Citation: ZHANG Lili, DING Huimin, ZHANG Jitang, XU Donghua, LI Zhifeng. Thermal Conductivity and Flame Retardancy of Carbon Nanotube Modified Epoxy Resin[J]. Chinese Journal of Applied Chemistry, ;2017, 34(1): 46-53. doi: 10.11944/j.issn.1000-0518.2017.01.160178 shu

Thermal Conductivity and Flame Retardancy of Carbon Nanotube Modified Epoxy Resin

a.
Changchun Faway-Johnson Controls, Changchun 130033, China
b.
State Key Laboratory of Polymer Physics and Chemistry, Changchun Institute of Applied Chemistry, Chinese Academy of Sciences, Changchun 130022, China

Corresponding author: ZHANG Lili, lili.zhang@jci.com
Received Date: 27 April 2016
Revised Date: 20 June 2016
Accepted Date: 13 July 2016

Fund Project: Supported by the National Natural Science Foundation of China No. 21274152

Figures(6)

Epoxy resin(EP) nanocomposites have been regarded as high performance materials with the advantages of organic polymers, inorganic materials and nanoparticles. Herein, DGEBA/MWCNTs nanocomposites were prepared based on diglycidyl ether of bisphenol-A(DGEBA), methylhexahydrophthalic anhydride(MHHPA) as curing agent, and multi-walled carbon nanotubes(MWCNTs) as additive.The effect of MWCNTs(mass fraction less than 1.5%) on thermal and flame retardancy of DGEBA epoxy resin was explored by DGEBA/MWCNTs nanocomposites structure, thermal properties, thermal conductivity and cone calorimeter analysis. MWCNTs formed cluster when their mass fraction is 1.5%. With increasing the content of MWCNTs, the glass transition temperature(T_g) and the temperature at which 5% mass loss of the composites increase initially and then decrease, at the same time the residual carbon content increases. Thermal conductivity of the composite exhibits a trend of rising initially and then decreasing afterwards. The maximal thermal conductivity appears when the mass fraction of MWCNTs reaches 1%. The total heat release volume of these composites decreases and the total volume of smoke release increases compared to those of epoxy resin. Cone calorimeter tests show that the incorporation of MWCNTs into epoxy thermosets can improve its flame retardancy to some extent.
- epoxy resin,
- multi-walled carbon nanotubes,
- thermal conductivity,
- flame retardancy
1. [1]
  Ray S S, Okamoto M. Polymer/layered Silicate Nanocomposites:A Review from Preparation to Processing[J]. Prog Polym Sci, 2003,28(11):1539-1541. doi: 10.1016/j.progpolymsci.2003.08.002
2. [2]
  Emmanuel P G. Polymer Layered Silicate Nanocomposites[J]. Adv Mater, 1996,8(1):1-9.
3. [3]
  BI Hong, WU Xianliang, LI Minquan. Electroless Plating Preparation and Microwave Absorbing Properties of Co-coated Carbon Nanotubes/Epoxy Composite[J]. Aerosp Mater Technol, 2005,35(2):34-37.
4. [4]
  YUAN Guanming, LI Xuanke, ZHANG Mingjin. Effect of Carbon Nanotubes on the Mechanical Properties of Epoxy Resin[J]. Aerosp Mater Technol, 2005,35(2):38-41.
5. [5]
  HONG Xiaobin, XIE Kai, XIAO Jiayu. Curing Reaction of Organic Silane Modified Bisphenol F Epoxy Resin[J]. Chinese J Appl Chem, 2007,24(11):1264-1267.
6. [6]
  Park S J, Jeong H J, Nah C. A Study of Oxyfluorination of Multi-walled Carbon Nanotubes on MechanicalInterfacial Properties of Epoxy Matrix Nanocomposites[J]. Mater Sci Eng A, 2004,38(1):13-16.
7. [7]
  Tian L, Pinnavaia T J. Clay-reinforced Epoxy Nanocomposites[J]. Chem Mater, 2002,52(9):2216-2219.
8. [8]
  Lebaron P C, Wang Z, Pinnavaia T J. Polymer-layered Silicate Nanocomposites:An Overview[J]. Appl Clay Sci, 1999,15(1):11-29.
9. [9]
  WANG Jianguo. Study on the Structure and Properties of Multi-walled Carbon Nanotubes/Epoxy Resin Composites[D]. Hangzhou:Zhejiang University,2006 (in Chinese).
10. [10]
  Im J S, Lee S K, In S J. Improved Flame Retardant Properties of Epoxy Resin by Fluorinated MMT/MWCNT Additives[J]. J Anal Appl Pyrolysis, 2010,89(2):225-232. doi: 10.1016/j.jaap.2010.08.003
11. [11]
  Dutta A, Penumadu D, Files B. Nanoindentation Testing for Evaluating Modulus and Hardness of Single-walled Carbon Nanotube-reinforced Epoxy Composites[J]. J Mater Res, 2004,9(1):158-164.
12. [12]
  ZANG Pengyuan, XUE Hua, CAI Jing. Synthesis and Characterization of Multi-branch and Iron-Filled Carbon Nanotubes[J]. Chinese J Inorg Chem, 2011,27(8):1625-1629.
13. [13]
  GUO Zhansheng, DU Shanyi, ZHANG Boming. Cure Kinetics and Chemorheological Behavior of Epoxy Resin Used in Advanced Composites[J]. Acta Mater Compos Sin, 2004,21(4):146-151.
14. [14]
  ZENG Xiaoliang, LIU Jia, XIONG Yuanqin. Progress in Research on High Heat Resistance of Epoxy Resins[J]. Chem Ind Prog, 2009,28(6):986-990.
15. [15]
  HONG Bin, WANG Tianzhen. Market Analysis of Epoxy Applications[J]. Thermoset Resin, 2011,26(3):54-58.
16. [16]
  Wu K, Song L, Hu Y. Synthesis and Characterization of a Functional Polyhedral Oligomericsilses Quioxaneand Its Flame Retardancy in Epoxy Resin[J]. Prog Org Coat, 2009,65(4):490-497. doi: 10.1016/j.porgcoat.2009.04.008
17. [17]
  Mercado L A, Galià M, Reina J A. Silicon-containing Flame Retardant Epoxy Resins:Synthesis, Characterization and Properties[J]. Polym Degrad Stab, 2006,91(11):2588-2594. doi: 10.1016/j.polymdegradstab.2006.05.007
18. [18]
  Kaynak C, Nakas G I, Isitman N A. Mechanical Properties, Flammability and Char Morphology of Epoxy Resin/Montmorillonite Nanocomposites[J]. Appl Clay Sci, 2009,46(3):319-324. doi: 10.1016/j.clay.2009.08.033
19. [19]
  Kaya E, Tanoğlu M, Okur S. Layered Clay/Epoxy Nanocomposites:Thermomechanical, Flame Retardancyand Optical Properties[J]. J Appl Poly Sci, 2008,109(2):834-840. doi: 10.1002/(ISSN)1097-4628
20. [20]
  Duan J K, Kim C, Jiang P K. Nano-AlN Functionalization by Silane Modification for the Preparation of Covalent-Integrated Epoxy/Poly(ether imide) Nanocomposites[J]. J Appl Polym Sci, 2010,115(5):2734-2746. doi: 10.1002/app.v115:5
21. [21]
  ZENG Lingke, QI Xiaoling, WANG Hui. Study on the Thermal Conductivity of Oxide Thermoelectric Materials[J]. Bull Chinese Ceram Soc, 2009,28(3):525-530.
22. [22]
  XIAO Lin, LI Xiaozhao, ZHAO Xiaobao. Laroratory of Influences of Moisture Content and Porosity on Thermal Conductivity of Soils[J]. J PLA Univ Sci Tech(Nat Sci Edn), 2008,9(3):241-247.
23. [23]
  Wei L, Kuo P K, Thomas R L. Thermal Conductivity of Isotopically Modified Single Crystal Diamond[J]. Phys Rev Lett, 1993,70(24):3764-3767. doi: 10.1103/PhysRevLett.70.3764
24. [24]
  Anthony T R, Banholzer W F, Fleiseher J F. Thermal Diffusivity of Isotopically Enriched 12 C Diamond[J]. Phys Rev B, 1990,42(2):1104-1111. doi: 10.1103/PhysRevB.42.1104
1. [1]
  Hailang JIA , Hongcheng LI , Pengcheng JI , Yang TENG , Mingyun GUAN . Preparation and performance of N-doped carbon nanotubes composite Co₃O₄ as oxygen reduction reaction electrocatalysts. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 693-700. doi: 10.11862/CJIC.20230402
2. [2]
  Haihua Yang , Minjie Zhou , Binhong He , Wenyuan Xu , Bing Chen , Enxiang Liang . Synthesis and Electrocatalytic Performance of Iron Phosphide@Carbon Nanotubes as Cathode Material for Zinc-Air Battery: a Comprehensive Undergraduate Chemical Experiment. University Chemistry, 2024, 39(10): 426-432. doi: 10.12461/PKU.DXHX202405100
3. [3]
  Bowen Yang , Rui Wang , Benjian Xin , Lili Liu , Zhiqiang Niu . C-SnO₂/MWCNTs Composite with Stable Conductive Network for Lithium-based Semi-Solid Flow Batteries. Acta Physico-Chimica Sinica, 2025, 41(2): 100015-. doi: 10.3866/PKU.WHXB202310024
4. [4]
  Xiufang Wang , Donglin Zhao , Kehua Zhang , Xiaojie Song . “Preparation of Carbon Nanotube/SnS₂ Photoanode Materials”: A Comprehensive University Chemistry Experiment. University Chemistry, 2024, 39(4): 157-162. doi: 10.3866/PKU.DXHX202308025
5. [5]
  Jie XIE , Hongnan XU , Jianfeng LIAO , Ruoyu CHEN , Lin SUN , Zhong JIN . Nitrogen-doped 3D graphene-carbon nanotube network for efficient lithium storage. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1840-1849. doi: 10.11862/CJIC.20240216
6. [6]
  Guimin ZHANG , Wenjuan MA , Wenqiang DING , Zhengyi FU . Synthesis and catalytic properties of hollow AgPd bimetallic nanospheres. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 963-971. doi: 10.11862/CJIC.20230293
7. [7]
  Yuhao SUN , Qingzhe DONG , Lei ZHAO , Xiaodan JIANG , Hailing GUO , Xianglong MENG , Yongmei GUO . Synthesis and antibacterial properties of silver-loaded sod-based zeolite. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 761-770. doi: 10.11862/CJIC.20230169
8. [8]
  Jingke LIU , Jia CHEN , Yingchao HAN . Nano hydroxyapatite stable suspension system: Preparation and cobalt adsorption performance. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1763-1774. doi: 10.11862/CJIC.20240060
9. [9]
  Weihan Zhang , Menglu Wang , Ankang Jia , Wei Deng , Shuxing Bai . 表面硫物种对钯-硫纳米片加氢性能的影响. Acta Physico-Chimica Sinica, 2024, 40(11): 2309043-. doi: 10.3866/PKU.WHXB202309043
10. [10]
  Zijian Jiang , Yuang Liu , Yijian Zong , Yong Fan , Wanchun Zhu , Yupeng Guo . Preparation of Nano Zinc Oxide by Microemulsion Method and Study on Its Photocatalytic Activity. University Chemistry, 2024, 39(5): 266-273. doi: 10.3866/PKU.DXHX202311101
11. [11]
  Zhuo WANG , Xiaotong LI , Zhipeng HU , Junqiao PAN . Three-dimensional porous carbon decorated with nano bismuth particles: Preparation and sodium storage properties. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 267-274. doi: 10.11862/CJIC.20240223
12. [12]
  Pengyang FAN , Shan FAN , Qinjin DAI , Xiaoying ZHENG , Wei DONG , Mengxue WANG , Xiaoxiao HUANG , Yong ZHANG . Preparation and performance of rich 1T-MoS₂ nanosheets for high-performance aqueous zinc ion battery cathode materials. Chinese Journal of Inorganic Chemistry, 2025, 41(4): 675-682. doi: 10.11862/CJIC.20240339
13. [13]
  Wenjiang LI , Pingli GUAN , Rui YU , Yuansheng CHENG , Xianwen WEI . C₆₀-MoP-C nanoflowers van der Waals heterojunctions and its electrocatalytic hydrogen evolution performance. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 771-781. doi: 10.11862/CJIC.20230289
14. [14]
  Siyu HOU , Weiyao LI , Jiadong LIU , Fei WANG , Wensi LIU , Jing YANG , Ying ZHANG . Preparation and catalytic performance of magnetic nano iron oxide by oxidation co-precipitation method. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1577-1582. doi: 10.11862/CJIC.20230469
15. [15]
  Guangming YIN , Huaiyao WANG , Jianhua ZHENG , Xinyue DONG , Jian LI , Yi'nan SUN , Yiming GAO , Bingbing WANG . Preparation and photocatalytic degradation performance of Ag/protonated g-C₃N₄ nanorod materials. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1491-1500. doi: 10.11862/CJIC.20240086
16. [16]
  Qingtang ZHANG , Xiaoyu WU , Zheng WANG , Xiaomei WANG . Performance of nano Li₂FeSiO₄/C cathode material co-doped by potassium and chlorine ions. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1689-1696. doi: 10.11862/CJIC.20240115
17. [17]
  Juan WANG , Zhongqiu WANG , Qin SHANG , Guohong WANG , Jinmao LI . NiS and Pt as dual co-catalysts for the enhanced photocatalytic H₂ production activity of BaTiO₃ nanofibers. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1719-1730. doi: 10.11862/CJIC.20240102
18. [18]
  Haiyuan Wang , Yiming Tang , Haoran Guo , Guohui Chen , Yajing Sun , Chao Zhao , Zhen Zhang . Comprehensive Chemistry Experimental Teaching Design Based on the Integration of Science and Education: Preparation and Catalytic Properties of Silver Nanomaterials. University Chemistry, 2024, 39(10): 219-228. doi: 10.12461/PKU.DXHX202404067
19. [19]
  Yufang GAO , Nan HOU , Yaning LIANG , Ning LI , Yanting ZHANG , Zelong LI , Xiaofeng LI . Nano-thin layer MCM-22 zeolite: Synthesis and catalytic properties of trimethylbenzene isomerization reaction. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1079-1087. doi: 10.11862/CJIC.20240036
20. [20]
  Jiahong ZHENG , Jingyun YANG . Preparation and electrochemical properties of hollow dodecahedral CoNi₂S₄ supported by MnO₂ nanowires. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1881-1891. doi: 10.11862/CJIC.20240170

Get Citation

PDF

XML

Metrics

PDF Downloads(6)
Abstract views(636)
HTML views(109)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142