Citation: FAN Ren-Jie, LIN Rui, HUANG Zhen, ZHAO Tian-Tian, MA Jian-Xin. Preparation and Characterization of Pt Catalysts Supported on Cobalt-Polypyrrole-Carbon for Fuel Cells[J]. Acta Physico-Chimica Sinica, ;2014, 30(7): 1259-1266. doi: 10.3866/PKU.WHXB201405045 shu

Preparation and Characterization of Pt Catalysts Supported on Cobalt-Polypyrrole-Carbon for Fuel Cells

FAN Ren-Jie ^1,2 ,
LIN Rui ^1,2, ,
HUANG Zhen ^1,2 ,
ZHAO Tian-Tian ^1,2 ,
MA Jian-Xin ^1,2

1.
1. Clean Energy Automotive Engineering Center, Tongji University, Shanghai 201804, P. R. China;
2. School of Automotive Studies, Tongji University, Shanghai 201804, P. R. China

Received Date: 27 March 2014
Available Online: 4 May 2014
Fund Project:

Pt/cobalt-polypyrrole-carbon (Co-PPy-C)-supported catalysts were successfully prepared by pulse-microwave assisted chemical reduction. Transmission electron microscopy (TEM), X-ray photoelectron spectroscopy (XPS), and X-ray diffraction (XRD) techniques were used to characterize the catalyst microstructure and morphology. The electrocatalytic performance, kinetic characteristics of the oxygen reduction reaction (ORR), and durability of the catalysts were measured by cyclic voltammetry (CV) and linear sweep voltammetry (LSV) techniques. It was found that the particle size of Pt/Co-PPy-C was about 1.8 nm, which was smaller than that of commercial Pt/C (JM) catalysts (2.5 nm). The metal particles were well-dispersed on the carbon support. The electrochemical specific area (ECSA) of Pt/Co-PPy-C (75.1 m²· g^-1) was much higher than that of Pt/C (JM) (51.3 m²·g^-1). The results of XPS showed that most of the Pt in the catalysts was in the Pt(0) state, and XRD results showed that the form of Pt was mainly the facecentered cubic lattice. The Pt/Co-PPy-C catalyst had the same half-wave potential as Pt/C (JM) and showed higher ORR activity. The Pt/Co-PPy-C catalyst proceeded by an approximately four-electron pathway in acid solution. After 1000 cycles of CV, the ECSA attenuation rates of Pt/Co-PPy-C and Pt/C were 13.0% and 24.0% respectively, which means that the Pt/Co-PPy-C catalyst has higher durability. The high performance of Pt/Co-PPy-C makes it a promising catalyst for proton exchange membrane fuel cells.
- Proton exchange membrane fuel cell,
- Catalyst,
- Cobalt-polypyrrole-carbon,
- Oxygen reduction reaction,
- Microwave chemical reduction
1. [1]
  
  (1) Zhang, J.; Tang, S. H.; Liao, L. Y.; Yu,W. F. Chin. J. Catal. 2013, 34, 1051. [张洁, 唐水花, 廖龙渝, 郁卫飞. 催化学报, 2013, 34, 1051.]
2. [2]
  (2) Wee, J. H.; Lee, K. Y.; Kim, S. H. J. Power Sources 2007, 165, 667. doi: 10.1016/j.jpowsour.2006.12.051
3. [3]
  (3) Yin, S. B.; Mu, S. C.; Pan, M.; Fu, Z. Y. J. Power Sources 2011, 196, 7931. doi: 10.1016/j.jpowsour. 2011.05.033
4. [4]
  (4) Yan, X. H. Zhang, G. R.; Xu, B. Q. Chin. J. Catal. 2013, 34, 1992. [严祥辉, 张贵荣, 徐柏庆. 催化学报, 2013, 34, 1992.]
5. [5]
  (5) Wang, S. Y.; Jiang, S. P.;Wang, X. Nanotechnology 2008, 19, 265601. doi: 10.1088/0957-4484/19/26/265601
6. [6]
  (6) He, D. P.; Zeng, C.; Xu, C.; Cheng, N. C.; Li, H. G.; Mu, S. C.; Pan, M. Langmuir 2011, 27, 5582. doi: 10.1021/la2003589
7. [7]
  (7) Zhao, Y. C.; Lan, H. X.; Tian, J. N.; Yang, X. L.;Wang, F. Y. Acta Phys. -Chim. Sin. 2009, 25 (10), 2050. [赵彦春, 兰黄鲜, 田建袅, 杨秀林, 王凤阳. 物理化学学报, 2009, 25 (10), 2050.]
8. [8]
  (8) Zhao, Y. C.; Lan, H. X.; Deng, B. B.; Tian, J. N.; Yang, X. L.; Wang, F. Y. Acta Phys. -Chim. Sin. 2010, 26 (8), 2255. [赵彦春, 兰黄鲜, 邓彬彬, 田建袅, 杨秀林, 王凤阳. 物理化学学报, 2010, 26 (8), 2255.]
9. [9]
  (9) Dai, X. F.; Zheng, M. F.; Xu, P.; Shi, J. J.; Ma, C. Y.; Qiao, J. L. Acta Phys. -Chim. Sin. 2013, 29 (8), 1753. [戴先逢, 郑明富, 徐攀, 石晶晶, 马承禺, 乔锦丽. 物理化学学报, 2013, 29 (8), 1753.]
10. [10]
  (10) Li, S.;Wang, J. T.; Chen, R. X.; Zhao,W.; Qian, L.; Pan, M. Acta Phys. -Chim. Sin. 2013, 29 (4), 792. [李赏, 王家堂, 陈锐鑫, 赵伟, 钱柳, 潘牧. 物理化学学报, 2013, 29 (4), 792.]
11. [11]
  (11) Bensebaa, F.; Farah, A. A.;Wang, D.; Bock, C.; Du, X. M.; Kung, J.; Page, Y. L. J. Phys. Chem. B 2005, 109 (32), 15339. doi: 10.1021/jp0519870
12. [12]
  (12) Qiao, J. L.; Xu, L.; Ding, L.; Zhang, L.; Baker, R.; Dai, X. F.; Zhang, J. J. Appl. Catal. B-Environ. 2012, 125, 197.
13. [13]
  (13) Ding, L.; Qiao, J. L.; Dai, X. F.; Zhang, J.; Zhang, J. J.; Tian, B. L. Int. J. Hydrog. Energy 2012, 37 (19), 14103. doi: 10.1016/j.ijhydene.2012.07.046
14. [14]
  (14) Zhang, H. J.; Li, H. L.; Li, X. T.; Qiu, H. X.; Yuan, X. X.; Zhao, B.; Ma, Z. F.; Yang, J. H. Int. J. Hydrog. Energy 2014, 39 (1), 267. doi: 10.1016/j.ijhydene.2013.09.084
15. [15]
  (15) Zhang, H. J.; Yuan, X. X.;Wang, Z. H.; Yang, J. H.; Ma, Z. F. Electrochim. Acta 2013, 87, 599. doi: 10.1016/j. electacta.2012.10.019
16. [16]
  (16) Huang, S. Y.; Ganesan, P.; Popov, B. N. Appl. Catal. B-Environ. 2009, 93, 75. doi: 10.1016/j.apcatb.2009.09.014
17. [17]
  (17) Yuasa, M.; Yamaguchi, A.; Itsuki, H.; Tanaka, K.; Yamamoto, M.; Oyaizu, K. Chem. Mater. 2005, 17, 4278.
18. [18]
  (18) Zhao, H. B.; Li, L.; Yang, J.; Zhang, Y. M. J. Power Sources 2008, 184, 375. doi: 10.1016/j.jpowsour.2008.03.024
19. [19]
  (19) Zhao, H. B.; Li, L.; Yang, J.; Zhang, Y. M.; Li, H. Electrochem. Commun. 2008, 10, 876. doi: 10.1016/j.elecom.2008.04.005
20. [20]
  (20) Dyer, C. K.; Moseley, P. T.; Ogumi, Z.; Rand, D. A. J.; Scrosati, B.; Garche, J. Encyclopedia of Electrochemical Power Sources, 1st ed.; Elsevier Science Ltd: Amsterdam. 2009, pp 639-649.
21. [21]
  (21) Tian, J.; Birry, L.; Jaouen, F.; Dodelet, J. P. Electrochim. Acta 2011, 56 (9), 3276. doi: 10.1016/j.electacta.2011.01.029
22. [22]
  (22) Jaouen, F.; ellner, V.; Lefèvre, M.; Herranz, J.; Proietti, E.; Dodelet, J. P. Electrochim. Acta 2013, 87, 619. doi: 10.1016/j.electacta.2012.09.057
23. [23]
  (23) Yuasa, M.; Yamaguchi, A.; Itsuki, H.; Tanaka, K.; Yamamoto, M.; Oyaizu, K. Chem. Mater. 2005, 17, 4278.
24. [24]
  (24) Bashyam, R.; Zelenay, P. Nature 2006, 443, 63. doi: 10.1038/nature05118
25. [25]
  (25) Lee, K. C.; Zhang, L.; Lui, H. S.; Hui, R.; Shi, Z.; Zhang, J. J. Electrochim. Acta 2009, 54, 4704. doi: 10.1016/j. electacta. 2009.03.081
26. [26]
  (26) Nguyen-Thanh, D.; Frenkel, A. I.;Wang, J. Q.; O′Brien, S.; Akins, D. L. Appl. Catal. B-Environ. 2011, 105, 50. doi: 10.1016/j.apcatb.2011.03.034
27. [27]
  (27) Yu,W. Y.; Tu,W. X.; Liu, H. F. Langmuir 1999, 15 (1), 6. doi: 10.1021/la9806505
28. [28]
  (28) Gan, L.; Du, H. D.; Li, B. H.; Kang, F. Y. New Carbon Mater. 2010, 25, 53. doi: 10.1016/S1872-5805(09)60015-9
29. [29]
  (29) Gasteiger, H. A.; Kocha, S. S.; Sompalli, B.;Wagner, F. T. Appl. Catal. B-Environ. 2005, 56, 9. doi: 10.1016/j.apcatb.2004.06.021
30. [30]
  (30) Vivek, S. M.; Elise, I.;Wu, B.; Lesia, P. V. D. Highly Dispersed Alloy Catalyst for Durability. http://www. hydrogen. energy. v/pdfs/progress11/v_d_2_murthi_2011.pdf (accessed Mar 20, 2014)
31. [31]
  (31) Lee, M. H.; Do, J. S. J. Power Sources 2009, 188, 353. doi: 10.1016/j.jpowsour.2008.12.051
1. [1]
  Hailang JIA , Hongcheng LI , Pengcheng JI , Yang TENG , Mingyun GUAN . Preparation and performance of N-doped carbon nanotubes composite Co₃O₄ as oxygen reduction reaction electrocatalysts. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 693-700. doi: 10.11862/CJIC.20230402
2. [2]
  Xiaofeng Zhu , Bingbing Xiao , Jiaxin Su , Shuai Wang , Qingran Zhang , Jun Wang . Transition Metal Oxides/Chalcogenides for Electrochemical Oxygen Reduction into Hydrogen Peroxides. Acta Physico-Chimica Sinica, 2024, 40(12): 2407005-. doi: 10.3866/PKU.WHXB202407005
3. [3]
  Kun WANG , Wenrui LIU , Peng JIANG , Yuhang SONG , Lihua CHEN , Zhao DENG . Hierarchical hollow structured BiOBr-Pt catalysts for photocatalytic CO₂ reduction. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1270-1278. doi: 10.11862/CJIC.20240037
4. [4]
  Yanan Liu , Yufei He , Dianqing Li . Preparation of Highly Dispersed LDHs-based Catalysts and Testing of Nitro Compound Reduction Performance: A Comprehensive Chemical Experiment for Research Transformation. University Chemistry, 2024, 39(8): 306-313. doi: 10.3866/PKU.DXHX202401081
5. [5]
  Yi YANG , Shuang WANG , Wendan WANG , Limiao CHEN . Photocatalytic CO₂ reduction performance of Z-scheme Ag-Cu₂O/BiVO₄ photocatalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 895-906. doi: 10.11862/CJIC.20230434
6. [6]
  Jiapei Zou , Junyang Zhang , Xuming Wu , Cong Wei , Simin Fang , Yuxi Wang . A Comprehensive Experiment Based on Electrocatalytic Nitrate Reduction into Ammonia: Synthesis, Characterization, Performance Exploration, and Applicable Design of Copper-based Catalysts. University Chemistry, 2024, 39(6): 373-382. doi: 10.3866/PKU.DXHX202312081
7. [7]
  Fengqiao Bi , Jun Wang , Dongmei Yang . Specialized Experimental Design for Chemistry Majors in the Context of “Dual Carbon”: Taking the Assembly and Performance Evaluation of Zinc-Air Fuel Batteries as an Example. University Chemistry, 2024, 39(4): 198-205. doi: 10.3866/PKU.DXHX202311069
8. [8]
  Dan Li , Hui Xin , Xiaofeng Yi . Comprehensive Experimental Design on Ni-based Catalyst for Biofuel Production. University Chemistry, 2024, 39(8): 204-211. doi: 10.3866/PKU.DXHX202312046
9. [9]
  Jinyi Sun , Lin Ma , Yanjie Xi , Jing Wang . Preparation and Electrocatalytic Nitrogen Reduction Performance Study of Vanadium Nitride@Nitrogen-Doped Carbon Composite Nanomaterials: A Recommended Comprehensive Chemistry Experiment. University Chemistry, 2024, 39(4): 184-191. doi: 10.3866/PKU.DXHX202310094
10. [10]
  Jun LI , Huipeng LI , Hua ZHAO , Qinlong LIU . Preparation and photocatalytic performance of AgNi bimetallic modified polyhedral bismuth vanadate. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 601-612. doi: 10.11862/CJIC.20230401
11. [11]
  Xiaoxia WANG , Ya'nan GUO , Feng SU , Chun HAN , Long SUN . Synthesis, structure, and electrocatalytic oxygen reduction reaction properties of metal antimony-based chalcogenide clusters. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1201-1208. doi: 10.11862/CJIC.20230478
12. [12]
  Tong Zhou , Jun Li , Zitian Wen , Yitian Chen , Hailing Li , Zhonghong Gao , Wenyun Wang , Fang Liu , Qing Feng , Zhen Li , Jinyi Yang , Min Liu , Wei Qi . Experiment Improvement of “Redox Reaction and Electrode Potential” Based on the New Medical Concept. University Chemistry, 2024, 39(8): 276-281. doi: 10.3866/PKU.DXHX202401005
13. [13]
  Ji-Quan Liu , Huilin Guo , Ying Yang , Xiaohui Guo . Calculation and Discussion of Electrode Potentials in Redox Reactions of Water. University Chemistry, 2024, 39(8): 351-358. doi: 10.3866/PKU.DXHX202401031
14. [14]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
15. [15]
  Zhuo WANG , Junshan ZHANG , Shaoyan YANG , Lingyan ZHOU , Yedi LI , Yuanpei LAN . Preparation and photocatalytic performance of CeO₂-reduced graphene oxide by thermal decomposition. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1708-1718. doi: 10.11862/CJIC.20240067
16. [16]
  Xuejiao Wang , Suiying Dong , Kezhen Qi , Vadim Popkov , Xianglin Xiang . Photocatalytic CO₂ Reduction by Modified g-C₃N₄. Acta Physico-Chimica Sinica, 2024, 40(12): 2408005-. doi: 10.3866/PKU.WHXB202408005
17. [17]
  Juntao Yan , Liang Wei . 2D S-Scheme Heterojunction Photocatalyst. Acta Physico-Chimica Sinica, 2024, 40(10): 2312024-. doi: 10.3866/PKU.WHXB202312024
18. [18]
  Yuanyin Cui , Jinfeng Zhang , Hailiang Chu , Lixian Sun , Kai Dai . Rational Design of Bismuth Based Photocatalysts for Solar Energy Conversion. Acta Physico-Chimica Sinica, 2024, 40(12): 2405016-. doi: 10.3866/PKU.WHXB202405016
19. [19]
  Zongfei YANG , Xiaosen ZHAO , Jing LI , Wenchang ZHUANG . Research advances in heteropolyoxoniobates. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 465-480. doi: 10.11862/CJIC.20230306
20. [20]
  Zhanggui DUAN , Yi PEI , Shanshan ZHENG , Zhaoyang WANG , Yongguang WANG , Junjie WANG , Yang HU , Chunxin LÜ , Wei ZHONG . Preparation of UiO-66-NH₂ supported copper catalyst and its catalytic activity on alcohol oxidation. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 496-506. doi: 10.11862/CJIC.20230317

Get Citation

PDF

XML

Metrics

PDF Downloads(627)
Abstract views(688)
HTML views(2)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142