Advanced Search

Citation: Hongli CHEN, Ziling XU, Shiwen DU, Ting WANG, Liguang WU. Controlled preparation of HKUST-1 based on polyvinylpyrrolidone and CO2 separation performance of its doped mixed-matrix membranes[J]. Chinese Journal of Inorganic Chemistry, ;2026, 42(3): 571-583. doi: 10.11862/CJIC.20250263 shu

Controlled preparation of HKUST-1 based on polyvinylpyrrolidone and CO2 separation performance of its doped mixed-matrix membranes

  • School of Environmental Science and Engineering, Zhejiang Gongshang University, Hangzhou 310012, China

  • Corresponding author: Ting WANG,  Liguang WU, wulg64@mail.zjgsu.edu.cn
  • Received Date: 11 August 2025
    Revised Date: 16 December 2025

Figures(12)

  • Polyvinylpyrrolidone (PVP) was added during solvothermal synthesis to regulate the morphology and structure of HKUST-1 crystals, which were then in situ incorporated into a polyimide (PI) matrix to fabricate mixed matrix membranes (MMMs). The morphology and structure of the HKUST-1 crystals were characterized by scanning electron microscopy (SEM), X-ray diffraction (XRD), and nitrogen adsorption-desorption test. On the basis of CO2 adsorption experiments of HKUST-1, gas permeation measurements of the MMMs, and grand canonical Monte Carlo (GCMC) simulations, the effect of HKUST-1 crystal size on the CO2 permeation performance of the MMMs was investigated, and the mechanism by which PVP regulates the CO2 separation performance of MMMs was elucidated. The results showed that, owing to the steric hindrance effect of PVP, the HKUST-1 crystals synthesized with PVP exhibited an average particle size of 1-3 μm and a specific surface area of 731-1 007 m2·g-1. Compared with HKUST-1 crystals synthesized without PVP, their average particle size was significantly reduced with a narrower size distribution and a larger specific surface area, while more Cu2+ metal sites and aromatic ring structures were exposed. This enhances the interfacial compatibility between HKUST-1 and PI, as well as the π-π interactions and Lewis acid interactions between HKUST-1 and CO2. The MMM prepared by in situ incorporation of HKUST-1 (K30), whose synthesis was regulated by K30-type PVP with a dopping amount (mass fraction) of 3%, exhibited a CO2 permeability of 142.81 Barrer [1 Barrer=7.5×10-14 cm3(STP)·cm·cm-2·s-1·Pa-1] and a CO2/N2 selectivity of 25.05, which are 76 times and 18 times those of the pristine PI membrane, respectively. These results demonstrate that tailoring the morphology of HKUST-1 crystals via PVP is an effective approach to enhancing the CO2 separation performance of MMMs.
  • 加载中
    1. [1]

      SULLIVAN I, GORYACHEV A, DIGDAYA I A, LI X Q, ATWATER H A, VERMAAS D A, XIANG C X. Coupling electrochemical CO2 conversion with CO2 capture[J]. Nat. Catal., 2021, 4(11): 952-958  doi: 10.1038/s41929-021-00699-7

    2. [2]

      KOYTSOUMPA E I, BERGINS C, KAKARAS E. The CO2 economy: Review of CO2 capture and reuse technologies[J]. J. Supercrit. Fluids, 2018, 132: 3-16  doi: 10.1016/j.supflu.2017.07.029

    3. [3]

      CHUNG T H, DHILLON S K, SHIN C, PANT D, DHAR B R. Microbial electrosynthesis technology for CO2 mitigation, biomethane production, and ex-situ biogas upgrading[J]. Biotechnol. Adv., 2024, 77: 108474  doi: 10.1016/j.biotechadv.2024.108474

    4. [4]

      PAREKH A, CHATURVEDI G, DUTTA A. Sustainability analyses of CO2 sequestration and CO2 utilization as competing options for mitigating CO2 emissions[J]. Sustain. Energy Technol. Assess., 2023, 55: 102942

    5. [5]

      STORRS K, LYHNE I, DRUSTRUP R. A comprehensive framework for feasibility of CCUS deployment: A meta-review of literature on factors impacting CCUS deployment[J]. Int. J. Greenh. Gas Control, 2023, 125: 103878  doi: 10.1016/j.ijggc.2023.103878

    6. [6]

      JIANG M Z, WANG Q, BAI J F. Research progress on low-cost ligand-based metal-organic frameworks for carbon dioxide capture from industrial flue gas[J]. Chinese J. Inorg. Chem., 2025, 41(1): 1-13  doi: 10.11862/CJIC.20240355

    7. [7]

      NI Z Q, CAO Y, ZHANG X P, ZHANG N, XIAO W, BAO J J, HE G H. Synchronous design of membrane material and process for pre-combustion CO2 capture: A superstructure method integrating membrane type selection[J]. Membranes, 2023, 13(3): 318  doi: 10.3390/membranes13030318

    8. [8]

      SADDEEQ A, KOUHI M M, KAMMAKAKAM I. Advances of ionic-mediated polymer architectures for CO2 gas separation membranes: A comprehensive review of design, progress, and future prospects[J]. ACS Omega, 2025, 10(25): 26266-26292  doi: 10.1021/acsomega.5c03166

    9. [9]

      KADIRKHAN F, GOH P S, ISMAIL A F, WAN MUSTAPA W N F, HALIM M H M, SOH W K, YEO S Y. Recent advances of polymeric membranes in tackling plasticization and aging for practical industrial CO2/CH4 applications—A review[J]. Membranes, 2022, 12(1): 71  doi: 10.3390/membranes12010071

    10. [10]

      QIN Z K, MA Y L, WEI J, GUO H F, WANG B D, DENG J, YI C H, LI N W, YI S L, DENG Y, DU W T, SHEN J, JIANG W J, YAO L, YANG L, DAI Z D. Recent progress in ternary mixed matrix membranes for CO2 separation[J]. Green Energy Environ., 2024, 9(5): 831-858  doi: 10.1016/j.gee.2023.04.008

    11. [11]

      NIU Z H, HE N Y, YAO Y F, MA A J, ZHANG E Y, CHENG L, LI Y L, LU X W. Mixed matrix membranes for gas separations: A review[J]. Chem. Eng. J., 2024, 494: 152912  doi: 10.1016/j.cej.2024.152912

    12. [12]

      XUAN X X, WANG M J, ZHANG M, KANETI Y V, XU X T, SUN X, YAMAUCHI Y. Nanoarchitectonics of low-dimensional metal- organic frameworks toward photo/electrochemical CO2 reduction reactions[J]. J. CO2 Util., 2022, 57: 101883  doi: 10.1016/j.jcou.2022.101883

    13. [13]

      WANG D Y, YAO H C, YE J S, GAO Y, CONG H L, YU B. Metal-organic frameworks (MOFs): Classification, synthesis, modification, and biomedical applications[J]. Small, 2024, 20(47): 2404350  doi: 10.1002/smll.202404350

    14. [14]

      LIU Y, DUAN X D, REN S S, GE F Y, ZHENG H G. Application of metal-organic frameworks and their derivatives for water splitting and zinc-air batteries[J]. Chinese J. Inorg. Chem., 2024, 40(1): 15-32

    15. [15]

      LI X B, GAO T Y, ZHOU Z H, JIANG J H, FENG J, CHEN L. Facile synthesis of amine-functionalized MOFs incorporated polyimide MMMs with enhanced CO2 permselectivity[J]. ChemistrySelect, 2019, 4(8): 2368-2373  doi: 10.1002/slct.201803944

    16. [16]

      ZHU W F, WANG L Z, LIANG W J, GUO R L, LI Z M. Bimetallic MOF-74-based mixed matrix membrane for efficient CO2 separation[J]. Microporous Mesoporous Mater., 2024, 379: 113288  doi: 10.1016/j.micromeso.2024.113288

    17. [17]

      VU M T, LIN R J, DIAO H, ZHU Z H, BHATIA S K, SMART S. Effect of ionic liquids (ILs) on MOFs/polymer interfacial enhancement in mixed matrix membranes[J]. J. Membr. Sci., 2019, 587: 117157  doi: 10.1016/j.memsci.2019.05.081

    18. [18]

      CUI Y C, CUI X L, YANG G, YU P Y, WANG C Z, KANG Z X, GUO H L, XIA D H. High CO2 adsorption of ultra-small Zr-MOF nanocrystals synthesized by modulation method boosts the CO2/CH4 separation performance of mixed-matrix membranes[J]. J. Membr. Sci., 2024, 689: 122174  doi: 10.1016/j.memsci.2023.122174

    19. [19]

      ASADI E, GHADIMI A, NADEALI A, NOROUZBAHARI S, HOSSEINI S S, JABBARZADEH M. Nano-sized MIL-101(Cr) MOF for CO2 separation: Crystal downsizing effects on adsorption and mixed matrix membranes[J]. J. Ind. Eng. Chem., 2025, 146: 277-292  doi: 10.1016/j.jiec.2024.11.008

    20. [20]

      LI J M, YANG J F, LI L B, LI J P. Separation of CO2/CH4 and CH4/N2 mixtures using MOF-5 and Cu3(BTC)2[J]. J. Energy Chem., 2014, 23(4): 453-460  doi: 10.1016/S2095-4956(14)60171-6

    21. [21]

      MAIA R A, LOUIS B, GAO W L, WANG Q. CO2 adsorption mechanisms on MOFs: A case study of open metal sites, ultra-microporosity and flexible framework[J]. React. Chem. Eng., 2021, 6(7): 1118-1133  doi: 10.1039/D1RE00090J

    22. [22]

      ZHANG Z M, WEI J, DENG M, YANG L, YAO L, JIANG W J, HE X Z, WANG K F, TANG J L, TANG B, ZHENG J F, DAI Z D. A pragmatic thermal treatment strategy for improved gas separation in 2D zeolite-based mixed matrix membranes[J]. Sep. Purif. Technol., 2025, 370: 133246  doi: 10.1016/j.seppur.2025.133246

    23. [23]

      DUAN Y T, LI L, SHEN Z Q, CHENG J, HE K W. Engineering metal-organic-framework (MOF)-based membranes for gas and liquid separation[J]. Membranes, 2023, 13(5): 480  doi: 10.3390/membranes13050480

    24. [24]

      SAFO I A, WERHEID M, DOSCHE C, OEZASLAN M. The role of polyvinylpyrrolidone (PVP) as a capping and structure-directing agent in the formation of Pt nanocubes[J]. Nanoscale Adv., 2019, 1(8): 3095-3106  doi: 10.1039/C9NA00186G

    25. [25]

      WANG T S, KIM H K, LIU Y J, LI W W, GRIFFITHS J T, WU Y, LAHA S, FONG K D, PODJASKI F, YUN C, KUMAR R V, LOTSCH B V, CHEETHAM A K, SMOUKOV S K. Bottom-up formation of carbon-based structures with multilevel hierarchy from MOF-guest polyhedra[J]. J. Am. Chem. Soc., 2018, 140(19): 6130-6136  doi: 10.1021/jacs.8b02411

    26. [26]

      SHAO C R, YU J G, LI X, WANG X Y, ZHU K G. Influence of the Pt nanoscale interlayer on stability and electrical property of Ti/Pt/Sb-SnO2 electrode: A synergetic experimental and computational study[J]. J. Electroanal. Chem., 2017, 804: 140-147  doi: 10.1016/j.jelechem.2017.09.057

    27. [27]

      LI B C, LIN J Y, LEE J, KWON E, THANH B X, DUAN X G, CHEN H H, YANG H T, LIN K Y A. Size-controlled nanoscale octahedral HKUST-1 as an enhanced catalyst for oxidative conversion of vanillic alcohol: The mediating effect of polyvinylpyrrolidone[J]. Colloid Surf. A-Physicochem. Eng. Asp., 2021, 631: 127639  doi: 10.1016/j.colsurfa.2021.127639

    28. [28]

      RAJAMANY R, PRAKASH S, ISMAIL Y A. Polyvinylpyrrolidone (PVP) assisted synthesis of Ni MOF: Enhanced supercapacitive performance through morphology control[J]. Next Mater., 2025, 7: 100459  doi: 10.1016/j.nxmate.2024.100459

    29. [29]

      MA X Y, WANG L, WANG H, DENG J, SONG Y L, LI Q S, LI X Y, DIETRICH A M. Insights into metal-organic frameworks HKUST-1 adsorption performance for natural organic matter removal from aqueous solution[J]. J. Hazard. Mater., 2022, 424: 126918  doi: 10.1016/j.jhazmat.2021.126918

    30. [30]

      WANG F F, CHEN J Q, SUN W Y. CuBi@Cu-MOF composite catalysts for electrocatalytic CO2 reduction to HCOOH[J]. Chinese J. Inorg. Chem., 2025, 41(1): 97-104  doi: 10.11862/CJIC.20240350

    31. [31]

      HAN B, CHAKRABORTY A. Synthesis and characteristics of ionic liquid-implanted HKUST-1 metal-organic frameworks for transforming heat into extraordinary water transfer[J]. ACS Sustain. Chem. Eng., 2024, 12(21): 8115-8127  doi: 10.1021/acssuschemeng.4c00730

    32. [32]

      GOYAL P, PARUTHI A, MENON D, BEHARA R, JAISWAL A, KEERTHY V, KUMAR A, KRISHNAN V, MISRA S K. Fe doped bimetallic HKUST-1 MOF with enhanced water stability for trapping Pb􀃭 with high adsorption capacity[J]. Chem. Eng. J., 2022, 430: 133088  doi: 10.1016/j.cej.2021.133088

    33. [33]

      MA Q, LI F, ZHANG X L, YANG B W, ZHANG Y J, WANG Q Y, WU Q H, HUANG J, HAO J M. Effective removal of thallium, recovery, and kinetic research by MnO2@HKUST-1 for wastewater[J]. Chem. Eng. J., 2024, 488: 151031  doi: 10.1016/j.cej.2024.151031

    34. [34]

      SRAN B S, KAMALAKANNAN S, HWANG J W, YOON J W, CHO K H, JO D, HAM H C, LEE S K, LEE U H. Optimized separation of C2H2 from binary mixtures of C2H2/CO2 and C2H2/C2H4 by coordinative copper􀃬 metal nodes modified from HKUST-1[J]. Chem. Eng. J., 2024, 491: 152034  doi: 10.1016/j.cej.2024.152034

    35. [35]

      YANEZ-AULESTIA A, TREJOS V M, ESPARZA-SCHULZ J M, IBARRA I A, SANCHEZ-GONZALEZ E. Chemically modified HKUST-1(Cu) for gas adsorption and separation: Mixed-metal and hierarchical porosity[J]. ACS Appl. Mater. Interfaces, 2024, 16(47): 65581-65591  doi: 10.1021/acsami.4c15059

    36. [36]

      CHEN C, WANG H J, CHEN Y P, WEI X Q, ZOU W X, WAN H, DONG L, GUAN G F. Layer-by-layer self-assembly of hierarchical flower-like HKUST-1-based composite over amino-tethered SBA-15 with synergistic enhancement for CO2 capture[J]. Chem. Eng. J., 2021, 413: 127396  doi: 10.1016/j.cej.2020.127396

    37. [37]

      FURUKAWA H, CORDOVA K E, O′KEEFFE M, YAGHI O M. The chemistry and applications of metal-organic frameworks[J]. Science, 2013, 341: 1230444  doi: 10.1126/science.1230444

    38. [38]

      HOBDAY C L, KRAUSE S, ROGGE S M J, EVANS J D, BUNZEN H. Perspectives on the influence of crystal size and morphology on the properties of porous framework materials[J]. Front. Chem., 2021, 9: 772059  doi: 10.3389/fchem.2021.772059

    39. [39]

      KEUPP J, SCHMID R. Molecular dynamics simulations of the "breathing" phase transformation of MOF nanocrystallites[J]. Adv. Theor. Simul., 2019, 2(11): 1900117  doi: 10.1002/adts.201900117

  • 加载中
    1. [1]

      Tingting Yu ,  Si Chen ,  Lianglong Sun ,  Tongtong Shi ,  Kai Sun ,  Xin Wang . Comprehensive Experimental Design for the Photochemical Synthesis, Analysis, and Characterization of Difluoropyrroles. University Chemistry, 2024, 39(11): 196-203. doi: 10.3866/PKU.DXHX202401022

    2. [2]

      Qin Cheng , Ming Huang , Qingqing Ye , Bangwei Deng , Fan Dong . Indium-based electrocatalysts for CO2 reduction to C1 products. Chinese Chemical Letters, 2024, 35(6): 109112-. doi: 10.1016/j.cclet.2023.109112

    3. [3]

      Feng-Fan Yang , Yin-Kang Ding , Lin-Kai Wu , Jiayue Tian , Shuai Dou , Wenjing Wang , Linfeng Liang . A 1,3,5-triazine μ3-bridged neutral Cu(Ⅰ) framework with enhanced stability and CO2 capture selectivity. Chinese Chemical Letters, 2025, 36(12): 110550-. doi: 10.1016/j.cclet.2024.110550

    4. [4]

      Wenwen Ma ,  Lian Kong ,  Jinyang Chu ,  Li Ma ,  Ziqing Ma ,  Heyu Cheng ,  Xinyuan Li ,  Zhan Yu ,  Zhen Zhao . Digitalization-Driven Olefin Production: Digital Design of Catalysts for CO2-Assisted Oxidation Dehydrogenation of Ethane to Ethylene. University Chemistry, 2026, 41(1): 363-372. doi: 10.12461/PKU.DXHX202506055

    5. [5]

      Jie ZHAO , Sen LIU , Qikang YIN , Xiaoqing LU , Zhaojie WANG . Theoretical calculation of selective adsorption and separation of CO2 by alkali metal modified naphthalene/naphthalenediyne. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 515-522. doi: 10.11862/CJIC.20230385

    6. [6]

      Zhipeng Bao ,  Yilin Wang ,  Yu Chen ,  Beirui Jia ,  Congcong Wang ,  Zean Xie ,  Xuehua Yu ,  Zhen Zhao . Digital and Intelligent Integration under the “Dual Carbon” Strategy: Plasma Reaction-Separation Coupling for CO2 Hydrogenation to Methanol. University Chemistry, 2026, 41(1): 29-40. doi: 10.12461/PKU.DXHX202506009

    7. [7]

      Xiyuan Zhang ,  Rui Dong ,  Yang Yang ,  Jiapeng Ding ,  Zhiwei Miao . Palladium-Catalyzed Tandem Cyclization of 4-Vinylbenzoxazinone and Indene-2-carbaldehyde: A Comprehensive Organic Chemistry Experiment. University Chemistry, 2025, 40(9): 361-367. doi: 10.12461/PKU.DXHX202410062

    8. [8]

      Xiaopei HE , Jing HAN , Zhong YU , Na YE , Yi WAN . Preparation and antimicrobial properties of polyvinyl alcohol composite film based on Ag(Ⅰ) complex. Chinese Journal of Inorganic Chemistry, 2026, 42(3): 531-542. doi: 10.11862/CJIC.20250271

    9. [9]

      Hao Ren ,  Wen Zhao ,  Fangna Dai ,  Wenyue Guo . Finite Difference Solution of One-Dimensional Quantum Systems: (1) Fundamental Concepts and Infinite Square Well. University Chemistry, 2025, 40(3): 124-131. doi: 10.12461/PKU.DXHX202405145

    10. [10]

      Zhaoxuan ZHU , Lixin WANG , Xiaoning TANG , Long LI , Yan SHI , Jiaojing SHAO . Application of poly(vinyl alcohol) conductive hydrogel electrolytes in zinc ion batteries. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 893-902. doi: 10.11862/CJIC.20240368

    11. [11]

      Hong Dong ,  Feng-Ming Zhang . Covalent organic frameworks for artificial photosynthetic diluted CO2 reduction. Chinese Journal of Structural Chemistry, 2024, 43(7): 100307-100307. doi: 10.1016/j.cjsc.2024.100307

    12. [12]

      Ping Wang ,  Tianbao Zhang ,  Zhenxing Li . Reconstruction mechanism of Cu surface in CO2 reduction process. Chinese Journal of Structural Chemistry, 2024, 43(8): 100328-100328. doi: 10.1016/j.cjsc.2024.100328

    13. [13]

      Muhammad Humayun ,  Mohamed Bououdina ,  Abbas Khan ,  Sajjad Ali ,  Chundong Wang . Designing single atom catalysts for exceptional electrochemical CO2 reduction. Chinese Journal of Structural Chemistry, 2024, 43(1): 100193-100193. doi: 10.1016/j.cjsc.2023.100193

    14. [14]

      Mingming Zhang , Ting Xu , Ruonan Yin , Xueqiu Chen , Zheng-Jun Wang , Jun Li , Xin Wang , Huile Jin , Haibo Ke , Shun Wang , Jing-Jing Lv . Anode engineering for electrocatalytic CO2 reduction reaction. Chinese Chemical Letters, 2026, 37(3): 110665-. doi: 10.1016/j.cclet.2024.110665

    15. [15]

      Zixuan Zhu , Xianjin Shi , Yongfang Rao , Yu Huang . Recent progress of MgO-based materials in CO2 adsorption and conversion: Modification methods, reaction condition, and CO2 hydrogenation. Chinese Chemical Letters, 2024, 35(5): 108954-. doi: 10.1016/j.cclet.2023.108954

    16. [16]

      Hui Bian , Xinyi Yuan , Nan Zhang , Zhuo Xu , Juhong Lian , Ruibin Jiang , Junqing Yan , Deng Li , Shengzhong (Frank) Liu . Correlating vacancy-defect density with CO2 activation for promoted CO2 methanation over CsPbBr3 photocatalyst. Chinese Chemical Letters, 2025, 36(7): 111034-. doi: 10.1016/j.cclet.2025.111034

    17. [17]

      Liang Lou , Xuncheng Liu , Yuanyu Wang , Tao Hu , Zhongjie Wang , Houqiang Shi , Junkai Xiong , Siqi Jing , Liankang Ye , Qihui Guo , Xiang Ge . Achieving reusability of leachate for multi-element recovery of the discarded LiNixCoyMn1-x-yO2 cathode by regulating the co-precipitation coefficient. Chinese Chemical Letters, 2025, 36(5): 109726-. doi: 10.1016/j.cclet.2024.109726

    18. [18]

      Xiaochun Liu , Gaoyan Chen , Xiaodong Yue , Chaoyue Wang , Xue-Xin Zhang , Xuecheng Ran , Yingxiao Zong , Junke Wang , Xicun Wang . A novel N-stable Co2P nano-catalyst for the synthesis of quinoxalines by annulation of alkynes and 1,2-diaminobenzenes. Chinese Chemical Letters, 2025, 36(8): 110707-. doi: 10.1016/j.cclet.2024.110707

    19. [19]

      Xiaofan ZHANG , Yu DUAN , Meijie SHI , Nan LU , Renhong LI , Xiaoqing YAN . Z-scheme Co3O4/BiOBr heterojunction for efficient photoreduction CO2 reduction. Chinese Journal of Inorganic Chemistry, 2025, 41(9): 1878-1888. doi: 10.11862/CJIC.20250079

    20. [20]

      Muzi Li , Xin Zhang , Xiang-Jing Kong , Qiancheng Chen , Xuefeng Bai , Tao He , Jian-Rong Li . Ion exchange for enhancing MOF adsorbents performance in humid C2H2/CO2 separation. Chinese Chemical Letters, 2026, 37(3): 110709-. doi: 10.1016/j.cclet.2024.110709

Get Citation
PDF
XML
Metrics
  • PDF Downloads(0)
  • Abstract views(4)
  • HTML views(0)

通讯作者: 陈斌, bchen63@163.com
  • 1. 

    沈阳化工大学材料科学与工程学院 沈阳 110142

  1. 本站搜索
  2. 百度学术搜索
  3. 万方数据库搜索
  4. CNKI搜索
Address：Zhongguancun North First Street 2,100190 Beijing, PR China Tel: +86-010-82449177-888
Powered By info@rhhz.net

/

DownLoad:  Full-Size Img  PowerPoint
Return