Citation: PANG Ran, ZUO Yu, TANG Yu-Ming, XIONG Jin-Ping. Electrochemical Impedance Spectroscopy Study of Failure Process of an Epoxy/Fluorocarbon Coating System[J]. Acta Physico-Chimica Sinica, ;2012, 28(05): 1146-1152. doi: 10.3866/PKU.WHXB201202272 shu

Electrochemical Impedance Spectroscopy Study of Failure Process of an Epoxy/Fluorocarbon Coating System

1.
Key Laboratory of Carbon Fibers and Functional Polymers, Ministry of Education, School of Materials Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, P. R. China

Received Date: 30 December 2011
Available Online: 27 February 2012
Fund Project: 国家科技支撑计划项目(2007 BAB 27 B04)资助 (2007 BAB 27 B04)

The failure processes of a multi-layer coating system (zinc-rich epoxy primer, epoxy middle layer, and fluorocarbon topcoat) in four corrosion environments were studied with electrochemical impedance spectroscopy (EIS). The failure rate of the coating system in the four environments decreases in following order: immersion in a 3.5% NaCl solution under UV light, steam above a water surface at 45 ℃, salt spray at 35 ℃, and immersion in a 3.5% NaCl solution at room temperature. Although the failure rates of the coating system in the four environments are different, the variations of the phase angles at the middle frequency range, particularly 10 Hz, are very close to that of the coating impedance; hence they may be used as a qualitative evaluation parameter for coating inspection.
- Fluorocarbon coating,
- Electrochemical impedance spectroscopy,
- Performance,
- Failure,
- Fast evaluation,
- Phase angle
1. [1]
  (1) Scully, J. R. J. Electrochem. Soc. 1989, 136, 979.
2. [2]
  (2) Scully, J. R.; Hensley, S. T. Corrosion 1994, 50, 705.
3. [3]
  (3) VanWesting, E. P. M.; Ferrari, G. M.; DeWit, J. H.W. Corrosion Sci. 1994, 36, 979.
4. [4]
  (4) VanWesting, E. P. M.; Ferrari, G. M.; DeWit, J. H.W. Corrosion Sci. 1993, 34, 1511.
5. [5]
  (5) Grundmeier, G.; Schmidt,W.; Stratmann, M. Electrochim. Acta 2000, 45, 2515.
6. [6]
  (6) Marchebois, H.; Savall, C.; Bernard, J.; Touzain, S. Electrochim. Acta 2004, 49, 2945.
7. [7]
  (7) Marchebois, H.; Joiret, S.; Savall, C.; Bernard, J.; Touzain, S. Surf. Coat. Tech. 2002, 157, 151.
8. [8]
  (8) Marchebois, H.; Keddam, M.; Joiret, S.; Savall, C.; Bernard, J.; Touzain, S. Electrochim. Acta 2004, 49, 1719.
9. [9]
  (9) Barranco, V.; Feliu, S., Jr.; Feliu, S. Corrosion Sci. 2004, 46, 2203.
10. [10]
  (10) Philippe, L. V. S.; Lyon, S. B.; Sammon, C.; Yarwood, J. Corrosion Sci. 2008, 50, 887.
11. [11]
  (11) Raps, D.; Hack, T.;Wehr, J.; Zheludkevich, M. L.; Bastos, A. C.; Ferreira, M. G. S.; Nuyken, O. Corrosion Sci. 2009, 51, 1012.
12. [12]
  (12) McIntyre, J. M.; Pham, H. Q. Prog. Org. Coat. 1996, 27, 201.
13. [13]
  (13) Bierwagen,G. P.; He, L.; Li, J.; Ellingson, L.; Tallman, D. E. Prog. Org. Coat. 2000, 39, 67.
14. [14]
  (14) Macedo, M. C. S. S.; Margarit-Mattos, I. C. P.; Fragata, F. L.; Jorcin, J. B.; Pébère, N.; Mattos, O. R. Corrosion Sci. 2009, 51, 1322.
15. [15]
  (15) Akbarinezhad, E.; Bahremandi, M.; Faridi, H. R.; Rezaei, F. Corrosion Sci. 2009, 51, 356.
16. [16]
  (16) Haruyama, S.; Sudo, S. Electrochim. Acta 1993, 38, 1857.
17. [17]
  (17) Mansfeld, F.; Tsai, C. H. Corrosion 1991, 47, 958.
18. [18]
  (18) Mahdavian, M.; Attar, M. M. Corrosion Sci. 2006, 48, 4152.
19. [19]
  (19) Mehta, N. K.; Bogere, M. N. Prog. Org. Coat. 2009, 64, 419.
20. [20]
  (20) Zuo, Y.; Pang, R.; Li,W.; Xiong, J. P.; Tang, Y. M. Corrosion Sci. 2008, 50, 3322.
21. [21]
  (21) Miscovic-Stankovic, V. K.; Drazic, D. M.; Teodorovic, M. J. Corrosion Sci. 1995, 37, 241.
22. [22]
  (22) Wu, J. Technology and Applications of Fourier Transform Spectroscopy; Sci. Techn. Literature Pub.: Beijing, 1994; pp 256-310.
23. [23]
  (23) Deflorian, F.; Rossi, S.; Fedel, M. Corrosion Sci. 2008, 50, 2360.
24. [24]
  (24) Loveday, D.; Peterson, P.; Rodgers, B. JCT Coatings Tech. 2004, 1, 88.
1. [1]
  Hong Zheng , Xin Peng , Chunwang Yi . The Tale of Caprolactam Cyclic Oligomers: The Ever-changing Life of “Princess Cyclo”. University Chemistry, 2024, 39(9): 40-47. doi: 10.12461/PKU.DXHX202403058
2. [2]
  Fengqiao Bi , Jun Wang , Dongmei Yang . Specialized Experimental Design for Chemistry Majors in the Context of “Dual Carbon”: Taking the Assembly and Performance Evaluation of Zinc-Air Fuel Batteries as an Example. University Chemistry, 2024, 39(4): 198-205. doi: 10.3866/PKU.DXHX202311069
3. [3]
  Jingjie Tang , Luying Xie , Jiayu Liu , Shangyu Shi , Xinyu Sun , Jiayang Lin , Qikun Yang , Chuan'ang Yu , Zecheng Wang , Yingying Wang , Zengyang Xie . Efficient Rapid Synthesis and Antibacterial Activities of Tosylhydrazones: A Recommended Innovative Chemistry Experiment for Undergraduate Medical University. University Chemistry, 2024, 39(3): 316-326. doi: 10.3866/PKU.DXHX202309091
4. [4]
  Jiahong ZHENG , Jiajun SHEN , Xin BAI . Preparation and electrochemical properties of nickel foam loaded NiMoO₄/NiMoS₄ composites. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 581-590. doi: 10.11862/CJIC.20230253
5. [5]
  Zhihuan XU , Qing KANG , Yuzhen LONG , Qian YUAN , Cidong LIU , Xin LI , Genghuai TANG , Yuqing LIAO . Effect of graphene oxide concentration on the electrochemical properties of reduced graphene oxide/ZnS. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1329-1336. doi: 10.11862/CJIC.20230447
6. [6]
  Qin ZHU , Jiao MA , Zhihui QIAN , Yuxu LUO , Yujiao GUO , Mingwu XIANG , Xiaofang LIU , Ping NING , Junming GUO . Morphological evolution and electrochemical properties of cathode material LiAl_0.08Mn_1.92O₄ single crystal particles. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1549-1562. doi: 10.11862/CJIC.20240022
7. [7]
  Qingtang ZHANG , Xiaoyu WU , Zheng WANG , Xiaomei WANG . Performance of nano Li₂FeSiO₄/C cathode material co-doped by potassium and chlorine ions. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1689-1696. doi: 10.11862/CJIC.20240115
8. [8]
  Kun Xu , Xinxin Song , Zhilei Yin , Jian Yang , Qisheng Song . Comprehensive Experimental Design of Preferential Orientation of Zinc Metal by Heat Treatment for Enhanced Electrochemical Performance. University Chemistry, 2024, 39(4): 192-197. doi: 10.3866/PKU.DXHX202309050
9. [9]
  Yuanchao LI , Weifeng HUANG , Pengchao LIANG , Zifang ZHAO , Baoyan XING , Dongliang YAN , Li YANG , Songlin WANG . Effect of heterogeneous dual carbon sources on electrochemical properties of LiMn_0.8Fe_0.2PO₄/C composites. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 751-760. doi: 10.11862/CJIC.20230252
10. [10]
  Xinpeng LIU , Liuyang ZHAO , Hongyi LI , Yatu CHEN , Aimin WU , Aikui LI , Hao HUANG . Ga₂O₃ coated modification and electrochemical performance of Li_1.2Mn_0.54Ni_0.13Co_0.13O₂ cathode material. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1105-1113. doi: 10.11862/CJIC.20230488
11. [11]
  Jiahong ZHENG , Jingyun YANG . Preparation and electrochemical properties of hollow dodecahedral CoNi₂S₄ supported by MnO₂ nanowires. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1881-1891. doi: 10.11862/CJIC.20240170
12. [12]
  Hongyi LI , Aimin WU , Liuyang ZHAO , Xinpeng LIU , Fengqin CHEN , Aikui LI , Hao HUANG . Effect of Y(PO₃)₃ double-coating modification on the electrochemical properties of Li[Ni_0.8Co_0.15Al_0.05]O₂. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1320-1328. doi: 10.11862/CJIC.20230480
13. [13]
  Jinyi Sun , Lin Ma , Yanjie Xi , Jing Wang . Preparation and Electrocatalytic Nitrogen Reduction Performance Study of Vanadium Nitride@Nitrogen-Doped Carbon Composite Nanomaterials: A Recommended Comprehensive Chemistry Experiment. University Chemistry, 2024, 39(4): 184-191. doi: 10.3866/PKU.DXHX202310094
14. [14]
  Xiaomei Ning , Liang Zhan , Xiaosong Zhou , Jin Luo , Xunfu Zhou , Cuifen Luo . Preparation and Electro-Oxidation Performance of PtBi Supported on Carbon Cloth: A Recommended Comprehensive Chemical Experiment. University Chemistry, 2024, 39(11): 217-224. doi: 10.3866/PKU.DXHX202401085
15. [15]
  Lei Shu , Zhengqing Hao , Kai Yan , Hong Wang , Lihua Zhu , Fang Chen , Nan Wang . Development of a Double-Carbon Related Experiment: Preparation, Characterization and Carbon-Capture Ability of Eggshell-Derived CaO. University Chemistry, 2024, 39(4): 149-156. doi: 10.3866/PKU.DXHX202310134
16. [16]
  Kai CHEN , Fengshun WU , Shun XIAO , Jinbao ZHANG , Lihua ZHU . PtRu/nitrogen-doped carbon for electrocatalytic methanol oxidation and hydrogen evolution by water electrolysis. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1357-1367. doi: 10.11862/CJIC.20230350
17. [17]
  Min Gu , Huiwen Xiong , Liling Liu , Jilie Kong , Xueen Fang . Rapid Quantitative Detection of Procalcitonin by Microfluidics: An Instrumental Analytical Chemistry Experiment. University Chemistry, 2024, 39(4): 87-93. doi: 10.3866/PKU.DXHX202310120
18. [18]
  Liuchuang Zhao , Wenbo Chen , Leqian Hu . Discussion on Improvement of Teaching Contents about Common Evaluation Parameters in Analytical Chemistry. University Chemistry, 2024, 39(2): 379-391. doi: 10.3866/PKU.DXHX202308079
19. [19]
  Jianmin Hao , Ruifeng Wu , Ying Wang , Yijia Bai , Xuechuan Gao , Yuying Du . Reform and Practice of Physical Chemistry Course Based on Enhanced Process Assessment and Evaluation. University Chemistry, 2024, 39(8): 78-83. doi: 10.3866/PKU.DXHX202311103
20. [20]
  Zhaomei LIU , Wenshi ZHONG , Jiaxin LI , Gengshen HU . Preparation of nitrogen-doped porous carbons with ultra-high surface areas for high-performance supercapacitors. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 677-685. doi: 10.11862/CJIC.20230404

Get Citation

PDF

XML

Metrics

PDF Downloads(736)
Abstract views(2317)
HTML views(51)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142