Citation: CAO Dandan, LÜ Rong, YU Anchi. Preparation and Characterization of Carbon Nitride Film with High Optical Quality[J]. Acta Physico-Chimica Sinica, ;2019, 35(4): 442-450. doi: 10.3866/PKU.WHXB201805163 shu

Preparation and Characterization of Carbon Nitride Film with High Optical Quality

Department of Chemistry, Renmin University of China, Beijing 100872, P. R. China

Corresponding author: YU Anchi, yuac@ruc.edu.cn
Received Date: 3 April 2018
Revised Date: 14 May 2018
Accepted Date: 14 May 2018
Available Online: 16 April 2018
Fund Project: The project was supported by the National Natural Science Foundation of China (21773306)the National Natural Science Foundation of China 21773306

Graphitic carbon nitride (g-CN), as a nonmetal semiconductor material, has been widely used in various fields, such as photocatalysis, electrocatalysis, batteries, light-emitting diodes, and solar cells, owing to its unique electronic and photophysical properties. However, the application of g-CN in practical devices remains limited because of the difficulties in fabricating g-CN films of high quality. In this work, we report a method for preparing a g-CN film with high optical quality on a substrate of indium tin oxide (ITO) glass and/or soda lime (NaCa) glass by using melamine as a precursor. First, we prepared the bulk g-CN from melamine in a muffle furnace via thermal polymerization. Then, we fabricated the g-CN film on the ITO and/or NaCa glass substrate with fine-milled, bulk g-CN in a tube furnace using thermal vapor deposition. With this two-step method, a yellow, transparent g-CN film with high optical quality was successfully fabricated on both the ITO and/or NaCa glass substrates. To check the quality of the film, we used scanning electron microscopy (SEM) to study the morphology of the fabricated g-CN film on the ITO glass substrate. Both the high-resolution and low-resolution SEM image results show that the obtained g-CN film on the ITO glass substrate had a homogeneous and dense structure without a corrugated surface, illustrating that it had good surface roughness. Then, we investigated the thickness and surface roughness of the g-CN film via atomic force microscopy (AFM). The AFM results show that the thickness of the g-CN film deposited on the ITO glass substrate was around 300 nm and that the surface roughness of the g-CN film deposited on the ITO glass substrate was less than 40 nm. To verify the chemical composition of the obtained g-CN film on the ITO glass substrate, we performed X-ray photoelectron spectroscopy (XPS) and energy-dispersive spectroscopy (EDS) analyses. Both the XPS and EDS results demonstrate that the chemical composition of the g-CN film deposited on the ITO glass substrate was similar to that of bulk g-CN powder. More importantly, we determined the band structure for the g-CN film deposited on the ITO glass substrate by using a combination of steady-state absorption and high-resolution valence band XPS analysis. It was found that the determined band structure for the g-CN film deposited on the ITO glass substrate was close to that of bulk g-CN powder, also indicating that its chemical composition was similar to that of bulk g-CN. Meanwhile, we also found that the prepared g-CN film on the ITO glass substrate effectively degraded methylene blue dye under Xe lamp irradiation, which was similar to the effect of bulk g-CN powder. All analyses performed demonstrate that the two-step method presented in this study could successfully fabricate a g-CN film with high optical quality. In addition, we also analyzed the fluorescence lifetime of the g-CN film deposited on the ITO glass substrate by using a homemade time-correlated single-photon counting apparatus and found that it was much shorter than that of bulk g-CN.
- Carbon nitride film,
- Two-step method of vapor deposition,
- Morphology,
- Composition,
- Steady-state absorption,
- Fluorescence spectroscopy,
- Time-correlated single-photon counting,
1. [1]
  Wang, X.; Maeda, K.; Thomas, A.; Takanabe, K.; Xin, G.; Carlsson, J. M.; Domen, K.; Antonietti, M. Nat. Mater. 2009, 8 (1), 76. doi: 10.1038/nmat2317 doi: 10.1038/nmat2317
2. [2]
  Zhou, L.; Zhang, H.; Sun, H.; Liu, S.; Tade, M. O.; Wang, S.; Jin, W. Catal. Sci. Technol. 2016, 6 (19), 7002. doi: 10.1039/c6cy01195k doi: 10.1039/c6cy01195k
3. [3]
  Wen, J.; Xie, J.; Chen, X.; Li, X. Appl. Surf. Sci. 2017, 391, 72. doi: 10.1016/j.apsusc.2016.07.030 doi: 10.1016/j.apsusc.2016.07.030
4. [4]
  Miller, T. S.; Jorge, A. B.; Suter, T. M.; Sella, A.; Cora, F.; McMillan, P. F. Phys. Chem. Chem. Phys. 2017, 19 (24), 15613. doi: 10.1039/c7cp02711g doi: 10.1039/c7cp02711g
5. [5]
  Ong, W. J.; Tan, L. L.; Ng, Y. H.; Yong, S. T.; Chai, S. P. Chem. Rev. 2016, 116 (12), 7159. doi: 10.1021/acs.chemrev.6b00075 doi: 10.1021/acs.chemrev.6b00075
6. [6]
  Cao, S.; Yu, J. J. Phys. Chem. Lett. 2014, 5 (12), 2101. doi: 10.1021/jz500546b doi: 10.1021/jz500546b
7. [7]
  Martin, D. J.; Qiu, K.; Shevlin, S. A.; Handoko, A. D.; Chen, X.; Guo, Z.; Tang, J. Angew. Chem. Int. Ed. 2014, 53 (35), 9240. doi: 10.1002/anie.201403375 doi: 10.1002/anie.201403375
8. [8]
  Han, Q.; Wang, B.; Gao, J.; Cheng, Z.; Zhao, Y.; Zhang, Z.; Qu, L. ACS Nano 2016, 10 (2), 2745. doi: 10.1021/acsnano.5b07831 doi: 10.1021/acsnano.5b07831
9. [9]
  Ou, H.; Lin, L.; Zheng, Y.; Yang, P.; Fang, Y.; Wang, X. Adv. Mater. 2017, 29 (22), 1700008. doi: 10.1002/adma.201700008 doi: 10.1002/adma.201700008
10. [10]
  Lin, Z.; Wang, X. Angew. Chem. Int. Ed. 2013, 52 (6), 1735. doi: 10.1002/anie.201209017 doi: 10.1002/anie.201209017
11. [11]
  Jiang, W.; Luo, W.; Wang, J.; Zhang, M.; Zhu, Y. J. Photochem. Photobiol. C 2016, 28, 87. doi: 10.1016/j.jphotochemrev.2016.06.001 doi: 10.1016/j.jphotochemrev.2016.06.001
12. [12]
  Wang, X.; Blechert, S.; Antonietti, M. ACS Catal. 2012, 2 (8), 1596. doi: 10.1021/cs300240x doi: 10.1021/cs300240x
13. [13]
  Zhang, Y.; Thomas, A.; Antonietti, M.; Wang, X. J. Am. Chem. Soc. 2009, 131 (1), 50. doi: 10.1021/ja808329f doi: 10.1021/ja808329f
14. [14]
  Shi, Y.; Jiang, S.; Zhou, K.; Bao, C.; Yu, B.; Qian, X.; Wang, B.; Hong, N.; Wen, P.; Gui, Z.; Hu, Y.; Yuen, R. K. ACS Appl. Mater. Interfaces 2014, 6 (1), 429. doi: 10.1021/am4044932 doi: 10.1021/am4044932
15. [15]
  Jiang, L. L.; Wang, Z. K.; Li, M.; Zhang, C. C.; Ye, Q. Q.; Hu, K. H.; Lu, D. Z.; Fang, P. F.; Liao, L. S. Adv. Funct. Mater. 2018, 28 (7), 1705875. doi: 10.1002/adfm.201705875 doi: 10.1002/adfm.201705875
16. [16]
  Afshari, M.; Dinari, M.; Momeni, M. M. Ultrason. Sonochem. 2018, 42, 631. doi: 10.1016/j.ultsonch.2017.12.023 doi: 10.1016/j.ultsonch.2017.12.023
17. [17]
  Liu, D. G.; Bai, W. Q.; Pan, Y. J.; Tu, J. P. Diamond Relat. Mater. 2015, 55, 102. doi: 10.1016/j.diamond.2015.03.015 doi: 10.1016/j.diamond.2015.03.015
18. [18]
  Liu, D. G.; Tu, J. P.; Hong, C. F.; Gu, C. D.; Mao, S. X. Surf. Coat. Int. 2010, 205 (1), 152. doi: 10.1016/j.surfcoat.2010.06.022 doi: 10.1016/j.surfcoat.2010.06.022
19. [19]
  Dong, Z. B.; Lu, Y. F.; Gao, K.; Shi, L. Q.; Sun, J.; Xu, N.; Wu, J. D. Thin Solid Films 2008, 516 (23), 8594. doi: 10.1016/j.tsf.2008.06.013 doi: 10.1016/j.tsf.2008.06.013
20. [20]
  Ge, L.; Han, C. Appl. Catal. B: Environ. 2012, 117-118, 268. doi: 10.1016/j.apcatb.2012.01.021 doi: 10.1016/j.apcatb.2012.01.021
21. [21]
  Yang, Y. X.; Guo, Y. N.; Liu, F. Y.; Yuan, X.; Guo, Y. H.; Zhang, S. Q.; Guo, W.; Huo, M. X. Appl. Catal. B: Environ. 2013, 142, 828. doi: 10.1016/j.apcatb.2013.06.026 doi: 10.1016/j.apcatb.2013.06.026
22. [22]
  Ye, L.; Chen, S. Appl. Surf. Sci. 2016, 389, 1076. doi: 10.1016/j.apsusc.2016.08.038 doi: 10.1016/j.apsusc.2016.08.038
23. [23]
  Bu, Y.; Chen, Z.; Yu, J.; Li, W. Electrochim. Acta 2013, 88, 294. doi: 10.1016/j.electacta.2012.10.049 doi: 10.1016/j.electacta.2012.10.049
24. [24]
  Shalom, M.; Gimenez, S.; Schipper, F.; Herraiz-Cardona, I.; Bisquert, J.; Antonietti, M. Angew. Chem. Int. Ed. 2014, 53 (14), 3654. doi: 10.1002/anie.201309415 doi: 10.1002/anie.201309415
25. [25]
  Thomas, A.; Fischer, A.; Goettmann, F.; Antonietti, M.; Müller, J. O.; Schlögl, R.; Carlsson, J. M. J. Mater. Chem. 2008, 18 (41), 4893. doi: 10.1039/b800274f doi: 10.1039/b800274f
26. [26]
  Zhang, H.; Li, S.; Lu, R.; Yu, A. ACS Appl. Mater. Interfaces 2015, 7 (39), 21868. doi: 10.1021/acsami.5b06309 doi: 10.1021/acsami.5b06309
27. [27]
  Bian, J.; Li, Q.; Huang, C.; Li, J.; Guo, Y.; Zaw, M.; Zhang, R. Q. Nano Energy 2015, 15, 353. doi: 10.1016/j.nanoen.2015.04.012 doi: 10.1016/j.nanoen.2015.04.012
28. [28]
  Ye, L.; Wang, D.; Chen, S. ACS Appl. Mater. Interfaces 2016, 8 (8), 5280. doi: 10.1021/acsami.5b11326 doi: 10.1021/acsami.5b11326
29. [29]
  Che, W.; Cheng, W.; Yao, T.; Tang, F.; Liu, W.; Su, H.; Huang, Y.; Liu, Q.; Liu, J.; Hu, F.; Pan, Z.; Sun, Z.; Wei, S. J. Am. Chem. Soc. 2017, 139 (8), 3021. doi: 10.1021/jacs.6b11878 doi: 10.1021/jacs.6b11878
30. [30]
  Wu, X. C.; Hong, J. M.; Han, Z. J.; Tao, Y. R. Chem. Phys. Lett. 2003, 373 (1-2), 28. doi: 10.1016/s0009-2614(03)00582-7 doi: 10.1016/s0009-2614(03)00582-7
31. [31]
  Lau, V. W.; Mesch, M. B.; Duppel, V.; Blum, V.; Senker, J.; Lotsch, B. V. J. Am. Chem. Soc. 2015, 137 (3), 1064. doi: 10.1021/ja511802c doi: 10.1021/ja511802c
32. [32]
  Praus, P.; Svoboda, L.; Ritz, M.; Troppová, I.; Šihor, M.; Kočí, K. Mater. Chem. Phys. 2017, 193, 438. doi: 10.1016/j.matchemphys.2017.03.008 doi: 10.1016/j.matchemphys.2017.03.008
33. [33]
  Zhang, J.; Zhang, M.; Zhang, G.; Wang, X. ACS Catal. 2012, 2 (6), 940. doi: 10.1021/cs300167b doi: 10.1021/cs300167b
34. [34]
  Lin, L.; Ou, H.; Zhang, Y.; Wang, X. ACS Catal. 2016, 6 (6), 3921. doi: 10.1021/acscatal.6b00922 doi: 10.1021/acscatal.6b00922
35. [35]
  Cui, Y.; Zhang, J.; Zhang, G.; Huang, J.; Liu, P.; Antonietti, M.; Wang, X. J. Mater. Chem. 2011, 21 (34), 13032. doi: 10.1039/c1jm11961c doi: 10.1039/c1jm11961c
36. [36]
  Jorge, A. B.; Martin, D. J.; Dhanoa, M. T. S.; Rahman, A. S.; Makwana, N.; Tang, J.; Sella, A.; Corà, F.; Firth, S.; Darr, J. A.; McMillan, P. F. J. Phys. Chem. C 2013, 117 (14), 7178. doi: 10.1021/jp4009338 doi: 10.1021/jp4009338
37. [37]
  Deifallah, M.; McMillan, P. F.; Corà, F. J. Phys. Chem. C 2008, 112 (14), 5447. doi: 10.1021/jp711483t doi: 10.1021/jp711483t
38. [38]
  Wang, Y.; Zhao, J.; Li, Y.; Wang, C. Appl. Catal. B 2018, 226, 544. doi: 10.1016/j.apcatb.2018.01.005 doi: 10.1016/j.apcatb.2018.01.005
39. [39]
  Yang, F.; Kuznietsov, V.; Lublow, M.; Merschjann, C.; Steigert, A.; Klaer, J.; Thomas, A.; Schedel-Niedrig, T. J. Mater. Chem. A 2013, 1, 6407. doi: 10.1039/c3ta10360a doi: 10.1039/c3ta10360a
40. [40]
  Peng, G.; Xing, L.; Barrio, J.; Volokh, M.; Shalom, M. Angew. Chem. Int. Ed. 2018, 57 (5), 1186. doi: 10.1002/anie.201711669 doi: 10.1002/anie.201711669
41. [41]
  Ye, C.; Li, J. X.; Li, Z. J.; Li, X. B.; Fan, X. B.; Zhang, L. P.; Chen, B.; Tung, C. H.; Wu, L. Z. ACS Catal. 2015, 5 (11), 6973. doi: 10.1021/acscatal.5b02185 doi: 10.1021/acscatal.5b02185
42. [42]
  Zhang, Y.; Pan, Q.; Chai, G.; Liang, M.; Dong, G.; Zhang, Q.; Qiu, J. Sci. Rep. 2013, 3, 1943. doi: 10.1038/srep01943 doi: 10.1038/srep01943
43. [43]
  Elbanna, O.; Fujitsuka, M.; Majima, T. ACS Appl. Mater. Interfaces 2017, 9 (40), 34844. doi: 10.1021/acsami.7b08548 doi: 10.1021/acsami.7b08548
44. [44]
  Niu, P.; Zhang, L.; Liu, G.; Cheng, H. M. Adv. Funct. Mater. 2012, 22 (22), 4763. doi: 10.1002/adfm.201200922 doi: 10.1002/adfm.201200922
45. [45]
  Niu, P.; Liu, G.; Cheng, H. M. J. Phys. Chem. C 2012, 116 (20), 11013. doi: 10.1021/jp301026y doi: 10.1021/jp301026y
46. [46]
  Zhang, H.; Yu, A. J. Phys. Chem. C 2014, 118 (22), 11628. doi: 10.1021/jp503477x doi: 10.1021/jp503477x
1. [1]
  Jiao CHEN , Yi LI , Yi XIE , Dandan DIAO , Qiang XIAO . Vapor-phase transport of MFI nanosheets for the fabrication of ultrathin b-axis oriented zeolite membranes. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 507-514. doi: 10.11862/CJIC.20230403
2. [2]
  Chun-Lin Sun , Yaole Jiang , Yu Chen , Rongjing Guo , Yongwen Shen , Xinping Hui , Baoxin Zhang , Xiaobo Pan . Construction, Performance Testing, and Practical Applications of a Home-Made Open Fluorescence Spectrometer. University Chemistry, 2024, 39(5): 287-295. doi: 10.3866/PKU.DXHX202311096
3. [3]
  Juan Yuan , Bin Zhang , Jinping Wu , Mengfan Wang . Design of a Comprehensive Experiment on Preparation and Characterization of Cu₂(Salen)₂ Nanomaterials with Two Distinct Morphologies. University Chemistry, 2024, 39(10): 420-425. doi: 10.3866/PKU.DXHX202402014
4. [4]
  Xiaowu Zhang , Pai Liu , Qishen Huang , Shufeng Pang , Zhiming Gao , Yunhong Zhang . Acid-Base Dissociation Equilibrium in Multiphase System: Effect of Gas. University Chemistry, 2024, 39(4): 387-394. doi: 10.3866/PKU.DXHX202310021
5. [5]
  Mengyao Shi , Kangle Su , Qingming Lu , Bin Zhang , Xiaowen Xu . Determination of Potassium Content in Tobacco Stem Ash by Flame Atomic Absorption Spectroscopy. University Chemistry, 2024, 39(10): 255-260. doi: 10.12461/PKU.DXHX202404105
6. [6]
  Jizhou Liu , Chenbin Ai , Chenrui Hu , Bei Cheng , Jianjun Zhang . 六氯锡酸铵促进钙钛矿太阳能电池界面电子转移及其飞秒瞬态吸收光谱研究. Acta Physico-Chimica Sinica, 2024, 40(11): 2402006-. doi: 10.3866/PKU.WHXB202402006
7. [7]
  Yongqing Kuang , Jie Liu , Jianjun Feng , Wen Yang , Shuanglian Cai , Ling Shi . Experimental Design for the Two-Step Synthesis of Paracetamol from 4-Hydroxyacetophenone. University Chemistry, 2024, 39(8): 331-337. doi: 10.12461/PKU.DXHX202403012
8. [8]
  Qin ZHU , Jiao MA , Zhihui QIAN , Yuxu LUO , Yujiao GUO , Mingwu XIANG , Xiaofang LIU , Ping NING , Junming GUO . Morphological evolution and electrochemical properties of cathode material LiAl_0.08Mn_1.92O₄ single crystal particles. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1549-1562. doi: 10.11862/CJIC.20240022
9. [9]
  Ke Li , Chuang Liu , Jingping Li , Guohong Wang , Kai Wang . 钛酸铋/氮化碳无机有机复合S型异质结纯水光催化产过氧化氢. Acta Physico-Chimica Sinica, 2024, 40(11): 2403009-. doi: 10.3866/PKU.WHXB202403009
10. [10]
  Lijun Dong , Pengcheng Du , Guangnong Lu , Wei Wang . Exploration and Practice of Independent Design Experiments in Inorganic and Analytical Chemistry: A Case Study of “Preparation and Composition Analysis of Tetraammine Copper(II) Sulfate”. University Chemistry, 2024, 39(4): 361-366. doi: 10.3866/PKU.DXHX202310041
11. [11]
  Zunxiang Zeng , Yuling Hu , Yufei Hu , Hua Xiao . Analysis of Plant Essential Oils by Supercritical CO₂Extraction with Gas Chromatography-Mass Spectrometry: An Instrumental Analysis Comprehensive Experiment Teaching Reform. University Chemistry, 2024, 39(3): 274-282. doi: 10.3866/PKU.DXHX202309069
12. [12]
  Jingzhao Cheng , Shiyu Gao , Bei Cheng , Kai Yang , Wang Wang , Shaowen Cao . 4-氨基-1H-咪唑-5-甲腈修饰供体-受体型氮化碳光催化剂的构建及其高效光催化产氢研究. Acta Physico-Chimica Sinica, 2024, 40(11): 2406026-. doi: 10.3866/PKU.WHXB202406026
13. [13]
  Heng Chen , Longhui Nie , Kai Xu , Yiqiong Yang , Caihong Fang . 两步焙烧法制备大比表面积和结晶性增强超薄g-C₃N₄纳米片及其高效光催化产H₂O₂. Acta Physico-Chimica Sinica, 2024, 40(11): 2406019-. doi: 10.3866/PKU.WHXB202406019
14. [14]
  Gaoyan Chen , Chaoyue Wang , Juanjuan Gao , Junke Wang , Yingxiao Zong , Kin Shing Chan . Heart to Heart: Exploring Cardiac CT. University Chemistry, 2024, 39(9): 146-150. doi: 10.12461/PKU.DXHX202402011
15. [15]
  Min LI , Xianfeng MENG . Preparation and microwave absorption properties of ZIF-67 derived Co@C/MoS₂ nanocomposites. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1932-1942. doi: 10.11862/CJIC.20240065
16. [16]
  Bingliang Li , Yuying Han , Dianyang Li , Dandan Liu , Wenbin Shang . One-Step Synthesis of Benorilate Guided by Green Chemistry Principles and in vivo Dynamic Evaluation. University Chemistry, 2024, 39(6): 342-349. doi: 10.3866/PKU.DXHX202311070
17. [17]
  Ruiqing LIU , Wenxiu LIU , Kun XIE , Yiran LIU , Hui CHENG , Xiaoyu WANG , Chenxu TIAN , Xiujing LIN , Xiaomiao FENG . Three-dimensional porous titanium nitride as a highly efficient sulfur host. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 867-876. doi: 10.11862/CJIC.20230441
18. [18]
  Yan ZHAO , Xiaokang JIANG , Zhonghui LI , Jiaxu WANG , Hengwei ZHOU , Hai GUO . Preparation and fluorescence properties of Eu³⁺-doped CaLaGaO₄ red-emitting phosphors. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1861-1868. doi: 10.11862/CJIC.20240242
19. [19]
  Yanhui Zhong , Ran Wang , Zian Lin . Analysis of Halogenated Quinone Compounds in Environmental Water by Dispersive Solid-Phase Extraction with Liquid Chromatography-Triple Quadrupole Mass Spectrometry. University Chemistry, 2024, 39(11): 296-303. doi: 10.12461/PKU.DXHX202402017
20. [20]
  Xinyuan Shi , Chenyangjiang , Changyu Zhai , Xuemei Lu , Jia Li , Zhu Mao . Preparation and Photoelectric Performance Characterization of Perovskite CsPbBr₃ Thin Films. University Chemistry, 2024, 39(6): 383-389. doi: 10.3866/PKU.DXHX202312019

Get Citation

PDF

XML

Metrics

PDF Downloads(13)
Abstract views(452)
HTML views(111)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142