Citation: Shujun Ming, Lei Pang, Chi Fan, Wen Guo, Yahao Dong, Peng Liu, Zhen Chen, Tao Li. Chemical deactivation of Cu-SAPO-18 deNO_x catalyst caused by basic inorganic contaminants in diesel exhaust[J]. Chinese Journal of Catalysis, ;2019, 40(4): 590-599. doi: S1872-2067(19)63312-7 shu

Chemical deactivation of Cu-SAPO-18 deNO_x catalyst caused by basic inorganic contaminants in diesel exhaust

Shujun Ming ^a, ,
Lei Pang ^b ,
Chi Fan ^a ,
Wen Guo ^a ,
Yahao Dong ^a ,
Peng Liu ^a ,
Zhen Chen ^a ,
Tao Li ^a

a Key Laboratory of Material Chemistry for Energy Conversion and Storage, Ministry of Education, Hubei Key Laboratory of Material Chemistry and Service Failure, School of Chemistry and Chemical Engineering, Huazhong University of Science and Technology, Wuhan 430074, Hubei, China;
b DongFeng Trucks R & D Center, Wuhan 430056, Hubei, China

Received Date: 19 November 2018
Revised Date: 11 January 2019

Fund Project: This work was supported by the National Natural Science Foundation of China (21473064).

Contaminants (K, Na, Ca, and Mg) were introduced into Cu-SAPO-18 via incipient wetness impregnation to investigate their effect on the selective catalytic reduction of NO_x with NH₃ (NH₃-SCR) over Cu-SAPO-18. After the introduction of contaminants into Cu-SAPO-18, the quantity of acidic sites and Cu²⁺ species in catalyst decreases owing to the replacement of H⁺ and Cu²⁺ by K⁺, Na⁺, Ca²⁺, and Mg²⁺. Furthermore, the loss of isolated Cu²⁺ induces the generation of CuO and CuAl₂O₄-like phases, which causes further loss in the Brunauer-Emmett-Teller surface area of the catalyst. Consequently, the deNO_x performance of the contaminated Cu-SAPO-18 catalysts drops. Such decline in NH₃-SCR performance becomes more pronounced by increasing the contaminant contents from 0.5 to 1.0 mmol/g_catal. In addition, the deactivation influence of the contaminants on Cu-SAPO-18 is presented in the order of K > Na > Ca > Mg, which is consistent with the order of reduction of acidic sites. To a certain degree, the effect of the acidic sites on the deactivation of Cu-SAPO-18 might be more significant than that of isolated Cu²⁺ and the catalyst framework. Moreover, kinetic analysis of NH₃-SCR was conducted, and the results indicate that there is no influence of contaminants on the NH₃-SCR mechanism.
- Cu-SAPO-18 catalyst,
- Basic inorganic contaminant,
- Selective catalytic reduction of NO_x with NH₃,
- Acidic site,
- Isolated Cu²⁺
1. [1]
2. [2]
3. [3]
4. [4]
5. [5]
6. [6]
7. [7]
8. [8]
9. [9]
10. [10]
11. [11]
12. [12]
13. [13]
14. [14]
15. [15]
16. [16]
17. [17]
18. [18]
19. [19]
20. [20]
21. [21]
22. [22]
23. [23]
24. [24]
25. [25]
26. [26]
27. [27]
28. [28]
29. [29]
30. [30]
31. [31]
32. [32]
33. [33]
34. [34]
35. [35]
36. [36]
37. [37]
38. [38]
39. [39]
40. [40]
41. [41]
42. [42]
43. [43]
44. [44]
45. [45]
46. [46]
47. [47]
48. [48]
1. [1]
  Hong LI , Xiaoying DING , Cihang LIU , Jinghan ZHANG , Yanying RAO . Detection of iron and copper ions based on gold nanorod etching colorimetry. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 953-962. doi: 10.11862/CJIC.20230370
2. [2]
  Yuan ZHU , Xiaoda ZHANG , Shasha WANG , Peng WEI , Tao YI . Conditionally restricted fluorescent probe for Fe³⁺ and Cu²⁺ based on the naphthalimide structure. Chinese Journal of Inorganic Chemistry, 2025, 41(1): 183-192. doi: 10.11862/CJIC.20240232
3. [3]
  Hongbo Zhang , Yihong Tang , Suxia Zhang , Yuanting Li . Electrochemical Monitoring of Photocatalytic Degradation of Phenol Pollutants: A Recommended Comprehensive Analytical Chemistry Experiment. University Chemistry, 2024, 39(6): 326-333. doi: 10.3866/PKU.DXHX202310013
4. [4]
  Xinxin YU , Yongxing LIU , Xiaohong YI , Miao CHANG , Fei WANG , Peng WANG , Chongchen WANG . Photocatalytic peroxydisulfate activation for degrading organic pollutants over the zero-valent iron recovered from subway tunnels. Chinese Journal of Inorganic Chemistry, 2025, 41(5): 864-876. doi: 10.11862/CJIC.20240438
5. [5]
  Jingkun Yu , Xue Yong , Ang Cao , Siyu Lu . Bi-Layer Single Atom Catalysts Boosted Nitrate-to-Ammonia Electroreduction with High Activity and Selectivity. Acta Physico-Chimica Sinica, 2024, 40(6): 2307015-0. doi: 10.3866/PKU.WHXB202307015
6. [6]
  Changjun You , Chunchun Wang , Mingjie Cai , Yanping Liu , Baikang Zhu , Shijie Li . Improved Photo-Carrier Transfer by an Internal Electric Field in BiOBr/N-rich C₃N₅ 3D/2D S-Scheme Heterojunction for Efficiently Photocatalytic Micropollutant Removal. Acta Physico-Chimica Sinica, 2024, 40(11): 2407014-0. doi: 10.3866/PKU.WHXB202407014
7. [7]
  Zhanggui DUAN , Yi PEI , Shanshan ZHENG , Zhaoyang WANG , Yongguang WANG , Junjie WANG , Yang HU , Chunxin LÜ , Wei ZHONG . Preparation of UiO-66-NH₂ supported copper catalyst and its catalytic activity on alcohol oxidation. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 496-506. doi: 10.11862/CJIC.20230317
8. [8]
  Yuanqing Wang , Yusong Pan , Hongwu Zhu , Yanlei Xiang , Rong Han , Run Huang , Chao Du , Chengling Pan . Enhanced Catalytic Activity of Bi₂WO₆ for Organic Pollutants Degradation under the Synergism between Advanced Oxidative Processes and Visible Light Irradiation. Acta Physico-Chimica Sinica, 2024, 40(4): 2304050-0. doi: 10.3866/PKU.WHXB202304050
9. [9]
  Jianan Hong , Chenyu Xu , Yan Liu , Changqi Li , Menglin Wang , Yanwei Zhang . Decoding the interfacial competition between hydrogen evolution and CO₂ reduction via edge-active-site modulation in photothermal catalysis. Acta Physico-Chimica Sinica, 2025, 41(9): 100099-0. doi: 10.1016/j.actphy.2025.100099
10. [10]
  Shiqian WEI , Xinyu TIAN , Hong LIU , Maoxia CHEN , Fan TANG , Qiang FAN , Weifeng FAN , Yu HU . Oxygen reduction reaction/oxygen evolution reaction catalytic performances of different active sites on nitrogen-doped graphene loaded with iron single atoms. Chinese Journal of Inorganic Chemistry, 2025, 41(9): 1776-1788. doi: 10.11862/CJIC.20250102
11. [11]
  Feifei Yang , Wei Zhou , Chaoran Yang , Tianyu Zhang , Yanqiang Huang . Enhanced Methanol Selectivity in CO₂ Hydrogenation by Decoration of K on MoS₂ Catalyst. Acta Physico-Chimica Sinica, 2024, 40(7): 2308017-0. doi: 10.3866/PKU.WHXB202308017
12. [12]
  Lina Guo , Ruizhe Li , Chuang Sun , Xiaoli Luo , Yiqiu Shi , Hong Yuan , Shuxin Ouyang , Tierui Zhang . Effect of Interlayer Anions in Layered Double Hydroxides on the Photothermocatalytic CO₂ Methanation of Derived Ni-Al₂O₃ Catalysts. Acta Physico-Chimica Sinica, 2025, 41(1): 100002-0. doi: 10.3866/PKU.WHXB202309002
13. [13]
  Jiapei Zou , Junyang Zhang , Xuming Wu , Cong Wei , Simin Fang , Yuxi Wang . A Comprehensive Experiment Based on Electrocatalytic Nitrate Reduction into Ammonia: Synthesis, Characterization, Performance Exploration, and Applicable Design of Copper-based Catalysts. University Chemistry, 2024, 39(6): 373-382. doi: 10.3866/PKU.DXHX202312081
14. [14]
  Haoyu Sun , Dun Li , Yuanyuan Min , Yingying Wang , Yanyun Ma , Yiqun Zheng , Hongwen Huang . Hierarchical Palladium-Copper-Silver Porous Nanoflowers as Efficient Electrocatalysts for CO₂ Reduction to C₂₊ Products. Acta Physico-Chimica Sinica, 2024, 40(6): 2307007-0. doi: 10.3866/PKU.WHXB202307007
15. [15]
  Ruolin CHENG , Haoran WANG , Jing REN , Yingying MA , Huagen LIANG . Efficient photocatalytic CO₂ cycloaddition over W₁₈O₄₉/NH₂-UiO-66 composite catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 523-532. doi: 10.11862/CJIC.20230349
16. [16]
  Xiaorui Chen , Xuan Luo , Tongming Su , Xinling Xie , Liuyun Chen , Yuejing Bin , Zuzeng Qin , Hongbing Ji . Ga-doped Cu/γ-Al₂O₃ bifunctional interface sites promote the direct hydrogenation of CO₂ to DME. Acta Physico-Chimica Sinica, 2025, 41(10): 100126-0. doi: 10.1016/j.actphy.2025.100126
17. [17]
  Peng YUE , Liyao SHI , Jinglei CUI , Huirong ZHANG , Yanxia GUO . Effects of Ce and Mn promoters on the selective oxidation of ammonia over V₂O₅/TiO₂ catalyst. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 293-307. doi: 10.11862/CJIC.20240210
18. [18]
  Congqi Zhu , Bo Liu , Ruchun Li . Dual active sites enhancing alkaline H₂-production performance. Acta Physico-Chimica Sinica, 2025, 41(11): 100146-0. doi: 10.1016/j.actphy.2025.100146
19. [19]
  Zhiquan Zhang , Baker Rhimi , Zheyang Liu , Min Zhou , Guowei Deng , Wei Wei , Liang Mao , Huaming Li , Zhifeng Jiang . Insights into the Development of Copper-Based Photocatalysts for CO₂ Conversion. Acta Physico-Chimica Sinica, 2024, 40(12): 2406029-0. doi: 10.3866/PKU.WHXB202406029
20. [20]
  Xue Dong , Xiaofu Sun , Shuaiqiang Jia , Shitao Han , Dawei Zhou , Ting Yao , Min Wang , Minghui Fang , Haihong Wu , Buxing Han . Electrochemical CO₂ Reduction to C₂₊ Products with Ampere-Level Current on Carbon-Modified Copper Catalysts. Acta Physico-Chimica Sinica, 2025, 41(3): 2404012-0. doi: 10.3866/PKU.WHXB202404012

Get Citation

PDF

XML

Metrics

PDF Downloads(1)
Abstract views(783)
HTML views(47)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Chemical deactivation of Cu-SAPO-18 deNOx catalyst caused by basic inorganic contaminants in diesel exhaust

Metrics

通讯作者: 陈斌, bchen63@163.com

Chemical deactivation of Cu-SAPO-18 deNO_x catalyst caused by basic inorganic contaminants in diesel exhaust