Citation: WANG Qing, YANG Qian-kun, XU Xiang-cheng, CUI Da, ZHANG Hong-xi, WANG Yi-fan. Application of FLASHCHAIN model in pyrolysis of Wangqing oil shale[J]. Journal of Fuel Chemistry and Technology, ;2016, 44(02): 138-145. shu

Application of FLASHCHAIN model in pyrolysis of Wangqing oil shale

1.
Northeast Dianli University, Engineering Research Centre of Oil Shale Comprehensive Utilization Ministry of Education, Jilin 132012, China

Corresponding author: WANG Qing,
Received Date: 2 September 2015
Available Online: 19 October 2015
Fund Project: 国家自然科学基金(51276034)项目资助. (51276034)

The carbon atom chemical structure of three Wangqing oil shales was characterized by ¹³C-NMR techniques,and twelve important parameters of the carbon skeleton structure were obtained.Thermogravimetric-Fourier transform infrared spectroscopy(TG-FTIR) tests were used to obtain the formation of light gases during pyrolysis at 50℃/min and the final temperature of 600℃.The FLASHCHAIN model,which was established based on the structure of fuel,was employed to simulate the evolution of pyrolysis products and compared with the experimental tests.The results show that the model has a good simulation below 520℃,some errors occur above 520℃ due to the influence of secondary pyrolysis reactions and decomposition of minerals in the shale.The errors increase gradually with the increasing pyrolysis temperature.
- oil shale,
- ¹³C-NMR,
- TG-FTIR,
- FLASHCHAIN
1. [1]
  [1] 刘招君,柳蓉.中国油页岩特征及开发利用前景分析[J].地学前缘,2005,12(3):315-322.(LIU Zhao-jun,LIU Rong.Oil shale resource state and evaluating system[J].Earth Science Frontiers,2005,12(3):315-323.)
2. [2]
  [2] HOU X L.Prospect of oil shale and shale oil industry.Proceedings international conference on oil shale oil[M].Beijing:Chemical Industry Press,1988:7-15.
3. [3]
  [3] QIAN J L,YIN L.Oil shale-petroleum alternative[M].Beijing:China Petrochemical Press,2008:30-34.
4. [4]
  [4] NIKSA S.FLASHCHAIN theory for rapid coal devolatilization.1.Formulation[J].Energy Fuels,1991,5(5):647-665.
5. [5]
  [5] NIKSA S.FLASHCHAIN theory for rapid coal devolatilization.2.Impact of operating conditions[J].Energy Fuels,1991,5(5):665-673.
6. [6]
  [6] NIKSA S.FLASHCHAIN theory for rapid coal devolatilization.3.Modeling the Behavior of Various Coals[J].Energy Fuels,1991,5(5):673-683.
7. [7]
  [7] NIKSA S.FLASHCHAIN theory for rapid coal devolatilization.4.Predicting ultimate yields from ultimate analyses alone[J].Energy Fuels,1994,8(3):659-670.
8. [8]
  [8] NIKSA S.FLASHCHAIN Theory for rapid coal devolatilization.5.Interpredicting rates of devolatilization for various coal types and operating conditions[J].Energy Fuels,1994,8(3):671-679.
9. [9]
  [9] NIKSA S.FLASHCHAIN theory for rapid coal devolatilization.6.Predicting the evolution of fuel nitrogen from various coals[J].Energy Fuels,1995,9(3):467-478.
10. [10]
  [10] NIKSA S.FLASHCHAIN theory for rapid coal devolatilization.7.Predicting the release of oxygen species from various coals[J].Energy Fuels,1996,10(1):173-187.
11. [11]
  [11] SOLOMON P R,HAMBIEN D G,CARANGRLO R M.General model of coal devolatilization[J].Energy Fuels,1988,2(4):405-422.
12. [12]
  [12] GRANT D M,PUGMIRE R J,FLETCHER T H.Chemical model of coal devolatilization using percolation lattice statistics[J].Energy Fuels,1989,3(2):175-186.
13. [13]
  [13] FLETCHER T H,KERSTEIN A R,PUGMIRE R J.Chemical percolation model for devolatilization.2.Temperature and heating rate effects on product yields[J].Energy Fuels,1990,4(1):54-60.
14. [14]
  [14] THOMAS FLETCHER.Chemical percolation model for devolatilization[J].Energy Fuels,1992,6(1):414-431.
15. [15]
  [15] JUPUDI R S,ZAMANSKY V,FLETCHER T H.Prediction of light gas composition in coal devolatilization[J].Energy Fuels,2009,23(6):3063-3067.
16. [16]
  [16] NIKSA S.Predicting the rapid devolatilization of diverse forms of biomass with bio-FLASHCHAIN[J].Proc Combust Inst,2000,28(2):2727-2733.
17. [17]
  [17] CHEN Y,CHARPENAY S,JENSEN A.Modeling of biomass pyrolysis kinetics[J].Symp(Int) Combust,1998,27(1):1327-1334.
18. [18]
  [18] FLETCHER T H,HARLAND R,WEBSTER J.Prediction of tar and light gas during pyrolysis of black liquor and biomass[J].Energy Fuels,2012,26(6):3381-3387.
19. [19]
  [19] DOMINIC B.An advanced model of coal devolatilization based on chemical structure[D].Provo:Brigham Young University,1999:39-40.
20. [20]
  [20] 秦匡宗,劳永新.茂名和抚顺油页岩组成结构的研究I.有机质的芳碳结构[J].燃料化学学报,1985,13(2):133-140.(QIN Kuang-zong,LAO Yong-xin.Investigation on the constitution and structure of Maoming and Fushun oil shale I.The structural components of the organic matter[J].J Fuel Chem Technol,1985,13(2):133-140.)
21. [21]
  [21] TONG J,HAN X,WANG S.Evaluation of structural characteristics of huadian oil shale kerogen using direct techniques(Solid-State ¹³C-NMR,XPS,FT-IR and XRD)[J].Energy Fuels,2011,25(9):4006-4013.
22. [22]
  [22] SOLUM M S,PUGMIRE R J,GRANT D M.¹³C solid-state NMR argonne premium coals[J].Energy Fuels,1989,3(2):187-193.
1. [1]
  Wenwen Zhang , Peichao Zhang , Conghao Gai , Xiaoyun Chai , Yan Zou , Qingjie Zhao . Unveiling Kinetics at Natural Abundance: ¹³C NMR Isotope Effect Experiments. University Chemistry, 2025, 40(10): 203-207. doi: 10.12461/PKU.DXHX202411076
2. [2]
  Zihan Cheng , Kai Jiang , Jun Jiang , Henggang Wang , Hengwei Lin . Achieving thermal-stimulus-responsive dynamic afterglow from carbon dots by singlet-triplet energy gap engineering through covalent fixation. Acta Physico-Chimica Sinica, 2026, 42(2): 100169-0. doi: 10.1016/j.actphy.2025.100169
3. [3]
  Yu Xiong , Li-Jun Hu , Jian-Guo Song , Di Zhang , Yi-Shuang Peng , Xiao-Jun Huang , Jian Hong , Bin Zhu , Wen-Cai Ye , Ying Wang . Structure elucidation of plumerubradins A–C: Correlations between ¹H NMR signal patterns and structural information of [2+2]-type cyclobutane derivatives. Chinese Chemical Letters, 2025, 36(5): 110149-. doi: 10.1016/j.cclet.2024.110149
4. [4]
  Qi Wu , Changhua Wang , Yingying Li , Xintong Zhang . Enhanced photocatalytic synthesis of H₂O₂ by triplet electron transfer at g-C₃N₄@BN van der Waals heterojunction interface. Acta Physico-Chimica Sinica, 2025, 41(9): 100107-0. doi: 10.1016/j.actphy.2025.100107
5. [5]
  Yang Wang , Yunpeng Fu , Xiaoji Liu , Guotao Zhang , Guobin Li , Wanqiang Liu , Jinglun Wang . Structural Analysis of Nitrile Solutions Based on Infrared Spectroscopy Probes. University Chemistry, 2025, 40(4): 367-374. doi: 10.12461/PKU.DXHX202406113
6. [6]
  Xue Wu , Yupeng Liu , Bingzhe Wang , Lingyun Li , Zhenjian Li , Qingcheng Wang , Quansheng Cheng , Guichuan Xing , Songnan Qu . Rationally assembling different surface functionalized carbon dots for enhanced near-infrared tumor photothermal therapy. Acta Physico-Chimica Sinica, 2025, 41(9): 100109-0. doi: 10.1016/j.actphy.2025.100109
7. [7]
  Yecang Tang , Shan Ling , Zhen Fang . Exploration of a Hierarchical and Integration-Oriented Talent Training Model in the Demonstration Center for Experimental Chemistry Education. University Chemistry, 2024, 39(7): 188-192. doi: 10.12461/PKU.DXHX202405107
8. [8]
  Linhan Tian , Changsheng Lu . Discussion on Sextuple Bonding in Diatomic Motifs of Chromium Family Elements. University Chemistry, 2024, 39(8): 395-402. doi: 10.3866/PKU.DXHX202401056
9. [9]
  Zhuo WANG , Junshan ZHANG , Shaoyan YANG , Lingyan ZHOU , Yedi LI , Yuanpei LAN . Preparation and photocatalytic performance of CeO₂-reduced graphene oxide by thermal decomposition. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1708-1718. doi: 10.11862/CJIC.20240067
10. [10]
  Yang Lv , Yingping Jia , Yanhua Li , Hexiang Zhong , Xinping Wang . Integrating the Ideological Elements with the “Chemical Reaction Heat” Teaching. University Chemistry, 2024, 39(11): 44-51. doi: 10.12461/PKU.DXHX202402059
11. [11]
  Yang ZHOU , Lili YAN , Wenjuan ZHANG , Pinhua RAO . Thermal regeneration of biogas residue biochar and the ammonia nitrogen adsorption properties. Chinese Journal of Inorganic Chemistry, 2025, 41(8): 1574-1588. doi: 10.11862/CJIC.20250032
12. [12]
  Zehua Zhao , Xiaoyan An , Jinrong Xu , Ling Yang , Hao Zhao , Zhongyun Wu . Independent Development and Application of Calorimetric Experiment Data Acquisition and Processing Software. University Chemistry, 2025, 40(11): 402-408. doi: 10.12461/PKU.DXHX202505045
13. [13]
  Xinzhi Ding , Chong Liu , Jing Niu , Nan Chen , Shutao Xu , Yingxu Wei , Zhongmin Liu . Solid-state NMR study of the stability of MOR framework aluminum. Chinese Journal of Structural Chemistry, 2024, 43(4): 100247-100247. doi: 10.1016/j.cjsc.2024.100247
14. [14]
  Jiahui CHEN , Tingting ZHENG , Xiuyun ZHANG , Wei LÜ . Research progress of near-infrared absorption inorganic nanomaterials in photothermal and photodynamic therapy of tumors. Chinese Journal of Inorganic Chemistry, 2024, 40(12): 2396-2414. doi: 10.11862/CJIC.20240106
15. [15]
  Han ZHANG , Jianfeng SUN , Jinsheng LIANG . Hydrothermal synthesis and luminescent properties of broadband near-infrared Na₃CrF₆ phosphor. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 349-356. doi: 10.11862/CJIC.20240098
16. [16]
  Mingjie Lei , Wenting Hu , Kexin Lin , Xiujuan Sun , Haoshen Zhang , Ye Qian , Tongyue Kang , Xiulin Wu , Hailong Liao , Yuan Pan , Yuwei Zhang , Diye Wei , Ping Gao . Accelerating the reconstruction of NiSe₂ by Co/Mn/Mo doping for enhanced urea electrolysis. Acta Physico-Chimica Sinica, 2025, 41(8): 100083-0. doi: 10.1016/j.actphy.2025.100083
17. [17]
  Limei CHEN , Mengfei ZHAO , Lin CHEN , Ding LI , Wei LI , Weiye HAN , Hongbin WANG . Preparation and performance of paraffin/alkali modified diatomite/expanded graphite composite phase change thermal storage material. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 533-543. doi: 10.11862/CJIC.20230312
18. [18]
  Yuting Bai , Cenqi Yan , Zhen Li , Jiaqiang Qin , Pei Cheng . Preparation of High-Strength Polyimide Porous Films with Thermally Closed Pore Property by In Situ Pore Formation Method. Acta Physico-Chimica Sinica, 2024, 40(9): 2306010-0. doi: 10.3866/PKU.WHXB202306010
19. [19]
  Hanqi Zhang , Biao Gao , Yuanyuan Feng , Guijuan Zheng , Zhijun Liu , Lichun Kong , Junjun Liu , Haji Akber Aisa , Guangmin Yao . DFT calculations and dynamic NMR revealed the coalescent NMR phenomena of the 6/6/6/9 tetracyclic merosesquiterpenoids with an unprecedented 9,15-dioxatetracyclo[8.5.3.0^4,17.0^14,18]octadecane core skeleton. Chinese Chemical Letters, 2025, 36(9): 111234-. doi: 10.1016/j.cclet.2025.111234
20. [20]
  Qi Wang , Yicong Gao , Feng Lu , Quli Fan . Preparation and Performance Characterization of the Second Near-Infrared Phototheranostic Probe: A New Design and Teaching Practice of Polymer Chemistry Comprehensive Experiment. University Chemistry, 2024, 39(11): 342-349. doi: 10.12461/PKU.DXHX202404141

Get Citation

PDF

XML

Metrics

PDF Downloads(1)
Abstract views(714)
HTML views(66)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142