zhuoyan Lv , Yangming Ding , Leilei Kang , Lin Li , Xiao Yan Liu , Aiqin Wang , Tao Zhang . Light-Enhanced Direct Epoxidation of Propylene by Molecular Oxygen over CuO_x/TiO₂ Catalyst. Acta Physico-Chimica Sinica, 2025, 41(4): 100038-. doi: 10.3866/PKU.WHXB202408015
6. [6]
  Zongpei Zhang , Yanyang Li , Yanan Si , Kai Li , Shuangquan Zang . Developing a Chemistry Experiment Center Employing a Multifaceted Approach to Serve High-Quality Laboratory Education. University Chemistry, 2024, 39(7): 13-19. doi: 10.12461/PKU.DXHX202404041
7. [7]
  Xingyang LI , Tianju LIU , Yang GAO , Dandan ZHANG , Yong ZHOU , Meng PAN . A superior methanol-to-propylene catalyst: Construction via synergistic regulation of pore structure and acidic property of high-silica ZSM-5 zeolite. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1279-1289. doi: 10.11862/CJIC.20240026
8. [8]
  Jinglun Wang , Hu Zhou , Baishu Zheng , Guobin Li , Ming Yue , Zhihua Zhou . Exploration and Practice of “Four Cooperations and Four Integrations” to Cultivate Innovative Talents in Chemical Materials in Local Colleges. University Chemistry, 2024, 39(7): 93-98. doi: 10.12461/PKU.DXHX202405013
9. [9]
  Zhuo WANG , Junshan ZHANG , Shaoyan YANG , Lingyan ZHOU , Yedi LI , Yuanpei LAN . Preparation and photocatalytic performance of CeO₂-reduced graphene oxide by thermal decomposition. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1708-1718. doi: 10.11862/CJIC.20240067
10. [10]
  Yang Lv , Yingping Jia , Yanhua Li , Hexiang Zhong , Xinping Wang . Integrating the Ideological Elements with the “Chemical Reaction Heat” Teaching. University Chemistry, 2024, 39(11): 44-51. doi: 10.12461/PKU.DXHX202402059
11. [11]
  Xiaowu Zhang , Pai Liu , Qishen Huang , Shufeng Pang , Zhiming Gao , Yunhong Zhang . Acid-Base Dissociation Equilibrium in Multiphase System: Effect of Gas. University Chemistry, 2024, 39(4): 387-394. doi: 10.3866/PKU.DXHX202310021
12. [12]
  Limei CHEN , Mengfei ZHAO , Lin CHEN , Ding LI , Wei LI , Weiye HAN , Hongbin WANG . Preparation and performance of paraffin/alkali modified diatomite/expanded graphite composite phase change thermal storage material. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 533-543. doi: 10.11862/CJIC.20230312
13. [13]
  Jingke LIU , Jia CHEN , Yingchao HAN . Nano hydroxyapatite stable suspension system: Preparation and cobalt adsorption performance. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1763-1774. doi: 10.11862/CJIC.20240060
14. [14]
  Zhenyu Feng , Zhaozhen Cao , Jinhua Zhan . Exploration of Online Training System for Large-Scale Instrument in Open Laboratory of Universities. University Chemistry, 2024, 39(4): 1-6. doi: 10.3866/PKU.DXHX202311016
15. [15]
  Haiyuan Wang , Shanshan Cheng , Hui Yang . Development and Exploration of the Ideological and Political Education Framework in Applied Chemistry Postgraduate Curriculum. University Chemistry, 2024, 39(6): 72-82. doi: 10.3866/PKU.DXHX202311020
16. [16]
  Jin Yan , Chengxia Tong , Yajie Li , Yue Gu , Xuejian Qu , Shigang Wei , Wanchun Zhu , Yupeng Guo . Construction of a “Dual Support, Triple Integration” Chemical Safety Practical Education System. University Chemistry, 2024, 39(7): 69-75. doi: 10.12461/PKU.DXHX202405008
17. [17]
  Shuangyan Huan , Jianhui Jiang , Gongke Li , Wenqing Zhang , Na Li , Yi Yang , Bin Hu , Yang Tian , Shuo Wu , Sichun Zhang , Yonghai Yue , Dechen Jiang , Zengping Chen , Zhonglin Lu , Cheng Cui , Yuzhi Wang , Weihong Tan . Exploration on the Construction of Analytical Chemistry Core Curriculum in the Chemistry “101 Plan”. University Chemistry, 2024, 39(10): 22-26. doi: 10.12461/PKU.DXHX202409003
18. [18]
  Wenyi Liang , Chi Zhang , Yuxin Fang , Meiyu Lin , Yaqian Duan , Songzhang Shen , Juan Su . Construction and Practice of a Safety Education System on “Teaching-Examination Linkage” in Chemical Laboratories. University Chemistry, 2024, 39(10): 330-336. doi: 10.12461/PKU.DXHX202404127
19. [19]
  Yan Yuan , Haitao Wu , Yi Zhang , Li Jiang , Feng Cao , Yanmao Dong . Research on the Talent Training System to Enhance the Core Competence of Employment for Undergraduate Students Majoring in Materials Chemistry. University Chemistry, 2024, 39(11): 52-56. doi: 10.12461/PKU.DXHX202402015
20. [20]
  Yanting HUANG , Hua XIANG , Mei PAN . Construction and application of multi-component systems based on luminous copper nanoclusters. Chinese Journal of Inorganic Chemistry, 2024, 40(11): 2075-2090. doi: 10.11862/CJIC.20240196

Get Citation

PDF

XML

Metrics

PDF Downloads(14)
Abstract views(1071)
HTML views(325)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142