Citation: Zhu Chan, Hai Yang, Zhao Zhigang, Yang Yaoyue. Preliminary Study of Ni and P Low-doped Pd-based Electrocatalysts Toward Ethanol Oxidation Reaction in Alkaline Media[J]. Acta Chimica Sinica, ;2018, 76(1): 30-34. doi: 10.6023/A17060279 shu

Preliminary Study of Ni and P Low-doped Pd-based Electrocatalysts Toward Ethanol Oxidation Reaction in Alkaline Media

College of Chemistry and Environmental Protection Engineering, Southwest Minzu University, Chengdu 610041

Corresponding author: Yang Yaoyue, yaoyueyoung@swun.edu.cn
Received Date: 26 June 2017
Available Online: 10 January 2017
Fund Project: the Fundamental Research Funds for the Central Universities 2017NGJPY05the National Natural Science Foundation of China 21603177the Innovation Funds for SMU students 201610656050the Natural Science Foundation of Sichuan Province 2016JY0212Project supported by the National Natural Science Foundation of China (No. 21603177), the Natural Science Foundation of Sichuan Province (No. 2016JY0212), the Fundamental Research Funds for the Central Universities (No. 2017NGJPY05) and the Innovation Funds for SMU students (No. 201610656050)

Figures(5)

Among currently reported anodic nano-alloy electrocatlysts for direct alkaline ethanol fuel cells (DAEFCs), the mass fraction (w) of co-catalysts is generally larger than 20%. This could increase the thickness of the catalyst layer in Membrane Electrode Assembly (MEA), which not only decreases the discharge voltage of fuel cells, also reduces the utilization of the noble metals such as Pt and Pd. To solve this problem, here we synthesized a series of Pd-Ni-P alloy electrocatalysts with ultra-low doping amount of Ni and P, using ca. 1.5 mg NaH₂PO₂ as reducing agent. To obtain different doping amount of Ni and P, the pH value of the synthetic solution was adjusted from 8 to 12 by 0.1 mol/L NaOH. Inductively Coupled Plasma-Atomic Emission Spectrometry (ICP-AES) results showed that the mass fraction of Ni and P were low to 0.2% and 0.05%, respectively, when the pH value of the synthetic solution is 10. Transmission Electron Microscopy (TEM) images showed that nanoparticles were distributed evenly on the carbon base, and their mean particle sizes increased from ca. 3.78 nm to ca. 5.4 nm with alkalinity of synthetic solutions increasing. Cyclic Voltammograms in 0.5 mol/L CH₃CH₂OH+1 mol/L NaOH solution revealed that the catalyst obtained under the pH 10 synthetic solution (hereafter denoted as Pd-Ni-P/C-pH10) gave a highest apparent current density of ca. 2466 mA•mg^-1 Pd, nearly 2.7 times in respect of that of the commercial Pd/C catalyst (JM). Meanwhile, the durability of Pd-Ni-P/C-pH10 for ethanol oxidation was improved by ca. 2.8 times compared to commercial catalyst. Relative to pure Pd, the binding energy of Pd 3d_5/2 of as-prepared catalysts all positively shifted, suggesting an obvious electronic interaction between Pd, Ni and P component in as-prepared catalysts. This interaction could led to a shift of the d-band center of Pd component, which may play a pivotal and dominated role in improving the catalytic performance for the ethanol electrooxidation in alkaline media.
- low-doping alloy,
- electrocatalysts,
- ethanol oxidation reaction,
- alkaline media,
- enhanced performance
1. [1]
  Antolini, E.; Gonzalez, E. J. Power Sources 2010, 195, 3431. doi: 10.1016/j.jpowsour.2009.11.145
2. [2]
  Rabis, A.; Rodriguez, P.; Schmidt, T. J. ACS Catalysis 2012, 2, 864. doi: 10.1021/cs3000864
3. [3]
  Xie, S.-W.; Chen, S.; Liu, Z.-Q.; Xu, C.-W. Int. J. Electrochem. Sci 2011, 6, 882.
4. [4]
  Wang, Y.; Zou, S.; Cai, W.-B. Catalysis 2015, 5, 1507.
5. [5]
  Bianchini, C.; Shen, P. K. Chem. Rev. 2009, 109, 4183. doi: 10.1021/cr9000995
6. [6]
  Antolini, E. J. Power Sources 2007, 170, 1. doi: 10.1016/j.jpowsour.2007.04.009
7. [7]
  Demirci, U. B. J. Power Sources 2007, 173, 11. doi: 10.1016/j.jpowsour.2007.04.069
8. [8]
  Kitchin, J. R.; Nørskov, J. K.; Barteau, M. A.; Chen, J. Phys. Rev. Lett. 2004, 93, 156801. doi: 10.1103/PhysRevLett.93.156801
9. [9]
  Liu, P.; Nørskov, J. K. Phys. Chem. Chem. Phys. 2001, 3, 3814. doi: 10.1039/b103525h
10. [10]
  Vigier, F.; Coutanceau, C.; Hahn, F.; Belgsir, E.; Lamy, C. J. Electroanal. Chem. 2004, 563, 81. doi: 10.1016/j.jelechem.2003.08.019
11. [11]
  Yajima, T.; Uchida, H.; Watanabe, M. J. Phys. Chem. B 2004, 108, 2654. doi: 10.1021/jp037215q
12. [12]
  Wang, Y.; Shi, F.-F.; Yang, Y.-Y.; Cai, W.-B. J. Power Sources 2013, 243, 369. doi: 10.1016/j.jpowsour.2013.06.021
13. [13]
  Jiang, R.; Tran, D. T.; McClure, J. P.; Chu, D. ACS Catal. 2014, 4, 2577. doi: 10.1021/cs500462z
14. [14]
  Chen, L.; Lu, L.; Zhu, H.; Chen, Y.; Huang, Y.; Li, Y.; Wang, L. Nat. Commun. 2017, 8, 14136. doi: 10.1038/ncomms14136
15. [15]
  Qi, Z.; Geng, H.; Wang, X.; Zhao, C.; Ji, H.; Zhang, C.; Xu, J.; Zhang, Z. J. Power Sources 2011, 196, 5823. doi: 10.1016/j.jpowsour.2011.02.083
16. [16]
  Ahmed, M. S.; Jeon, S. ACS Catal. 2014, 4, 1830. doi: 10.1021/cs500103a
17. [17]
  Ma, L.; He, H.; Hsu, A.; Chen, R. J. Power Sources 2013, 241, 696. doi: 10.1016/j.jpowsour.2013.04.051
18. [18]
  Du, W.; Mackenzie, K. E.; Milano, D. F.; Deskins, N. A.; Su, D.; Teng, X. ACS Catal. 2012, 2, 287. doi: 10.1021/cs2005955
19. [19]
  Mao, H.; Wang, L.; Zhu, P.; Xu, Q.; Li, Q. Int. J. Hydrogen Energy 2014, 39, 17583. doi: 10.1016/j.ijhydene.2014.08.079
20. [20]
  Huang, M.-H.; Jin, B.-Y.; Zhao, L.-H.; Sun, S.-G. Acta Phys.-Chim. Sin. 2017, 33, 563(in Chinese). doi: 10.3866/PKU.WHXB201612072
21. [21]
  Tao, X.; Li, L.; Qi, X.; Wei, Z. Acta Chim. Sinica 2016, 75, 237(in Chinese).
22. [22]
  Lai, Q.-Z.; Yin, G.-P.; Wang, Z.-B. J. Chem. Eng. Chin. Univ. 2009, 23, 756(in Chinese). doi: 10.3321/j.issn:1003-9015.2009.05.005
23. [23]
  Wang, N.; Zhang, W.; Wang, Y.-X. Chem. Ind. Eng. 2017, 34, 80(in Chinese).
24. [24]
  Wang, J.-Y.; Kang, Y.-Y.; Yang, H.; Cai, W.-B. J. Phys. Chem. C 2009, 113, 8366.
25. [25]
  Yang, G.; Chen, Y.; Zhou, Y.; Tang, Y.; Lu, T. Electrochem. Commun. 2010, 12, 492. doi: 10.1016/j.elecom.2010.01.029
26. [26]
  Mao, X. Y.; Liang, X. P.; Liu, J.; Liu, L.; Liu, K. Key Eng. Mater. 2014, 633, 330. doi: 10.4028/www.scientific.net/KEM.633
27. [27]
  Dutta, A.; Datta, J. J. Phys. Chem. C 2012, 116, 25677. doi: 10.1021/jp305323s
28. [28]
  Yin, J.; Shan, S.; Ng, M. S.; Yang, L.; Mott, D.; Fang, W.; Kang, N.; Luo, J.; Zhong, C. J. Langmuir 2013, 29, 9249. doi: 10.1021/la401839m
29. [29]
  Mao, H.; Huang, T.; Yu, A. S. J. Mater. Chem. A 2014, 2, 16378. doi: 10.1039/C4TA03911D
30. [30]
  Li, L.; Chen, M.; Huang, G.; Yang, N.; Zhang, L.; Wang, H.; Liu, Y.; Wang, W.; Gao, J. J. Power Sources 2014, 263, 13. doi: 10.1016/j.jpowsour.2014.04.021
31. [31]
  Huang, Z.; Zhou, H.; Li, C.; Zeng, F.; Fu, C.; Kuang, Y. J. Mater. Chem. 2012, 22, 1781. doi: 10.1039/C1JM13024B
32. [32]
  Shen, S.; Zhao, T.; Xu, J.; Li, Y. J. Power Sources 2010, 195, 1001. doi: 10.1016/j.jpowsour.2009.08.079
33. [33]
  Wakisaka, M.; Mitsui, S.; Hirose, Y.; Kawashima, K.; Uchida, H.; Watanabe, M. J. Phys. Chem. B 2006, 110, 23489. doi: 10.1021/jp0653510
34. [34]
  Wang, J.-Y.; Zhang, H.-X.; Jiang, K.; Cai, W.-B. J. Am. Chem. Soc. 2011, 133, 14876. doi: 10.1021/ja205747j
35. [35]
  Rodriguez, P.; Kwon, Y.; Koper, M. T. Nat. Chem. 2012, 4, 177. doi: 10.1038/nchem.1221
36. [36]
  Yang, Y.-Y.; Ren, J.; Li, Q.-X.; Zhou, Z.-Y.; Sun, S.-G.; Cai, W.-B. ACS Catal. 2014, 4, 798. doi: 10.1021/cs401198t
1. [1]
  Hailang JIA , Hongcheng LI , Pengcheng JI , Yang TENG , Mingyun GUAN . Preparation and performance of N-doped carbon nanotubes composite Co₃O₄ as oxygen reduction reaction electrocatalysts. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 693-700. doi: 10.11862/CJIC.20230402
2. [2]
  Yang WANG , Xiaoqin ZHENG , Yang LIU , Kai ZHANG , Jiahui KOU , Linbing SUN . Mn single-atom catalysts based on confined space: Fabrication and the electrocatalytic oxygen evolution reaction performance. Chinese Journal of Inorganic Chemistry, 2024, 40(11): 2175-2185. doi: 10.11862/CJIC.20240165
3. [3]
  Kai CHEN , Fengshun WU , Shun XIAO , Jinbao ZHANG , Lihua ZHU . PtRu/nitrogen-doped carbon for electrocatalytic methanol oxidation and hydrogen evolution by water electrolysis. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1357-1367. doi: 10.11862/CJIC.20230350
4. [4]
  Juan WANG , Zhongqiu WANG , Qin SHANG , Guohong WANG , Jinmao LI . NiS and Pt as dual co-catalysts for the enhanced photocatalytic H₂ production activity of BaTiO₃ nanofibers. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1719-1730. doi: 10.11862/CJIC.20240102
5. [5]
  Jiapei Zou , Junyang Zhang , Xuming Wu , Cong Wei , Simin Fang , Yuxi Wang . A Comprehensive Experiment Based on Electrocatalytic Nitrate Reduction into Ammonia: Synthesis, Characterization, Performance Exploration, and Applicable Design of Copper-based Catalysts. University Chemistry, 2024, 39(6): 373-382. doi: 10.3866/PKU.DXHX202312081
6. [6]
  Zelong LIANG , Shijia QIN , Pengfei GUO , Hang XU , Bin ZHAO . Synthesis and electrocatalytic CO₂ reduction performance of metal-organic framework catalysts loaded with silver particles. Chinese Journal of Inorganic Chemistry, 2025, 41(1): 165-173. doi: 10.11862/CJIC.20240409
7. [7]
  Bing WEI , Jianfan ZHANG , Zhe CHEN . Research progress in fine tuning of bimetallic nanocatalysts for electrocatalytic carbon dioxide reduction. Chinese Journal of Inorganic Chemistry, 2025, 41(3): 425-439. doi: 10.11862/CJIC.20240201
8. [8]
  Xin Han , Zhihao Cheng , Jinfeng Zhang , Jie Liu , Cheng Zhong , Wenbin Hu . Design of Amorphous High-Entropy FeCoCrMnBS (Oxy) Hydroxides for Boosting Oxygen Evolution Reaction. Acta Physico-Chimica Sinica, 2025, 41(4): 100033-. doi: 10.3866/PKU.WHXB202404023
9. [9]
  Meng Lin , Hanrui Chen , Congcong Xu . Preparation and Study of Photo-Enhanced Electrocatalytic Oxygen Evolution Performance of ZIF-67/Copper(I) Oxide Composite: A Recommended Comprehensive Physical Chemistry Experiment. University Chemistry, 2024, 39(4): 163-168. doi: 10.3866/PKU.DXHX202308117
10. [10]
  Chuanming GUO , Kaiyang ZHANG , Yun WU , Rui YAO , Qiang ZHAO , Jinping LI , Guang LIU . Performance of MnO₂-0.39IrO_x composite oxides for water oxidation reaction in acidic media. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1135-1142. doi: 10.11862/CJIC.20230459
11. [11]
  Tian TIAN , Meng ZHOU , Jiale WEI , Yize LIU , Yifan MO , Yuhan YE , Wenzhi JIA , Bin HE . Ru-doped Co₃O₄/reduced graphene oxide: Preparation and electrocatalytic oxygen evolution property. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 385-394. doi: 10.11862/CJIC.20240298
12. [12]
  Yuchen Zhou , Huanmin Liu , Hongxing Li , Xinyu Song , Yonghua Tang , Peng Zhou . 设计热力学稳定的贵金属单原子光催化剂用于乙醇的高效非氧化转化形成高纯氢和增值产物乙醛. Acta Physico-Chimica Sinica, 2025, 41(6): 100067-. doi: 10.1016/j.actphy.2025.100067
13. [13]
  Wenlong LI , Xinyu JIA , Jie LING , Mengdan MA , Anning ZHOU . Photothermal catalytic CO₂ hydrogenation over a Mg-doped In₂O_3-x catalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 919-929. doi: 10.11862/CJIC.20230421
14. [14]
  Zhanggui DUAN , Yi PEI , Shanshan ZHENG , Zhaoyang WANG , Yongguang WANG , Junjie WANG , Yang HU , Chunxin LÜ , Wei ZHONG . Preparation of UiO-66-NH₂ supported copper catalyst and its catalytic activity on alcohol oxidation. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 496-506. doi: 10.11862/CJIC.20230317
15. [15]
  Wen YANG , Didi WANG , Ziyi HUANG , Yaping ZHOU , Yanyan FENG . La promoted hydrotalcite derived Ni-based catalysts: In situ preparation and CO₂ methanation performance. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 561-570. doi: 10.11862/CJIC.20230276
16. [16]
  Qingqing SHEN , Xiangbowen DU , Kaicheng QIAN , Zhikang JIN , Zheng FANG , Tong WEI , Renhong LI . Self-supporting Cu/α-FeOOH/foam nickel composite catalyst for efficient hydrogen production by coupling methanol oxidation and water electrolysis. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1953-1964. doi: 10.11862/CJIC.20240028
17. [17]
  Zhiquan Zhang , Baker Rhimi , Zheyang Liu , Min Zhou , Guowei Deng , Wei Wei , Liang Mao , Huaming Li , Zhifeng Jiang . Insights into the Development of Copper-based Photocatalysts for CO₂ Conversion. Acta Physico-Chimica Sinica, 2024, 40(12): 2406029-. doi: 10.3866/PKU.WHXB202406029
18. [18]
  Yi YANG , Shuang WANG , Wendan WANG , Limiao CHEN . Photocatalytic CO₂ reduction performance of Z-scheme Ag-Cu₂O/BiVO₄ photocatalyst. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 895-906. doi: 10.11862/CJIC.20230434
19. [19]
  Zhao Lu , Hu Lv , Qinzhuang Liu , Zhongliao Wang . Modulating NH₂ Lewis Basicity in CTF-NH₂ through Donor-Acceptor Groups for Optimizing Photocatalytic Water Splitting. Acta Physico-Chimica Sinica, 2024, 40(12): 2405005-. doi: 10.3866/PKU.WHXB202405005
20. [20]
  Peng YUE , Liyao SHI , Jinglei CUI , Huirong ZHANG , Yanxia GUO . Effects of Ce and Mn promoters on the selective oxidation of ammonia over V₂O₅/TiO₂ catalyst. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 293-307. doi: 10.11862/CJIC.20240210

Get Citation

PDF

XML

Metrics

PDF Downloads(5)
Abstract views(1711)
HTML views(198)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142