Citation: LIU Zongzhang, ZHANG Tong, XU Yuchao, JIANG Haoxi, ZHANG Minhua. Preparation of MgO/SBA-15 Catalyst and Its Catalytic Performance for the Synthesis of 1, 3-Butadiene from Ethanol[J]. Chinese Journal of Applied Chemistry, ;2019, 36(2): 176-181. doi: 10.11944/j.issn.1000-0518.2019.02.180157 shu

Preparation of MgO/SBA-15 Catalyst and Its Catalytic Performance for the Synthesis of 1, 3-Butadiene from Ethanol

^aKey Laboratory for Green Chemical Technology of Ministry of Education, R & D Center for Petrochemical Technology; ^bCollaborative Innovation Center of Chemical Science and Engineering, Tianjin University, Tianjin 300072, China

Corresponding author: ZHANG Minhua,
Received Date: 7 May 2018
Revised Date: 5 June 2018
Accepted Date: 19 July 2018

Figures(5)

The novel MgO/SBA-15 catalysts were prepared via impregnation of magnesium oxide onto the SBA-15 zeolite support. The effect of MgO content on the structure, physic-chemical properties and catalytic performances of catalysts was studied by Brunauer-Emmett-Teller(BET) measurement, X-ray diffraction(XRD), transmission electron microscopy(TEM), ²⁹Si NMR(nuclear magnetic resonance) spectroscopy, NH₃-TPD(temperature programmed desorption) and CO₂-TPD. It is found that the catalyst with 20% mass fraction of MgO can form well-dispersed MgO in the inner pores of SBA-15 zeolite and the Mg-O-Si structure between MgO and SBA-15, which is beneficial to the production of 1, 3-butadiene. Under the optimal reaction conditions of 350℃ and feed weight hourly space velocity of 2.64 h^-1, the best catalytic performance is obtained with the ethanol conversion of 55.8% and the 1, 3-butadiene selectivity of 80.2%. The MgO/SBA-15 catalyst has potential applications in the production of butadiene from ethanol.
- MgO/SBA-15 catalyst,
- ethanol,
- 1, 3-butadiene
1. [1]
  Huang X X, Men Y, Wang J G. Highly Active and Selective Binary MgO-SiO₂ Catalysts for the Production of 1, 3-Butadiene from Ethanol[J]. Catal Sci Technol, 2017,7(1):168-180. doi: 10.1039/C6CY02091G
2. [2]
  Angelici C, Velthoen M E Z, Weckhuysen B M. Influence of Acid-Base Properties on the Lebedev Ethanol-to-Butadiene Process Catalyzed by SiO₂-MgO Materials[J]. Catal Sci Technol, 2015,5(5):2869-2879. doi: 10.1039/C5CY00200A
3. [3]
  Niiyama H, Morii S, Echigoya E. Butadiene Formation from Ethanol over Silica-Magnesia Catalysts[J]. Bull Chem Soc Jpn, 2006,45(3):655-659.
4. [4]
  Chung S H, Angelici C, Hinterding S O M. Role of Magnesium Silicates in Wet-Kneaded Silica-Magnesia Catalysts for the Lebedev Ethanol-to-Butadiene Process[J]. ACS Catal, 2016,6(6):4034-4045. doi: 10.1021/acscatal.5b02972
5. [5]
  Janssens W, Makshina E V, Vanelderen P. Ternary Ag/MgO-SiO₂ Catalysts for the Conversion of Ethanol into Butadiene[J]. ChemSusChem, 2015,8(6):994-1008. doi: 10.1002/cssc.v8.6
6. [6]
  Cheong J L, Shao Y L, Tan S J R. Highly Active and Selective Zr/MCF Catalyst for Production of 1, 3-Butadiene from Ethanol in a Dual Fixed Bed Reactor System[J]. ACS Sustain Chem Eng, 2016,4(9):4887-4894. doi: 10.1021/acssuschemeng.6b01193
7. [7]
  Wang R, Liu X W, He Y. The Humidity-Sensitive Property of MgO-SBA-15 Composites in One-Pot Synthesis[J]. Actuator B-Chem, 2010,145(1):386-393. doi: 10.1016/j.snb.2009.12.025
8. [8]
  Chae H J, Kim T W, Moon Y K. Butadiene Production from Bioethanol and Acetaldehyde over Tantalum Oxide-Supported Ordered Mesoporous Silica Catalysts[J]. Appl Catal B-Environ, 2014,150(1641):596-604.
9. [9]
  Maciel G E, Sindorf D W. Silicon-29 NMR Study of the Surface of Silica Gel by Cross Polarization and Magic-Angle Spinning[J]. J Am Chem Soc, 1980,102(25):7606-7607. doi: 10.1021/ja00545a056
10. [10]
  Zhu Q Q, Wang B, Tan T W. Conversion of Ethanol and Acetaldehyde to Butadiene over MgO-SiO₂ Catalysts:Effect of Reaction Parameters and Interaction Between MgO and SiO₂ on Catalytic Performance[J]. ACS Sustain Chem Eng, 2017,5(1):722-733. doi: 10.1021/acssuschemeng.6b02060
11. [11]
  Ordomsky V V, Sushkevich V L, Ivanova I I. Study of Acetaldehyde Condensation Chemistry over Magnesia and Zirconia Supported on Silica[J]. J Mol Catal A-Chem, 2010,333(1/2):85-93.
1. [1]
  Tong Zhou , Liyi Xie , Chuyu Liu , Xiyan Zheng , Bao Li . Between Sobriety and Intoxication: The Fascinating Journey of Sauce-Flavored Latte. University Chemistry, 2024, 39(9): 55-58. doi: 10.12461/PKU.DXHX202312048
2. [2]
  Siwei Lv , Tantian Tan , Xinyue Li , Siyan Zhang , Mingyuan Zhang , Minghao Li , Hangshuo Guo , Zhaorong Li , Liangjie Dong , Fengshuo Zhang , Junlong Zhao . Competition of the “King of Transboundary Medicine”. University Chemistry, 2024, 39(9): 102-108. doi: 10.12461/PKU.DXHX202403034
3. [3]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
4. [4]
  Juntao Yan , Liang Wei . 2D S-Scheme Heterojunction Photocatalyst. Acta Physico-Chimica Sinica, 2024, 40(10): 2312024-. doi: 10.3866/PKU.WHXB202312024
5. [5]
  Zhuoming Liang , Ming Chen , Zhiwen Zheng , Kai Chen . Multidimensional Studies on Ketone-Enol Tautomerism of 1,3-Diketones By ¹H NMR. University Chemistry, 2024, 39(7): 361-367. doi: 10.3866/PKU.DXHX202311029
6. [6]
  Yiping HUANG , Liqin TANG , Yufan JI , Cheng CHEN , Shuangtao LI , Jingjing HUANG , Xuechao GAO , Xuehong GU . Hollow fiber NaA zeolite membrane for deep dehydration of ethanol solvent by vapor permeation. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 225-234. doi: 10.11862/CJIC.20240224
7. [7]
  Juan WANG , Zhongqiu WANG , Qin SHANG , Guohong WANG , Jinmao LI . NiS and Pt as dual co-catalysts for the enhanced photocatalytic H₂ production activity of BaTiO₃ nanofibers. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1719-1730. doi: 10.11862/CJIC.20240102
8. [8]
  Zhiquan Zhang , Baker Rhimi , Zheyang Liu , Min Zhou , Guowei Deng , Wei Wei , Liang Mao , Huaming Li , Zhifeng Jiang . Insights into the Development of Copper-based Photocatalysts for CO₂ Conversion. Acta Physico-Chimica Sinica, 2024, 40(12): 2406029-. doi: 10.3866/PKU.WHXB202406029
9. [9]
  Hailang JIA , Hongcheng LI , Pengcheng JI , Yang TENG , Mingyun GUAN . Preparation and performance of N-doped carbon nanotubes composite Co₃O₄ as oxygen reduction reaction electrocatalysts. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 693-700. doi: 10.11862/CJIC.20230402
10. [10]
  Wei Zhong , Dan Zheng , Yuanxin Ou , Aiyun Meng , Yaorong Su . K原子掺杂高度面间结晶的g-C₃N₄光催化剂及其高效H₂O₂光合成. Acta Physico-Chimica Sinica, 2024, 40(11): 2406005-. doi: 10.3866/PKU.WHXB202406005
11. [11]
  Jingzhao Cheng , Shiyu Gao , Bei Cheng , Kai Yang , Wang Wang , Shaowen Cao . 4-氨基-1H-咪唑-5-甲腈修饰供体-受体型氮化碳光催化剂的构建及其高效光催化产氢研究. Acta Physico-Chimica Sinica, 2024, 40(11): 2406026-. doi: 10.3866/PKU.WHXB202406026
12. [12]
  Lina Guo , Ruizhe Li , Chuang Sun , Xiaoli Luo , Yiqiu Shi , Hong Yuan , Shuxin Ouyang , Tierui Zhang . 层状双金属氢氧化物的层间阴离子对衍生的Ni-Al₂O₃催化剂光热催化CO₂甲烷化反应的影响. Acta Physico-Chimica Sinica, 2025, 41(1): 2309002-. doi: 10.3866/PKU.WHXB202309002
13. [13]
  Yinwu Su , Xuanwen Zheng , Jianghui Du , Boda Li , Tao Wang , Zhiyan Huang . Green Synthesis of 1,3-Dibromoacetone Using Halogen Exchange Method: Recommending a Basic Organic Synthesis Teaching Experiment. University Chemistry, 2024, 39(5): 307-314. doi: 10.3866/PKU.DXHX202311092
14. [14]
  Kun WANG , Wenrui LIU , Peng JIANG , Yuhang SONG , Lihua CHEN , Zhao DENG . Hierarchical hollow structured BiOBr-Pt catalysts for photocatalytic CO₂ reduction. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1270-1278. doi: 10.11862/CJIC.20240037
15. [15]
  Yuanyin Cui , Jinfeng Zhang , Hailiang Chu , Lixian Sun , Kai Dai . Rational Design of Bismuth Based Photocatalysts for Solar Energy Conversion. Acta Physico-Chimica Sinica, 2024, 40(12): 2405016-. doi: 10.3866/PKU.WHXB202405016
16. [16]
  Dan Li , Hui Xin , Xiaofeng Yi . Comprehensive Experimental Design on Ni-based Catalyst for Biofuel Production. University Chemistry, 2024, 39(8): 204-211. doi: 10.3866/PKU.DXHX202312046
17. [17]
  Zhanggui DUAN , Yi PEI , Shanshan ZHENG , Zhaoyang WANG , Yongguang WANG , Junjie WANG , Yang HU , Chunxin LÜ , Wei ZHONG . Preparation of UiO-66-NH₂ supported copper catalyst and its catalytic activity on alcohol oxidation. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 496-506. doi: 10.11862/CJIC.20230317
18. [18]
  Yang WANG , Xiaoqin ZHENG , Yang LIU , Kai ZHANG , Jiahui KOU , Linbing SUN . Mn single-atom catalysts based on confined space: Fabrication and the electrocatalytic oxygen evolution reaction performance. Chinese Journal of Inorganic Chemistry, 2024, 40(11): 2175-2185. doi: 10.11862/CJIC.20240165
19. [19]
  Yihao Zhao , Jitian Rao , Jie Han . Synthesis and Photochromic Properties of 3,3-Diphenyl-3H-Naphthopyran: Design and Teaching Practice of a Comprehensive Organic Experiment. University Chemistry, 2024, 39(10): 149-155. doi: 10.3866/PKU.DXHX202402050
20. [20]
  Wen YANG , Didi WANG , Ziyi HUANG , Yaping ZHOU , Yanyan FENG . La promoted hydrotalcite derived Ni-based catalysts: In situ preparation and CO₂ methanation performance. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 561-570. doi: 10.11862/CJIC.20230276

Get Citation

PDF

XML

Metrics

PDF Downloads(6)
Abstract views(1252)
HTML views(474)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142