Citation: ZHANG Xuan-Xuan, RAN Fen, FAN Hui-Li, KONG Ling-Bin, KANG Long. Hydrothermal Synthesis and Electrochemical Measurements of Interconnected Porous Carbon/MnO₂ Composites[J]. Acta Physico-Chimica Sinica, ;2014, 30(5): 881-890. doi: 10.3866/PKU.WHXB201403061 shu

Hydrothermal Synthesis and Electrochemical Measurements of Interconnected Porous Carbon/MnO₂ Composites

ZHANG Xuan-Xuan ¹ ,
RAN Fen ^1,2, ,
FAN Hui-Li ¹ ,
KONG Ling-Bin ^1,2 ,
KANG Long ^1,2,

1.
1 School of Material Science and Engineerings, Lanzhou University of Technology, Lanzhou 730050, P. R. China;
2 State Key Laboratory of Advanced Processing and Recycling of Non-Ferrous Metals, Lanzhou University of Technology, Lanzhou 730050, P. R. China

Received Date: 8 November 2013
Available Online: 6 March 2014
Fund Project:

This article describes the electrochemical performance of a novel interconnected porous carbon/ MnO₂ (IPC/MnO₂) composite prepared by in situ self-limiting deposition under hydrothermal condition. The morphology and structure were characterized using scanning electron microscopy (SEM), transmission electron microscopy (TEM), X-ray diffraction (XRD), and thermogravimetric analysis (TGA), and the electrochemical behavior was investigated using cyclic voltammetry (CV), charge-discharge tests, electrochemical impedance spectroscopy (EIS), and cycle life tests. The results showed that MnO₂ grew homogeneously on the IPC surface, forming a hierarchical microstructure. The MnO₂ had a typical K-Birnessite-type crystal structure and the MnO₂ content was about 34%(w). At high synthetic temperatures, the MnO₂ particles on the IPC surface were smaller. The prepared electrode material exhibited a od electrochemical capacitance performance. As the reaction temperature increased, the specific capacitance of the IPC/MnO₂ composite first increased and then remained constant. The IPC/MnO₂ composite synthesized at 100 ℃ had the maximum specific capacitance, 411 F·g^-1, in a three-electrode system. An asymmetric supercapacitor was constructed with the IPC/MnO₂ composite as the positive electrode and activated carbon (AC) as the negative electrode, in a 1 mol·L^-1 Na₂SO₄ electrolyte. The results showed that the corresponding potential window increased from 1 to 1.8 V. The maximum specific capacitance of the asymmetric supercapacitor was 86 F·g^-1 and a od rate capability was achieved.
- Manganese oxide,
- Interconnected porous carbon,
- Supercapacitor,
- Composite electrode material
1. [1]
  
  (1) El-Kady, M. F.; Strong, V.; Dubin, S.; Kaner, R. B. Science 2012, 335, 1326. doi: 10.1126/science.1216744
2. [2]
  (2) Simon, P.; tsi, Y. Nat. Mater. 2008, 7, 845. doi: 10.1038/nmat2297
3. [3]
  (3) Wen, C. M.; Wen, Z. Y.; You, Z.; Wang, X. F. Chin. J. Chem. Phys. 2012, 25, 209. doi: 10.1088/1674-0068/25/02/209-213
4. [4]
  (4) Wang, X. F.; You, Z.; Ruan, D. B. Chin. J. Chem. Phys. 2005, 18, 635.
5. [5]
  (5) Kim, I. H.; Kim, K. B. J. Electrochem. Soc. 2006, 153, A383.
6. [6]
  (6) Nagarajan, N.; Cheong, M.; Zhitomirsky, I. Mater. Chem. Phys. 2007, 103 (1), 47. doi: 10.1016/j.matchemphys.2007.01.005
7. [7]
  (7) Yu, H. M.; Zheng, W.; Cao, G. S.; Zhao, X. B. Acta Phys. -Chim. Sin. 2009, 25 (11), 2186. [余红明, 郑威, 曹高劭, 赵新兵. 物理化学学报, 2009, 25 (11), 2186.] doi: 10.3866/PKU.WHXB20091113
8. [8]
  (8) Fischer, A. E.; Pettigrew, K. A.; Rolison, D. R.; Stroud, R. M.; Long, J.W. Nano Lett. 2007, 7 (2), 281.
9. [9]
  (9) Sharma, R. K.; Oh, H. S.; Shul, Y. G.; Kim, H. J. Power Sources 2007, 173, 1024. doi: 10.1016/j.jpowsour.2007.08.076
10. [10]
  (10) Huang, H. J.; Wang, X. Nanoscale 2011, 3, 3185. doi: 10.1039/c1nr10229j
11. [11]
  (11) Wang, H. L.; Casalongue, H. S.; Liang, Y. Y.; Dai, H. J. J. Am. Chem. Soc. 2010, 132, 7472. doi: 10.1021/ja102267j
12. [12]
  (12) Sawangphruk, M.; Srimuk, P.; Chiochan, P.; Krittayavathananon, A.; Luanwuthi, S.; Limtrakul, J. Carbon 2013, 60, 109. doi: 10.1016/j.carbon.2013.03.062
13. [13]
  (13) Yan, J.; Fan, Z. J.; Wei, T.; Qian, W. Z.; Zhang, M. L.; Wei, F. Carbon 2010, 48, 3825.
14. [14]
  (14) Song, M. K.; Cheng, S.; Chen, H. Y.; Qin, W. T.; Nam, K.W.; Xu, S. C.; Yang, X. Q.; Bongiorno, A.; Lee, J.; Bai, J. M.; Tyson, T. A.; Cho, J.; Liu, M. L. Nano Lett. 2012, 12, 3483. doi: 10.1021/nl300984y
15. [15]
  (15) Bordjiba, T.; Belanger, D. J. Electrochem. Soc. 2009, 156, A378.
16. [16]
  (16) Hu, L. B.; Pasta, M.; La Mantia, F.; Cui, L. F.; Jeong, S.; Deshazer, H. D.; Choi, J.W.; Han, S. M.; Cui, Y. Nano Lett. 2010, 10, 708.
17. [17]
  (17) Chen, W.; Xie, X.; Liu, N.; Yang, Y.; Wu, H.; Yao, Y.; Pasta, M.; Alshareef, H. N.; Cui, Y. ACS Nano 2011, 5, 8904. doi: 10.1021/nn203085j
18. [18]
  (18) Prasad, K. R.; Miura, N. J. Power Sources 2004, 135, 354. doi: 10.1016/j.jpowsour.2004.04.005
19. [19]
  (19) Yan, J.; Fan, Z.; Wei, T.; Qian, W.; Zhang, M.; Wei, F. Carbon 2009, 47, 3371. doi: 10.1016/j.carbon.2009.08.001
20. [20]
  (20) Yang, Y. J.; Liu, E. H.; Li, L. M.; Huang, Z. Z.; Shen, H. J.; Xiang, X. X. J. Alloy. Compd. 2009, 487, 564.
21. [21]
  (21) Yan, J.; Fan, Z.; Wei, T.; Qie, Z.; Wang, S.; Zhang, M. Mater. Sci. Eng. B 2008, 151, 174. doi: 10.1016/j.mseb.2008.05.018
22. [22]
  (22) Chen, S.; Zhu, J.; Wu, X.; Han, Q.; Wang, X. ACS Nano 2010, 4, 2822. doi: 10.1021/nn901311t
23. [23]
  (23) Zhang, J.; Jiang, J.; Zhao, X. S. J. Phys. Chem. C 2011, 115, 6448. doi: 10.1021/jp200724h
24. [24]
  (24) Jin, X. B.; Zhou, W. Z.; Zhang, S.W.; Chen, G. Z. Small 2007, 3, 1513.
25. [25]
  (25) Tan, Y. T.; Ran, F.; Kong, L. B.; Liu, J.; Kang, L. Synthetic Metals 2012, 162, 114. doi: 10.1016/j.synthmet.2011.11.020
26. [26]
  (26) Liu, M. C.; Kong, L. B.; Lu, C.; Li, X. M.; Luo, Y. C.; Kang, L.; Li, X. H.; Walsh, F. C. J. Electrochem. Soc. 2012, 159, A1.
27. [27]
  (27) Li, L.; He, Y. Q.; Chu, X. F.; Li, Y. M.; Sun, F. F.; Huang, H. Z. Acta Phys. -Chim. Sin. 2013, 29, 1681. [李乐, 贺蕴秋, 储晓菲, 李一鸣, 孙芳芳, 黄河洲. 物理化学学报, 2013, 29, 1681.] doi: 10.3866/PKU.WHXB201305223
28. [28]
  (28) Khomenko, V.; Raymundo-Pinero, E.; Beguin, F. J. Power Sources 2006, 153, 183. doi: 10.1016/j.jpowsour.2005.03.192
29. [29]
  (29) Wang, X.; Li, Y. D. Chem. Eur. J. 2003, 9, 300.
30. [30]
  (30) Song, X. C.; Zhao, Y.; Zheng, Y. F. Cryst. Growth Des. 2007, 7, 159. doi: 10.1021/cg060536h
31. [31]
  (31) Ma, R.; Bando, Y.; Zhang, L.; Sasaki, T. Adv. Mater. 2004, 16, 918.
32. [32]
  (32) Toupin, M.; Brousse, T.; Bélanger, D. Chem. Mater. 2004, 16, 3184. doi: 10.1021/cm049649j
33. [33]
  (33) Zolfaghari, A.; Naderi, H. R.; Mortaheb, H. R. J. Electroanal. Chem. 2013, 697, 60.
34. [34]
  (34) Izadi-Najafabadi, A.; Yasuda, S.; Kobashi, K.; Yamada, T.; Futaba, D. N.; Hatori, H.; Yumura, M.; Iijima, S.; Hata, K. Adv. Mater. 2010, 22, E235.
35. [35]
  (35) Qu, Q. T.; Zhang, P.; Wang, B.; Chen, Y. H.; Tian, S.; Wu, Y. P.; Holze, R. J. Phys. Chem. C 2009, 113, 14020.
1. [1]
  Zhaomei LIU , Wenshi ZHONG , Jiaxin LI , Gengshen HU . Preparation of nitrogen-doped porous carbons with ultra-high surface areas for high-performance supercapacitors. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 677-685. doi: 10.11862/CJIC.20230404
2. [2]
  Yanhui XUE , Shaofei CHAO , Man XU , Qiong WU , Fufa WU , Sufyan Javed Muhammad . Construction of high energy density hexagonal hole MXene aqueous supercapacitor by vacancy defect control strategy. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1640-1652. doi: 10.11862/CJIC.20240183
3. [3]
  Jin CHANG . Supercapacitor performance and first-principles calculation study of Co-doping Ni(OH)₂. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1697-1707. doi: 10.11862/CJIC.20240108
4. [4]
  Xiaoning TANG , Shu XIA , Jie LEI , Xingfu YANG , Qiuyang LUO , Junnan LIU , An XUE . Fluorine-doped MnO₂ with oxygen vacancy for stabilizing Zn-ion batteries. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1671-1678. doi: 10.11862/CJIC.20240149
5. [5]
  Jiahong ZHENG , Jiajun SHEN , Xin BAI . Preparation and electrochemical properties of nickel foam loaded NiMoO₄/NiMoS₄ composites. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 581-590. doi: 10.11862/CJIC.20230253
6. [6]
  Jiahong ZHENG , Jingyun YANG . Preparation and electrochemical properties of hollow dodecahedral CoNi₂S₄ supported by MnO₂ nanowires. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1881-1891. doi: 10.11862/CJIC.20240170
7. [7]
  Kuaibing Wang , Honglin Zhang , Wenjie Lu , Weihua Zhang . Experimental Design and Practice for Recycling and Nickel Content Detection from Waste Nickel-Metal Hydride Batteries. University Chemistry, 2024, 39(11): 335-341. doi: 10.12461/PKU.DXHX202403084
8. [8]
  Wen LUO , Lin JIN , Palanisamy Kannan , Jinle HOU , Peng HUO , Jinzhong YAO , Peng WANG . Preparation of high-performance supercapacitor based on bimetallic high nuclearity titanium-oxo-cluster based electrodes. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 782-790. doi: 10.11862/CJIC.20230418
9. [9]
  Zhiquan Zhang , Baker Rhimi , Zheyang Liu , Min Zhou , Guowei Deng , Wei Wei , Liang Mao , Huaming Li , Zhifeng Jiang . Insights into the Development of Copper-based Photocatalysts for CO₂ Conversion. Acta Physico-Chimica Sinica, 2024, 40(12): 2406029-. doi: 10.3866/PKU.WHXB202406029
10. [10]
  Jinyi Sun , Lin Ma , Yanjie Xi , Jing Wang . Preparation and Electrocatalytic Nitrogen Reduction Performance Study of Vanadium Nitride@Nitrogen-Doped Carbon Composite Nanomaterials: A Recommended Comprehensive Chemistry Experiment. University Chemistry, 2024, 39(4): 184-191. doi: 10.3866/PKU.DXHX202310094
11. [11]
  Xin Zhou , Zhi Zhang , Yun Yang , Shuijin Yang . A Study on the Enhancement of Photocatalytic Performance in C/Bi/Bi₂MoO₆ Composites by Ferroelectric Polarization: A Recommended Comprehensive Chemical Experiment. University Chemistry, 2024, 39(4): 296-304. doi: 10.3866/PKU.DXHX202310008
12. [12]
  Caixia Lin , Zhaojiang Shi , Yi Yu , Jianfeng Yan , Keyin Ye , Yaofeng Yuan . Ideological and Political Design for the Electrochemical Synthesis of Benzoxathiazine Dioxide Experiment. University Chemistry, 2024, 39(2): 61-66. doi: 10.3866/PKU.DXHX202309005
13. [13]
  Xiaomei Ning , Liang Zhan , Xiaosong Zhou , Jin Luo , Xunfu Zhou , Cuifen Luo . Preparation and Electro-Oxidation Performance of PtBi Supported on Carbon Cloth: A Recommended Comprehensive Chemical Experiment. University Chemistry, 2024, 39(11): 217-224. doi: 10.3866/PKU.DXHX202401085
14. [14]
  Shengbiao Zheng , Liang Li , Nini Zhang , Ruimin Bao , Ruizhang Hu , Jing Tang . Metal-Organic Framework-Derived Materials Modified Electrode for Electrochemical Sensing of Tert-Butylhydroquinone: A Recommended Comprehensive Chemistry Experiment for Translating Research Results. University Chemistry, 2024, 39(7): 345-353. doi: 10.3866/PKU.DXHX202310096
15. [15]
  Meng Lin , Hanrui Chen , Congcong Xu . Preparation and Study of Photo-Enhanced Electrocatalytic Oxygen Evolution Performance of ZIF-67/Copper(I) Oxide Composite: A Recommended Comprehensive Physical Chemistry Experiment. University Chemistry, 2024, 39(4): 163-168. doi: 10.3866/PKU.DXHX202308117
16. [16]
  Qi Li , Pingan Li , Zetong Liu , Jiahui Zhang , Hao Zhang , Weilai Yu , Xianluo Hu . Fabricating Micro/Nanostructured Separators and Electrode Materials by Coaxial Electrospinning for Lithium-Ion Batteries: From Fundamentals to Applications. Acta Physico-Chimica Sinica, 2024, 40(10): 2311030-. doi: 10.3866/PKU.WHXB202311030
17. [17]
  Tong Zhou , Jun Li , Zitian Wen , Yitian Chen , Hailing Li , Zhonghong Gao , Wenyun Wang , Fang Liu , Qing Feng , Zhen Li , Jinyi Yang , Min Liu , Wei Qi . Experiment Improvement of “Redox Reaction and Electrode Potential” Based on the New Medical Concept. University Chemistry, 2024, 39(8): 276-281. doi: 10.3866/PKU.DXHX202401005
18. [18]
  Ji-Quan Liu , Huilin Guo , Ying Yang , Xiaohui Guo . Calculation and Discussion of Electrode Potentials in Redox Reactions of Water. University Chemistry, 2024, 39(8): 351-358. doi: 10.3866/PKU.DXHX202401031
19. [19]
  Limei CHEN , Mengfei ZHAO , Lin CHEN , Ding LI , Wei LI , Weiye HAN , Hongbin WANG . Preparation and performance of paraffin/alkali modified diatomite/expanded graphite composite phase change thermal storage material. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 533-543. doi: 10.11862/CJIC.20230312
20. [20]
  Ziheng Zhuang , Xiao Xu , Kin Shing Chan . Superdrugs for Superbugs. University Chemistry, 2024, 39(9): 128-133. doi: 10.3866/PKU.DXHX202309040

Get Citation

PDF

XML

Metrics

PDF Downloads(1569)
Abstract views(907)
HTML views(32)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Hydrothermal Synthesis and Electrochemical Measurements of Interconnected Porous Carbon/MnO2 Composites

Metrics

通讯作者: 陈斌, bchen63@163.com

Hydrothermal Synthesis and Electrochemical Measurements of Interconnected Porous Carbon/MnO₂ Composites