Citation: LIU Guang-Cai, GONG Xiao-Yun, JIANG You, PIAO Yi-Qing, FANG Xiang, HUANG Ze-Jian, TIAN Di. Research and Application of Mass Spectrometry with Low Energy Electron Impact Ionization Source[J]. Chinese Journal of Analytical Chemistry, ;2019, 47(5): 686-694. doi: 10.19756/j.issn.0253-3820.181750 shu

Research and Application of Mass Spectrometry with Low Energy Electron Impact Ionization Source

LIU Guang-Cai ^1,2, ,
GONG Xiao-Yun ² ,
JIANG You ² ,
PIAO Yi-Qing ^2,3 ,
FANG Xiang ^1,2 ,
HUANG Ze-Jian ² ,
TIAN Di ¹

1.
College of Instrumentation & Electrical Engineering, Jilin University, Changchun 130061, China;
2.
Mass Spectrometry Engineering Technology Research Center, Center for Advanced Measurement Science, National Institute of Metrology, Beijing 100029, China;
3.
College of Life Sciences, China Jiliang University, Hangzhou 310018, China

Received Date: 2 December 2018
Revised Date: 10 February 2019

Fund Project: This work was supported by the National Key Research and Development Program of China (Nos.2016YFF0102603, 2017YFF0206204, 2012YQ12004907).

The changes of concentrations of O₂ and CO₂ in the tail gas of fermentation industry reflect some important physiological and metabolic parameters in the fermentation process. Monitoring of the tail gas of fermentation has important significance for guiding the fermentation process. However, traditional monitoring methods are time-consuming with low precision and poor versatility, and are not suitable to monitor fermentation tail gas accurately in real time. In the process mass spectrometry, the traditional 70 eV electron impact ionization source will produce a large number of fragment ions, which may overlap with different substances, thus increasing the difficulty of qualitative analysis and causing inaccurate monitoring results. In order to realize real-time, on-line accurate monitoring of fermentation tail gas, a quadrupole process mass spectrometry based on electron impact ionization was developed for on-line analysis. Through investigation of the relationship between emission current of filament and the electron receiving pole at low ionization energy, the ionization efficiency of the electron impact ionization source under low ionization energy mode was improved, and CO₂, O₂ and N₂ were tested. Experimental results showed that under the conditions including electron energy of 22 eV, electron receiving voltage of 22 V and filament emission current of 20-25 mA, the relative errors of quantitative detection of CO₂ with volume fraction of higher than 0.023% and O₂ with volume fraction of higher than 0.021% were all less than 1%. The instrument and the developed method had ideal application prospect in the rapid real-time, on-line monitoring of industrial processes.
- Fermentation tail gas monitoring,
- Electron impact ionization,
- Ionization energy,
- Filament emission current,
- Quadrupole mass spectrometry
1. [1]
2. [2]
3. [3]
4. [4]
5. [5]
6. [6]
7. [7]
8. [8]
9. [9]
10. [10]
11. [11]
12. [12]
13. [13]
14. [14]
15. [15]
16. [16]
17. [17]
18. [18]
19. [19]
20. [20]
21. [21]
22. [22]
23. [23]
24. [24]
25. [25]
26. [26]
27. [27]
28. [28]
29. [29]
30. [30]
31. [31]
32. [32]
33. [33]
1. [1]
  Chongjing Liu , Yujian Xia , Pengjun Zhang , Shiqiang Wei , Dengfeng Cao , Beibei Sheng , Yongheng Chu , Shuangming Chen , Li Song , Xiaosong Liu . Understanding Solid-Gas and Solid-Liquid Interfaces through Near Ambient Pressure X-Ray Photoelectron Spectroscopy. Acta Physico-Chimica Sinica, 2025, 41(2): 100013-0. doi: 10.3866/PKU.WHXB202309036
2. [2]
  Zian Lin , Yingxue Jin . Matrix-Assisted Laser Desorption/Ionization Mass Spectrometry (MALDI-MS) for Disease Marker Screening and Identification: A Comprehensive Experiment Teaching Reform in Instrumental Analysis. University Chemistry, 2024, 39(11): 327-334. doi: 10.12461/PKU.DXHX202403066
3. [3]
  Tengjiao Wang , Tian Cheng , Rongjun Liu , Zeyi Wang , Yuxuan Qiao , An Wang , Peng Li . Conductive Hydrogel-based Flexible Electronic System: Innovative Experimental Design in Flexible Electronics. University Chemistry, 2024, 39(4): 286-295. doi: 10.3866/PKU.DXHX202309094
4. [4]
  Zihao Guo , Shichen Ma , Kin Shing Chan . 烯烃环化反应中6电子试剂的等瓣相似性和等电子关系. University Chemistry, 2025, 40(6): 160-166. doi: 10.12461/PKU.DXHX202408038
5. [5]
  Shumin Zhang , Yaqi Wang , Zelin Wang , Libo Wang , Changsheng An , Difa Xu . Ultrafast electron transfer at the ZIS_1−x/UCN S-scheme interface enables efficient H₂O₂ photosynthesis coupled with tetracycline degradation. Acta Physico-Chimica Sinica, 2025, 41(11): 100136-0. doi: 10.1016/j.actphy.2025.100136
6. [6]
  Yuping Wei , Yiting Wang , Jialiang Jiang , Jinxuan Deng , Hong Zhang , Xiaofei Ma , Junjie Li . Interdisciplinary Teaching Practice——Flexible Wearable Electronic Skin for Low-Temperature Environments. University Chemistry, 2024, 39(10): 261-270. doi: 10.12461/PKU.DXHX202404007
7. [7]
  Jiali CHEN , Guoxiang ZHAO , Yayu YAN , Wanting XIA , Qiaohong LI , Jian ZHANG . Machine learning exploring the adsorption of electronic gases on zeolite molecular sieves. Chinese Journal of Inorganic Chemistry, 2025, 41(1): 155-164. doi: 10.11862/CJIC.20240408
8. [8]
  Yanan Jiang , Yuchen Ma . Brief Discussion on the Electronic Exchange Interaction in Quantum Chemistry Computations. University Chemistry, 2025, 40(3): 10-15. doi: 10.12461/PKU.DXHX202402058
9. [9]
  Yaqin Zheng , Lian Zhuo , Meng Li , Chunying Rong . Enhancing Understanding of the Electronic Effect of Substituents on Benzene Rings Using Quantum Chemistry Calculations. University Chemistry, 2025, 40(3): 193-198. doi: 10.12461/PKU.DXHX202406119
10. [10]
  Jingwen Wang , Minghao Wu , Xing Zuo , Yaofeng Yuan , Yahao Wang , Xiaoshun Zhou , Jianfeng Yan . Advances in the Application of Electrochemical Regulation in Investigating the Electron Transport Properties of Single-Molecule Junctions. University Chemistry, 2025, 40(3): 291-301. doi: 10.12461/PKU.DXHX202406023
11. [11]
  Jianchun Wang , Ruyu Xie . The Fantastical Dance of Miss Electron: Contra-Thermodynamic Electrocatalytic Reactions. University Chemistry, 2025, 40(4): 331-339. doi: 10.12461/PKU.DXHX202406082
12. [12]
  Qiwen Chen , Baolei Wang . Research Progress on One-Electron σ-Bond of Organic Compounds. University Chemistry, 2025, 40(11): 191-198. doi: 10.12461/PKU.DXHX202412136
13. [13]
  Jinfu Ma , Hui Lu , Jiandong Wu , Zhongli Zou . Teaching Design of Electrochemical Principles Course Based on “Cognitive Laws”: Kinetics of Electron Transfer Steps. University Chemistry, 2024, 39(3): 174-177. doi: 10.3866/PKU.DXHX202309052
14. [14]
  Liu Lin , Zemin Sun , Huatian Chen , Lian Zhao , Mingyue Sun , Yitao Yang , Zhensheng Liao , Xinyu Wu , Xinxin Li , Cheng Tang . Recent Advances in Electrocatalytic Two-Electron Water Oxidation for Green H₂O₂ Production. Acta Physico-Chimica Sinica, 2024, 40(4): 2305019-0. doi: 10.3866/PKU.WHXB202305019
15. [15]
  Zhaoyu Wen , Na Han , Yanguang Li . Recent Progress towards the Production of H₂O₂ by Electrochemical Two-Electron Oxygen Reduction Reaction. Acta Physico-Chimica Sinica, 2024, 40(2): 2304001-0. doi: 10.3866/PKU.WHXB202304001
16. [16]
  Wenxu Liu , Feng Han , Boxuan Wang , Huayi Liu , Xiaobin Gu , Xin Zhang , Yao Liu . Comprehensive Chemical Experiment: Design, Synthesis, and Photoelectronic Properties Study of Fully Non-Fused Ring Electron Acceptors. University Chemistry, 2025, 40(10): 263-275. doi: 10.12461/PKU.DXHX202412021
17. [17]
  Lin′an CAO , Dengyue MA , Gang XU . Research advances in electrically conductive metal-organic frameworks-based electrochemical sensors. Chinese Journal of Inorganic Chemistry, 2025, 41(10): 1953-1972. doi: 10.11862/CJIC.20250160
18. [18]
  Yuanchun Pan , Xinyun Lin , Leyi Yang , Wenya Hu , Dekui Song , Nan Liu . Artificial Intelligence Science Practice: Preparation of Electronic Skin by Chemical Vapor Deposition of Graphene. University Chemistry, 2025, 40(11): 272-280. doi: 10.12461/PKU.DXHX202412052
19. [19]
  Lingbang Qiu , Jiangmin Jiang , Libo Wang , Lang Bai , Fei Zhou , Gaoyu Zhou , Quanchao Zhuang , Yanhua Cui . In Situ Electrochemical Impedance Spectroscopy Monitoring of the High-Temperature Double-Discharge Mechanism of Nb₁₂WO₃₃ Cathode Material for Long-Life Thermal Batteries. Acta Physico-Chimica Sinica, 2025, 41(5): 100040-0. doi: 10.1016/j.actphy.2024.100040
20. [20]
  Donghui PAN , Yuping XU , Xinyu WANG , Lizhen WANG , Junjie YAN , Dongjian SHI , Min YANG , Mingqing CHEN . Preparation and in vivo tracing of ⁶⁸Ga-labeled PM_2.5 mimetic particles for positron emission tomography imaging. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 669-676. doi: 10.11862/CJIC.20230468

Get Citation

PDF

XML

Metrics

PDF Downloads(8)
Abstract views(981)
HTML views(201)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142