Citation: PENG Jiao-Yu, ZHANG Bo, CHEN Jing, DONG Ya-Ping, LI Wu. Crystallization Kinetics of Mg-Borates Precipitating from Diluted Boron-Containing Brine of Da Qaidam Saline Lake[J]. Chinese Journal of Inorganic Chemistry, ;2019, 35(10): 1821-1833. doi: 10.11862/CJIC.2019.209 shu

Crystallization Kinetics of Mg-Borates Precipitating from Diluted Boron-Containing Brine of Da Qaidam Saline Lake

PENG Jiao-Yu ^1,2 ,
ZHANG Bo ^1,2 ,
CHEN Jing ^1,2,3 ,
DONG Ya-Ping ^1,2,, ,
LI Wu ^1,4

1.
Key Laboratory of Comprehensive and Highly Efficient Utilization of Salt Lake Resources, Qinghai Institute of Salt Lakes, Chinese Academy of Sciences, Xining 810008, China
2.
Qinghai Engineering and Technology Research Center of Comprehensive Utilization of Salt Lake Resources, Xining 810008, China
3.
University of Chinese Academy of Sciences, Beijing 100049, China
4.
Key Laboratory of Salt Lake Resources Chemistry of Qinghai Province, Xining 810008, China

Corresponding author: DONG Ya-Ping, Dongyaping@hotmail.com
Received Date: 23 January 2019
Revised Date: 30 July 2019

Figures(7)

The crystallization kinetics of Mg-borates from different diluted brines was investigated by dynamical method. With the aid of simple optimum method and Runge-Kutta digital solution of differential equations, the experimental data was fitted by computer and the optimum kinetic equations of Mg-borates were obtained. Factors such as temperature, mass dilution ratios and boron concentrations during crystallization were tested. The crystallization rate was also calculated based on the kinetic equations. The results show that low temperature, high boron concentration and medium dilution ratio favor the Mg-borates crystallization. The boron yield would be more than 88% in B₂O₃ under the optimized condition. The kinetic parameters indicate that almost all of the crystallization mechanisms of Mg-borates in diluted brine are polynuclear layer controlled growth. Besides, the crystallization reactions in diluted solutions were also proposed.
- boron-containing brine,
- dilution,
- crystallization kinetics,
- Mg-borates
1. [1]
  GAO Shi-Yang, XU Kai-Feng, LI Gang, et al. Acta Chim. Sinica, 1986, 44:1229-1233
2. [2]
  GAO Shi-Yang, FENG Jiu-Ning. Chinese J. Inorg. Chem., 1992, 8(1):68-70
3. [3]
  GAO Shi-Yang, FU Ting-Jin, WANG Jian-Zhong. Chinese. J. Inorg. Chem., 1985, 1:97-102
4. [4]
  Peng J Y, Bian S J, Zhang B, et al. Hydrometallurgy, 2017, 174:47-55 doi: 10.1016/j.hydromet.2017.09.003
5. [5]
6. [6]
  Peng J Y, Bian S J, Lin F, et al. Phase Transitions, 2017, 90(10):1025-1033 doi: 10.1080/01411594.2017.1288230
7. [7]
  GAO Chun-Liang, YU Jun-Qing, MIN Xiu-Yun, et al. Journal of Salt Lake Research, 2015, 23(1):22-29
8. [8]
  GAO Chun-Liang, YU Jun-Qing, MIN Xiu-Yun, et al. Acta Geol. Sin., 2015, 89(3):659-670
9. [9]
  GAO Shi-Yang, LI Bing-Xiao. Acta Mineralogica Sinica, 1982(2):107-112 doi: 10.3321/j.issn:1000-4734.1982.02.004
10. [10]
  Lin F, Dong Y P, Peng J Y, et al. Phase Transitions, 2016, 89(6):558-567 doi: 10.1080/01411594.2015.1077524
11. [11]
  Peng J Y, Bian S J, Lin F, et al. Phase Transitions, 2017, 90(10):1025-1033 doi: 10.1080/01411594.2017.1288230
12. [12]
  LIU Zhi-Hong, HU Man-Cheng, GAO Shi-Yang, et al. Geochimica, 2003, 32(6):569-572 doi: 10.3321/j.issn:0379-1726.2003.06.008
13. [13]
  ZHENG Xue-Jia. Production and Application of Boron Compounds. Beijing:Chem-ical Industry Press, 2008:21-43
14. [14]
  GAO Shi-Yang, CHEN Xue-An, XIA Shu-Ping. Acta Chim. Sinica, 1990, 48:1049-1056
15. [15]
  GAO Shi-Yang, HUANG Fa-Qing, XIA Shu-Ping. Journal of Salt Lake Research, 1993, 1(1):38-48
16. [16]
  YAO Zhan-Li, GAO Shi-Yang, ZHU Li-Xia. Chinese. J. Inorg. Chem., 1995, 11(4):419-423
17. [17]
  ZHU Li-Xia, GAO Shi-Yang, XIA Shu-Ping, et al. Chinese. J. Inorg. Chem., 2000, 16(5):722-728 doi: 10.3321/j.issn:1001-4861.2000.05.004
18. [18]
  MA Yu-Tao, XIA Shu-Ping, GAO Shi-Yang. Chemical Research and Application, 2001, 13(6):636-640 doi: 10.3969/j.issn.1004-1656.2001.06.009
19. [19]
  GAO Shi-Yang, YAO Zhan-Li, XIA Shu-Ping. Acta Chim. Sinica, 1994, 52:10-22
20. [20]
  Nielsen A E. Acta Chem. Scand. 1959(13):784-802
21. [21]
  Nielsen A E. Kinetics of Precipitation. Oxford:Pergamon, 1964.
22. [22]
  Analysis Room of Qinghai Institute of Salt Lakes, Chinese Academy of Sciences. Workbook of Identication and Analysis Method of Salt Minerals. 2nd Ed.. Beijing:Chemical Industry Press, 1988.
23. [23]
  Peng J Y, Chen J, Dong Y P, et al. Spectrochim. Acta Part A, 2018, 199:367-375 doi: 10.1016/j.saa.2018.03.063
1. [1]
  Jun Lu , Jinrui Yan , Yaohao Guo , Junjie Qiu , Shuangliang Zhao , Bo Bao . Controlling solid form and crystal habit of triphenylmethanol by antisolvent crystallization in a microfluidic device. Chinese Chemical Letters, 2024, 35(4): 108876-. doi: 10.1016/j.cclet.2023.108876
2. [2]
  Yi Zhang , Biao Wang , Chao Hu , Muhammad Humayun , Yaping Huang , Yulin Cao , Mosaad Negem , Yigang Ding , Chundong Wang . Fe–Ni–F electrocatalyst for enhancing reaction kinetics of water oxidation. Chinese Journal of Structural Chemistry, 2024, 43(2): 100243-100243. doi: 10.1016/j.cjsc.2024.100243
3. [3]
  Yi Herng Chan , Zhe Phak Chan , Serene Sow Mun Lock , Chung Loong Yiin , Shin Ying Foong , Mee Kee Wong , Muhammad Anwar Ishak , Ven Chian Quek , Shengbo Ge , Su Shiung Lam . Thermal pyrolysis conversion of methane to hydrogen (H₂): A review on process parameters, reaction kinetics and techno-economic analysis. Chinese Chemical Letters, 2024, 35(8): 109329-. doi: 10.1016/j.cclet.2023.109329
4. [4]
  Xinlong WANG , Zhenguo CHENG , Guo WANG , Xiaokuen ZHANG , Yong XIANG , Xinquan WANG . Enhancement of the fragile interface of high voltage LiCoO₂ by surface gradient permeation of trace amounts of Mg/F. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 571-580. doi: 10.11862/CJIC.20230259
5. [5]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
6. [6]
  Sinong Wang , Shanshan Jin , Xue Yang , Yanyan Huang , Peng Liu , Yi Tang , Yuliang Yang . Development of Mg-Al LDH and LDO as novel protective materials for deacidification of paper-based relics. Chinese Chemical Letters, 2024, 35(9): 109890-. doi: 10.1016/j.cclet.2024.109890
7. [7]
  Gregorio F. Ortiz . Some facets of the Mg/Na₃VCr_0.5Fe_0.5(PO₄)₃ battery. Chinese Chemical Letters, 2024, 35(10): 109391-. doi: 10.1016/j.cclet.2023.109391
8. [8]
  Qiang Fu , Shouhong Sun , Kangzhi Lu , Ning Li , Zhanhua Dong . Boron-doped carbon dots: Doping strategies, performance effects, and applications. Chinese Chemical Letters, 2024, 35(7): 109136-. doi: 10.1016/j.cclet.2023.109136
9. [9]
  Jingwen Zhao , Jianpu Tang , Zhen Cui , Limin Liu , Dayong Yang , Chi Yao . A DNA micro-complex containing polyaptamer for exosome separation and wound healing. Chinese Chemical Letters, 2024, 35(9): 109303-. doi: 10.1016/j.cclet.2023.109303
10. [10]
  Guangchang Yang , Shenglong Yang , Jinlian Yu , Yishun Xie , Chunlei Tan , Feiyan Lai , Qianqian Jin , Hongqiang Wang , Xiaohui Zhang . Regulating local chemical environment in O3-type layered sodium oxides by dual-site Mg²⁺/B³⁺ substitution achieves durable and high-rate cathode. Chinese Chemical Letters, 2024, 35(9): 109722-. doi: 10.1016/j.cclet.2024.109722
11. [11]
  Qianqian Song , Yunting Zhang , Jianli Liang , Si Liu , Jian Zhu , Xingbin Yan . Boron nitride nanofibers enhanced composite PEO-based solid-state polymer electrolytes for lithium metal batteries. Chinese Chemical Letters, 2024, 35(6): 108797-. doi: 10.1016/j.cclet.2023.108797
12. [12]
  Liangji Chen , Zhen Yuan , Fudong Feng , Xin Zhou , Zhile Xiong , Wuji Wei , Hao Zhang , Banglin Chen , Shengchang Xiang , Zhangjing Zhang . A hydrogen-bonded organic framework containing fluorescent carbazole and responsive pyridyl units for sensing organic acids. Chinese Chemical Letters, 2024, 35(9): 109344-. doi: 10.1016/j.cclet.2023.109344
13. [13]
  Chen Lian , Si-Han Zhao , Hai-Lou Li , Xinhua Cao . A giant Ce-containing poly(tungstobismuthate): Synthesis, structure and catalytic performance for the decontamination of a sulfur mustard simulant. Chinese Chemical Letters, 2024, 35(10): 109343-. doi: 10.1016/j.cclet.2023.109343
14. [14]
  Luyan Shi , Ke Zhu , Yuting Yang , Qinrui Liang , Qimin Peng , Shuqing Zhou , Tayirjan Taylor Isimjan , Xiulin Yang . Phytic acid-derivative Co₂B-CoPO_x coralloidal structure with delicate boron vacancy for enhanced hydrogen generation from sodium borohydride. Chinese Chemical Letters, 2024, 35(4): 109222-. doi: 10.1016/j.cclet.2023.109222
15. [15]
  Tingting Huang , Zhuanlong Ding , Hao Liu , Ping-An Chen , Longfeng Zhao , Yuanyuan Hu , Yifan Yao , Kun Yang , Zebing Zeng . Electron-transporting boron-doped polycyclic aromatic hydrocarbons: Facile synthesis and heteroatom doping positions-modulated optoelectronic properties. Chinese Chemical Letters, 2024, 35(4): 109117-. doi: 10.1016/j.cclet.2023.109117
16. [16]
  Yu-Hang Li , Shuai Gao , Lu Zhang , Hanchun Chen , Chong-Chen Wang , Haodong Ji . Insights on selective Pb adsorption via O 2p orbit in UiO-66 containing rich-zirconium vacancies. Chinese Chemical Letters, 2024, 35(8): 109894-. doi: 10.1016/j.cclet.2024.109894
17. [17]
  Zhiwei Chen , Heyun Sheng , Xue Li , Menghan Chen , Xin Li , Qiuling Song . Efficient capture of difluorocarbene by pyridinium 1,4-zwitterionic thiolates: A concise synthesis of difluoromethylene-containing 1,4-thiazine derivatives. Chinese Chemical Letters, 2024, 35(4): 108937-. doi: 10.1016/j.cclet.2023.108937
18. [18]
  Long TANG , Yaxin BIAN , Luyuan CHEN , Xiangyang HOU , Xiao WANG , Jijiang WANG . Syntheses, structures, and properties of three coordination polymers based on 5-ethylpyridine-2,3-dicarboxylic acid and N-containing ligands. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1975-1985. doi: 10.11862/CJIC.20240180
19. [19]
  Wenhao Yan , Shuaiya Xue , Xuerui Zhao , Wei Zhang , Jian Li . Hexagonal boron nitride based slippery liquid infused porous surface with anti-corrosion, anti-contaminant and anti-icing properties for protecting magnesium alloy. Chinese Chemical Letters, 2024, 35(4): 109224-. doi: 10.1016/j.cclet.2023.109224
20. [20]
  Xuejian Xing , Pan Zhu , E Pang , Shaojing Zhao , Yu Tang , Zheyu Hu , Quchang Ouyang , Minhuan Lan . D-A-D-structured boron-dipyrromethene with aggregation-induced enhanced phototherapeutic efficiency for near-infrared fluorescent and photoacoustic imaging-guided synergistic photodynamic and photothermal cancer therapy. Chinese Chemical Letters, 2024, 35(10): 109452-. doi: 10.1016/j.cclet.2023.109452

Get Citation

PDF

XML

Metrics

PDF Downloads(5)
Abstract views(413)
HTML views(46)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142