Citation: Runran WANG, Qiyue JIAO, Ruifang LI, Hong WANG, Hongwei WANG, Yali BAO, Qi WANG, Xiaoyan WANG. Influence of the loading methods of Ni species in Ni/CeO₂ catalysts on the performance of CO methanation[J]. Chinese Journal of Inorganic Chemistry, ;2026, 42(5): 1026-1038. doi: 10.11862/CJIC.20250364 shu

Influence of the loading methods of Ni species in Ni/CeO₂ catalysts on the performance of CO methanation

Runran WANG ^{1, #} ,
Qiyue JIAO ^{2, #} ,
Ruifang LI ¹ ,
Hong WANG ¹ ,
Hongwei WANG ¹ ,
Yali BAO ¹ ,
Qi WANG ^1,, ,
Xiaoyan WANG ^1,,

1.
College of Chemical Engineering, Inner Mongolia University of Technology, Hohhot 010051, China
2.
Emergency Management Department of Inner Mongolia Autonomous Region, Hohhot 010051, China

Corresponding author: Qi WANG, qiwang127@imut.edu.cn Xiaoyan WANG, rain20030000072@imut.edu.cn
Received Date: 8 December 2025
Revised Date: 5 March 2026

Figures(9)

To enhance the low-temperature activity and anti-sintering performance of Ni-based catalysts for CO methanation, mesoporous CeO₂ supports with a confined structure were synthesized via a hydrothermal method. The effects of three Ni loading methods—incipient wetness impregnation, co-precipitation, and bis(cyclopentadienyl)nickel sublimation—on catalytic performance were systematically compared. Characterization techniques, including X-ray diffraction (XRD), N₂ adsorption-desorption test, hydrogen temperature-programmed reduction (H₂-TPR), X-ray photoelectron spectroscopy (XPS), and transmission electron microscopy (TEM), revealed the critical influence of the loading method on Ni species dispersion, particle size, and metal-support interaction. The results indicated that all three mesoporous Ni/CeO₂ catalysts exhibited excellent anti-sintering properties due to the confinement effect of the support. However, their low-temperature activities differed significantly, primarily determined by the specific state of Ni. In the NC-B catalyst prepared by bis(cyclopentadienyl)nickel sublimation, the interaction between Ni species and the support was relatively weak. After reduction, this method yielded highly dispersed metallic Ni nanoparticles, increasing the number of low-temperature active sites. Consequently, the NC-B catalyst achieved 98% CO conversion rate and 100% CH₄ selectivity at 300 ℃, demonstrating the optimal low-temperature methanation performance.
- CO methanation,
- CeO₂,
- Ni-based catalyst,
- anti-sintering,
- metal-support interaction
1. [1]
  CHENG J L, GUO X M, MENG T, HU X, LI L, WANG Y Z, HUANG W Z. NiAlNd catalysts for CO₂ methanation derived from the layered double hydroxide precursor[J]. Chinese J. Inorg. Chem., 2024, 40(8): 1592-1602
2. [2]
  CELORIA F, SALOMONE F, TAURO A, GANDIGLIO M, FERRERO D, CHAMPON I, GEFFRAYE G, PIRONE R, BENSAID S. Kinetic study and deactivation phenomena for the methanation of CO₂ and CO mixed syngas on a Ni/Al₂O₃ catalyst[J]. Chem. Eng. J., 2025, 512: 162113 doi: 10.1016/j.cej.2025.162113
3. [3]
  LI L L, ZHANG M W, WANG Y J, FANG K G. Preparation of Fe/SAPO-34 catalyst and its catalytic performance for CO hydrogenation to light olefins[J]. Journal of Fuel Chemistry and Technology, 2025, 53(4): 504-514
4. [4]
  HUSSAIN I, JALIL A A, HASSAN N S, FAROOQ M, MUJTABA M A, HAMID M Y S, SHARIF H M A, NABGAN W, AZIZ M A H, OWGI A. Contemporary thrust and emerging prospects of catalytic systems for substitute natural gas production by CO methanation[J]. Fuel, 2022, 311: 122604 doi: 10.1016/j.fuel.2021.122604
5. [5]
  ZHANG J, JIA X Y, LIU C J. Structural effect of Ni/TiO₂ on CO methanation: Improved activity and enhanced stability[J]. RSC Adv., 2022, 12(2): 721-727 doi: 10.1039/D1RA08021K
6. [6]
  LI J X, LIANG Y F, LI Z, FAN K, WANG C X, LI K, LI Y, SUN X, NING P, WANG F. Synergistic effect of Ni and NiO in hydrogen reduction for CO methanation[J]. Sep. Purif. Technol., 2024, 335: 126178 doi: 10.1016/j.seppur.2023.126178
7. [7]
  HOU Z G, CHEN Y M, MA X, ZHOU L, WANG W, QIU J S, ZHANG Y. Cerium-promoted Ni/SiO₂ catalyst for CO methanation[J]. Can. J. Chem. Eng., 2023, 101(12): 7068-7077 doi: 10.1002/cjce.24955
8. [8]
  WANG H W, WU J X, WANG X Y, WANG H, LIU J R. Formation of perovskite-type LaNiO₃ on La-Ni/Al₂O₃-ZrO₂ catalysts and their performance for CO methanation[J]. Journal of Fuel Chemistry and Technology, 2021, 49(2): 186-197
9. [9]
  XIA Y H, SHEN W H, WANG J, FANG Y J. Study on selective CO methanation over Ni/W‑Al₂O₃ catalyst in hydrogen‑rich gas[J]. Modern Chemical Industry, 2023, 43(6): 150-154
10. [10]
  LI Y T, SHEN C Y, JIANG C Y, LIANG C J, CHEN B W, DING W P, GUO X F. Surrounded Ni@Al₂O₃ as a robust catalyst for CO methanation: The size effect of Ni nanoparticles[J]. ACS Catal., 2025, 15: 9728-9737 doi: 10.1021/acscatal.5c01212
11. [11]
  HOU Z G, CHEN Y M, WANG C, MA X, YANG H, WANG W, ZHANG Y. The promotional effects of Mn on Ni/SiO₂ catalysts for CO methanation[J]. React. Kinet. Mech. Catal., 2023, 136(2): 587-601 doi: 10.1007/s11144-023-02377-0
12. [12]
  LI X L, ZHANG X N, DU Z Z, HAN F X, FAN Z H, ZHANG S K, ZHANG Z Z, TU W F, HAN Y F. Study on the variation law of electron-rich Ni atoms at the Ni-CeO₂ interface and its mechanism for promoting CO methanation[J]. Chin. J. Catal., 2025, 74(7): 177-190
13. [13]
  REN J, LEI H, MEBRAHTU C C, ZENG F, ZHENG X S, PEI G, ZHANG W H, WANG Z D. Ni-based hydrotalcite-derived catalysts for enhanced CO₂ methanation: Thermal tuning of the metal-support interaction[J]. Appl. Catal. B‒Environ., 2024, 340: 123245 doi: 10.1016/j.apcatb.2023.123245
14. [14]
  TAPIA J, OSTOS C, MENDOZA C, ARBOLEDA J, ECHAVARRIA A. Effect of the Ni/CeO₂ mesoporous structure on the proper balance of active sites present for CO₂ methanation: An in-situ NAP-XPS study[J]. Environ. Technol. Innov., 2024, 35: 103713 doi: 10.1016/j.eti.2024.103713
15. [15]
  HAN Y H, ZHAO J X, QUAN Y H, YIN S N, WU S P, REN J. Highly efficient La_xCe_1-xO_2-x/2 nanorod-supported nickel catalysts for CO methanation: Effect of La addition[J]. Energy Fuels, 2021, 35(4): 3307-3314 doi: 10.1021/acs.energyfuels.0c04008
16. [16]
  LI F, SU W T, FANG Y Y, YAO K, SUN Y, DAI C Y, ZHAO B R. Enhancement in the activity and selectivity of Co/CeO₂ for CO₂ methanation by the design of Co-O-Ce structure[J]. Chem. Eng. J., 2025: 166365
17. [17]
  LI J W, DU C C, FENG Q Y, ZHAO Y R, LIU S X, XU J L, HU M, ZENG Z Z, ZHANG Z, SHEN H X, ZHANG Y X, ZHU J Q, ZHANG L J, ZHAO W, HUANG J Y, XIONG H F. Evolution and performances of Ni single atoms trapped by mesoporous ceria in dry reforming of methane[J]. Appl. Catal. B‒Environ., 2024, 354: 124069 doi: 10.1016/j.apcatb.2024.124069
18. [18]
  ATZORI L, ROMBI E, MELONI D, MONACI R, SINI M F, CUTRUFELLO M G. Nanostructured Ni/CeO₂-ZrO₂ catalysts for CO₂ conversion into synthetic natural gas[J]. J. Nanosci. Nanotechnol., 2019, 19(6): 3269-3276 doi: 10.1166/jnn.2019.16612
19. [19]
  EVTUSHKOVA A, HEINRICHS J M J J, KOSINOV N, HENSEN E J M. CO₂ methanation of Co/CeO₂ prepared by wetness impregnation of Co on flame-synthesized CeO₂[J]. ChemCatChem, 2025, 17(17): e00679 doi: 10.1002/cctc.202500679
20. [20]
  OSTI A, COSTA S, RIZZATO L, SENONER B, GLISENTI A. Photothermal activation of methane dry reforming on perovskite-supported Ni-catalysts: Impact of support composition and Ni loading method[J]. Catal. Today, 2025, 449: 115200 doi: 10.1016/j.cattod.2025.115200
21. [21]
  NIU Y X, ZHENG X R, GUO B H, LIU H Y, JIN Y, NIU J T. Particle size tuning of Ni/CeO₂ catalysts and their performance in methane dry reforming reaction[J]. Gas Sci. Eng., 2025: 205790
22. [22]
  CHEN C C, WANG W B, REN Q H, YE R P, NIE N, LIU Z, ZHANG L L, XIA J B. Impact of preparation method on nickel speciation and methane dry reforming performance of Ni/SiO₂ catalysts[J]. Front. Chem., 2022, 10: 993691 doi: 10.3389/fchem.2022.993691
23. [23]
  KUMAR S, JAIN A, MIYAOKA H, ICHIKAWA T, KOJIMA Y. Catalytic effect of bis (cyclopentadienyl) nickel Ⅱ on the improvement of the hydrogenation-dehydrogenation of Mg-MgH₂ system[J]. Int. J. Hydrog. Energy, 2017, 42(27): 17178-17183 doi: 10.1016/j.ijhydene.2017.05.090
24. [24]
  JIANG H P, LI X, CHEN S T, WANG H Q, HUO P W. g-C₃N₄ quantum dots-modified mesoporous CeO₂ composite photocatalyst for enhanced CO₂ photoreduction[J]. J. Mater. Sci. ‒Mater. Electron., 2020, 31(22): 20495-20512 doi: 10.1007/s10854-020-04568-0
25. [25]
  SHEN Y T, GAO Y K, YANG H, LU Z Y, LI M M, WU C E, WANG S, XU L L, GAO F, CHEN M D. Mesoporous CeO₂ hollow-nanosphere-supported Ni catalysts for enhanced low-temperature CO₂ methanation[J]. J. Environ. Chem. Eng., 2026, 14(2): 121136 doi: 10.1016/j.jece.2026.121136
26. [26]
  MARCONI E, TUTI S, LUISETTO I. Structure-sensitivity of CO₂ methanation over nanostructured Ni supported on CeO₂ nanorods[J]. Catalysts, 2019, 9(4): 375 doi: 10.3390/catal9040375
27. [27]
  LIN S X, LI Z H, LI M S. Tailoring metal-support interactions via tuning CeO₂ particle size for enhancing CO₂ methanation activity over Ni/CeO₂ catalysts[J]. Fuel, 2023, 333: 126369 doi: 10.1016/j.fuel.2022.126369
28. [28]
  WANG T T, TANG R, LI Z H. Enhanced CO₂ methanation activity over Ni/CeO₂ catalyst by adjusting metal-support interactions[J]. Mol. Catal., 2024, 558: 114034
29. [29]
  LIAO L, CHEN L D, YE R P, TANG X L, LIU J. Robust nickel silicate catalysts with high Ni loading for CO₂ methanation[J]. Chem. Asian J., 2021, 16(6): 678-689
30. [30]
  LIN S X, KANG L, GONG L C, TAO L G, XI S B, LI Z H, LIU W. Facet specificity of yttrium doping on CO₂ methanation over Ni/CeO₂ catalysts[J]. Chem. Eng. J., 2024, 502: 157840 doi: 10.1016/j.cej.2024.157840
31. [31]
  LI Y D, YANG Y H, HUANG Z Z, ZHOU H L, ZENG R Y, LIN X H, MA X L, WANG S C, XIANG S C, ZHANG Z J. Oxygen-vacancy-rich Ni/CeO₂: UiO-66-derived high-efficiency catalyst for low-temperature CO₂ methanation[J]. Chem. Eng. J., 2025, 511: 162073
32. [32]
  ELHAMDY W A, SAID A E A A, GODA M N, KHALIL K M S. Promotional effect of CeO₂ and Fe₂O₃ species on mesoporous silica as efficient catalysts for the vapor-phase dehydration of iso-butyl alcohol to isobutylene[J]. Appl. Catal. A‒Gen., 2025, 702: 120352 doi: 10.1016/j.apcata.2025.120352
33. [33]
  BUENO J, LOPEZ S, MARTINEZ I, MARTIN I, GUILLEN E, DIESTE V P, DAVO A, LOZANO D, BUENO A. Highly active, selective and stable Ru/NiO-CeO₂ catalyst for low-temperature CO₂ methanation[J]. Chem. Eng. J., 2025: 167951
34. [34]
  FENG W W, HOU Y, YAN J, LI G B, ZHANG H X, HUANG S, HUANG T, LIU W M, ZHANG S L, PENG H G. Preparation of highly dispersed Pt catalyst by CeO_x ‘islands’ modification of dendritic mesoporous SiO₂: CO as a probe molecule[J]. Catal. Today, 2024, 437: 114721
35. [35]
  TANG R, ULLAH N, HUI Y J, LI X, LI Z H. Enhanced CO₂ methanation activity over Ni/CeO₂ catalyst by one-pot method[J]. Mol. Catal., 2021, 508: 111602
1. [1]
  Xiutao Xu , Chunfeng Shao , Jinfeng Zhang , Zhongliao Wang , Kai Dai . Rational Design of S-Scheme CeO₂/Bi₂MoO₆ Microsphere Heterojunction for Efficient Photocatalytic CO₂ Reduction. Acta Physico-Chimica Sinica, 2024, 40(10): 2309031-0. doi: 10.3866/PKU.WHXB202309031
2. [2]
  Peng Li , Yuanying Cui , Zhongliao Wang , Graham Dawson , Chunfeng Shao , Kai Dai . Efficient interfacial charge transfer of CeO₂/Bi₁₉Br₃S₂₇ S-scheme heterojunction for boosted photocatalytic CO₂ reduction. Acta Physico-Chimica Sinica, 2025, 41(6): 100065-0. doi: 10.1016/j.actphy.2025.100065
3. [3]
  Yanzhe WANG , Xiaoming GUO , Qiangsheng GUO , Liang LI , Bin LU , Peihang YE . Effect of Ce introduction on the low-temperature performance of NiAl catalyst for CO₂ methanation. Chinese Journal of Inorganic Chemistry, 2025, 41(11): 2218-2228. doi: 10.11862/CJIC.20250202
4. [4]
  Ronghui LI . Photocatalysis performance of nitrogen-doped CeO₂ thin films via ion beam-assisted deposition. Chinese Journal of Inorganic Chemistry, 2025, 41(6): 1123-1130. doi: 10.11862/CJIC.20240440
5. [5]
  Kailu Guo , Jinzhi Jia , Huijiao Wang , Ziyu Hao , Yinjian Chen , Ke Shi , Haixia Wu , Cailing Xu . Structural tuning and reconstruction of CeO₂-coupled nickel selenides for robust water oxidation. Chinese Chemical Letters, 2025, 36(8): 110888-. doi: 10.1016/j.cclet.2025.110888
6. [6]
  Doudou Liu , Weiwei Guo , Guoliang Mei , Youpeng Dan , Rong Yang , Chao Huang , Yanling Zhai , Xiaoquan Lu . Application of catalyst Cu-t-ZrO₂ based on the electronic metal-support interaction in electrocatalytic nitrate reduction. Chinese Chemical Letters, 2025, 36(8): 110578-. doi: 10.1016/j.cclet.2024.110578
7. [7]
  Yufeng ZHANG , Haotian QI , Jingya ZHONG , Leiming LANG , Guojun YUAN , Siqi LU , Haiying WANG , Guangxiang LIU . S-anion effects on the improvement of adsorption capacity and performance for benzyl alcohol electro-oxidation catalysts. Chinese Journal of Inorganic Chemistry, 2025, 41(12): 2591-2600. doi: 10.11862/CJIC.20250282
8. [8]
  Jinli Chen , Shouquan Feng , Tianqi Yu , Yongjin Zou , Huan Wen , Shibin Yin . Modulating Metal-Support Interaction Between Pt3Ni and Unsaturated WOx to Selectively Regulate the ORR Performance. Chinese Journal of Structural Chemistry, 2023, 42(10): 100168-100168. doi: 10.1016/j.cjsc.2023.100168
9. [9]
  Chenye An , Sikandaier Abiduweili , Xue Guo , Yukun Zhu , Hua Tang , Dongjiang Yang . Hierarchical S-scheme Heterojunction of Red Phosphorus Nanoparticles Embedded Flower-like CeO₂ Triggering Efficient Photocatalytic Hydrogen Production. Acta Physico-Chimica Sinica, 2024, 40(11): 2405019-0. doi: 10.3866/PKU.WHXB202405019
10. [10]
  Zhuo WANG , Junshan ZHANG , Shaoyan YANG , Lingyan ZHOU , Yedi LI , Yuanpei LAN . Preparation and photocatalytic performance of CeO₂-reduced graphene oxide by thermal decomposition. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1708-1718. doi: 10.11862/CJIC.20240067
11. [11]
  Xinyu Xu , Jiale Lu , Bo Su , Jiayi Chen , Xiong Chen , Sibo Wang . Steering charge dynamics and surface reactivity for photocatalytic selective methane oxidation to ethane over Au/Ti-CeO₂. Acta Physico-Chimica Sinica, 2025, 41(11): 100153-0. doi: 10.1016/j.actphy.2025.100153
12. [12]
  Dan Li , Hui Xin , Xiaofeng Yi . Comprehensive Experimental Design on Ni-based Catalyst for Biofuel Production. University Chemistry, 2024, 39(8): 204-211. doi: 10.3866/PKU.DXHX202312046
13. [13]
  Yunxia Liu , Guandong Wu , Lin Li , Yiming Niu , Bingsen Zhang , Botao Qiao , Junhu Wang . Construction of sintering-resistant gold catalysts via ascorbic-acid inducing strong metal-support interactions. Chinese Chemical Letters, 2025, 36(4): 110608-. doi: 10.1016/j.cclet.2024.110608
14. [14]
  Jisung Yoon , Junghum Park , Hojae Lee , Sang won Lee , Miju Ku , Junseop Lee , Jonghyuck Lee , Tae ho Shin , Young-Beom Kim . Enhancing the electrochemical performance of Ni-based electrodes via flash light sintering for metal-supported solid oxide fuel cells (MS-SOFCs). Chinese Journal of Structural Chemistry, 2025, 44(12): 100758-100758. doi: 10.1016/j.cjsc.2025.100758
15. [15]
  Xiangyang Ji , Yishuang Chen , Peng Zhang , Shaojia Song , Jian Liu , Weiyu Song . Boosting the first C–H bond activation of propane on rod-like V/CeO₂ catalyst by photo-assisted thermal catalysis. Chinese Chemical Letters, 2025, 36(5): 110719-. doi: 10.1016/j.cclet.2024.110719
16. [16]
  Yinghui Pu , Yiming Niu , Tongtong Gao , Junnan Chen , Bingsen Zhang . Ammonia-directed gas-metal-support interaction forming Ni₃ZnN for efficient hydrogenation. Chinese Chemical Letters, 2026, 37(1): 111520-. doi: 10.1016/j.cclet.2025.111520
17. [17]
  Jinglin CHENG , Xiaoming GUO , Tao MENG , Xu HU , Liang LI , Yanzhe WANG , Wenzhu HUANG . NiAlNd catalysts for CO₂ methanation derived from the layered double hydroxide precursor. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1592-1602. doi: 10.11862/CJIC.20240152
18. [18]
  Hui Bian , Xinyi Yuan , Nan Zhang , Zhuo Xu , Juhong Lian , Ruibin Jiang , Junqing Yan , Deng Li , Shengzhong (Frank) Liu . Correlating vacancy-defect density with CO₂ activation for promoted CO₂ methanation over CsPbBr₃ photocatalyst. Chinese Chemical Letters, 2025, 36(7): 111034-. doi: 10.1016/j.cclet.2025.111034
19. [19]
  Kexin Yin , Jingren Yang , Yanwei Li , Qian Li , Xing Xu . Metal-free diatomaceous carbon-based catalyst for ultrafast and anti-interference Fenton-like oxidation. Chinese Chemical Letters, 2024, 35(12): 109847-. doi: 10.1016/j.cclet.2024.109847
20. [20]
  Gang Lang , Jing Feng , Bo Feng , Junlan Hu , Zhiling Ran , Zhiting Zhou , Zhenju Jiang , Yunxiang He , Junling Guo . Supramolecular phenolic network-engineered C–CeO₂ nanofibers for simultaneous determination of isoniazid and hydrazine in biological fluids. Chinese Chemical Letters, 2024, 35(6): 109113-. doi: 10.1016/j.cclet.2023.109113

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(53)
HTML views(10)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Influence of the loading methods of Ni species in Ni/CeO2 catalysts on the performance of CO methanation

Metrics

通讯作者: 陈斌, bchen63@163.com

Influence of the loading methods of Ni species in Ni/CeO₂ catalysts on the performance of CO methanation