Citation: LI Xiang-Hong, DENG Shu-Duan, XIE Xiao-Guang, DU Guan-Ben. Inhibition Effect of Bamboo Leaf Extract on the Corrosion of Aluminum in HCl Solution[J]. Acta Physico-Chimica Sinica, ;2014, 30(10): 1883-1894. doi: 10.3866/PKU.WHXB201407161 shu

Inhibition Effect of Bamboo Leaf Extract on the Corrosion of Aluminum in HCl Solution

1.
1. Faculty of Science, Southwest Forestry University, Kunming 650224, P. R. China;
2. Yunnan Key Laboratory of Wood Adhesives and Glue Products, Southwest Forestry University, Kunming 650224, P. R. China;
3. School of Chemical Science and Technology, Yunnan University, Kunming 650091, P. R. China

Received Date: 28 April 2014
Available Online: 16 July 2014
Fund Project:

A bamboo leaf inhibitor (designated PSLE) was extracted from Phyllostachys sulphurea (Corr. Riviere) leaves using a series of C₂H₅OH-water solutions (20%-80% (volume fraction)). The solutions were characterized by Fourier transform infrared (FTIR) spectroscopy and ultraviolet- visible (UV-Vis) spectrophotometry. The total flavonoid content of the PSLE was determined. The inhibition effect of PSLE toward the corrosion of aluminum in HCl solution was studied by weight loss, potentiodynamic polarization, electrochemical impedance spectroscopy (EIS), and scanning electron microscopy (SEM). Density functional theory (DFT) quantum chemical calculations including solvent effects were used to investigate the adsorption of light by the two major components vientin and isovientin. The results show that PSLE is a od inhibitor and the adsorption of PSLE on the aluminum surface obeys the Langmuir adsorption isotherm. The inhibition efficiency increases with PSLE concentration while it decreases with temperature and HCl concentration. A od correlation exists between the total flavonoid content and the inhibition performance. This implies that the flavonoids are the major contributor to inhibition activity. PSLE behaves as a cathodic inhibitor. The EIS spectra are characterized by one large capacitive loop at high frequencies followed by a large inductive loop at low frequency values. The impedance value increases with increasing inhibitor concentration. SEM results confirm that the corrosion of aluminum is retarded remarkably by PSLE. The quantum calculation results indicate that the adsorption center of either vientin or isovientin is mainly a flavonoid backbone structure (FBS).
- Aluminium,
- Hydrochloric acid,
- Bamboo leaf extract,
- Corrosion inhibition,
- Adsorption,
- Quantum chemical calculation
1. [1]
  
  (1) Chaieb, E.; Bouyanzer, A.; Hammouti, B.; Berrabah, M. Acta Phys. -Chim. Sin. 2009, 25, 1254. [Chaieb, E.; Bouyanzer, A.; Hammouti, B.; Berrabah, M. 物理化学学报, 2009, 25, 1254.] doi: 10.3866/PKU.WHXB20090709
2. [2]
  (2) Raja, P. B.; Rahim, A. A.; Osman, H.; Awang, K. Acta Phys. -Chim. Sin. 2010, 26, 2171. [Raja, Pandian Bothi; Rahim, Afidah Abdul; Osman, Hasnah; Awang, Khalijah. 物理化学学报, 2010, 26, 2171.] doi: 10.3866/PKU.WHXB20100646
3. [3]
  (3) El Hosary, A. A.; Saleh R. M.; Shams El Din, A. M. Corrossion Sci. 1972, 12, 897. doi: 10.1016/S0010-938X(72)80098-2
4. [4]
  (4) Avwiri, G. O.; Lgho, F. O. Mater. Lett. 2003, 57, 3705. doi: 10.1016/S0167-577X(03)00167-8
5. [5]
  (5) Oguzie, E. E.; Onuchukwu, A. I.; Okafor, P. C.; Ebenso, E. E. Pig. Resin. Technol. 2006, 35 (2), 63. doi: 10.1108/03699420610652340
6. [6]
  (6) El-Etre, A. Y. Corrosion Sci. 2003, 45, 2485. doi: 10.1016/S0010-938X(03)00066-0
7. [7]
  (7) Oguzie, E. E. Corrosion Sci. 2007, 49, 1527. doi: 10.1016/j.corsci.2006.08.009
8. [8]
  (8) Umoren, S. A.; Obot, I. B.; Ebenso, E. E.; Obi-Egbedi, N. O. Desalination 2009, 247, 561. doi: 10.1016/j.desal.2008.09.005
9. [9]
  (9) Deng, S. D.; Li, X. H. Corrosion Sci. 2012, 64, 253. doi: 10.1016/j.corsci.2012.07.017
10. [10]
  (10) Lu, B. Y.;Wu, X. Q.; Tie, X.W.; Zhang, Y.; Zhang, Y. Food Chem. Toxicol. 2005, 43, 783. doi: 10.1016/j.fct.2005.01.019
11. [11]
  (11) Lu, B. Y.;Wu, X. Q.; Shi, J. Y.; Dong, Y. J.; Zhang, Y. Food Chem. Toxicol. 2006, 44, 1739. doi: 10.1016/j.fct.2006.05.012
12. [12]
  (12) Li, X. H.; Deng, S. D.; Fu, H. Corrosion Sci. 2012, 62, 163. doi: 10.1016/j.corsci.2012.05.008
13. [13]
  (13) Deng, S. D.; Li, X. H.; Fu, H. Chem. Indust. Forest Prod. 2010, 30, 81. [邓书端, 李向红, 付惠. 林产化学与工业, 2010, 30, 81.] (14) Li, X. H.; Deng, S. D. Corrosion Sci. 2012, 65, 299. doi: 10.1016/j.corsci.2012.08.033
14. [14]
  (15) Li, X. H.; Deng, S. D.; Fu, H. Acta Phys. -Chim. Sin. 2011, 27, 2841. [李向红, 邓书端, 付惠. 物理化学学报, 2011, 27, 2841.] doi: 10.3866/PKU.WHXB20112841
15. [15]
  (16) Materials Studio 7.0. Accelrys Inc.: San Die , CA, 2013. (17) Becke, A. D. J. Chem. Phys. 1988, 88, 2547. doi: 10.1063/1.454033
16. [16]
  (18) Lee, C.; Yang,W.; Parr, R. G. Phys. Rev. B 1988, 37, 785. doi: 10.1103/PhysRevB.37.785
17. [17]
  (19) Klamt, A.; Schüürmann, G. J. Chem. Soc. Perkin Trans. 1993, 2, 799. (20) Jing,W. J. Information Develop Economy 2009, 19, 139. (21) Su, C. H.;Wang, F. S.; Ding, Y. L. China Forestry Sci. Tech. 2010, 24, 87. (22) Deng, Q. Y.; Liu, L.; Deng, H. M. Principles of Spectrometric Identification, 2nd ed.; Science Press: Beijing, 2007; p 37. (23) Kuang, H. X. Traditional Chinese Medicine Chemistry; Traditional Chinese Medicine Press: Beijing, 2003; p 155. (24) Fuchs- dec, R.; Dole?ek,V. Colloids Surf. A 2004, 244, 73. doi: 10.1016/j.colsurfa.2004.05.015
18. [18]
  (25) Cano, E.; Polo, J. L.; La Iglesia, A.; Bastidas, J. M. Adsorption 2004, 10, 219. doi: 10.1023/B:ADSO.0000046358.35572.4c
19. [19]
  (26) Zhao, J. M.; Li, J. Acta Phys. -Chim. Sin. 2012, 28, 623. [赵景茂, 李俊. 物理化学学报, 2012, 28, 623.] doi: 10.3866/PKU.WHXB201112293
20. [20]
  (27) Oguzie, E. E.; Unaegbu, C.; Ogukwea, C. N.; Okolue, B. N.; Onuchuku, A. I. Mater. Chem. Phys. 2004, 84, 363. doi: 10.1016/j.matchemphys.2003.11.027
21. [21]
  (28) Deng, S. D.; Li, X. H.; Xie, X. G. Corrosion Sci. 2014, 80, 276. doi: 10.1016/j.corsci.2013.11.041
22. [22]
  (29) Zhang, Q. B.; Hua, Y. X. Mater. Chem. Phys. 2010, 119, 57. doi: 10.1016/j.matchemphys.2009.07.035
23. [23]
  (30) Martinez, S.; Stern, I. Appl. Surf. Sci. 2002, 199, 83. doi: 10.1016/S0169-4332(02)00546-9
24. [24]
  (31) Behpour, M.; Ghoreishi, S. M.; Soltani, N.; Salavati-Niasari, M. T. Corrosion Sci. 2009, 51, 1073. doi: 10.1016/j.corsci.2009.02.011
25. [25]
  (32) Cai, Q. H.; Shan, Y. K.; Lu, B.; Yuan, X. H. Corrosion 1993, 49, 486. doi: 10.5006/1.3316077
26. [26]
  (33) de Assunção Araújo Pereira, S. S.; Pêgas, M. M.; Fernández, T. L.; Magalhães, M.; Schöntag, T. G.; La , D. C.; de Senna, L. F.; D'Elia, E. Corrosion Sci. 2012, 65, 360. doi: 10.1016/j.corsci.2012.08.038
27. [27]
  (34) Obot, I. B.; Obi-Egbedi, N. O. Corrosion Sci. 2010, 52, 282. doi: 10.1016/j.corsci.2009.09.013
28. [28]
  (35) Shukla, S. K.; Quraishi, M. A. Corrosion Sci. 2010, 52, 314. doi: 10.1016/j.corsci.2009.09.017
29. [29]
  (36) Talati, J. D.; Gandhi, D. K. Corrosion Sci. 1983, 23, 1315. doi: 10.1016/0010-938X(83)90081-1
30. [30]
  (37) Yurt, A.; Ulutas, S.; Dal, H. Appl. Surf. Sci. 2006, 253, 919. doi: 10.1016/j.apsusc.2006.01.026
31. [31]
  (38) Li, X. H.; Deng, S. D.; Fu, H. Corrosion Sci. 2011, 53, 1529. (39) Cao, C. N. Corrosion Electrochemistry Mechanism, 3rd ed.; Chemical Industrial Engineering Press: Beijing, 2008; p 197. (40) Oguzie, E. E.; Okolue, B. N.; Ebenso, E. E.; Onuoha, G. N.; Onuchukwu, A. I. Mater. Chem. Phys. 2004, 87, 394. doi: 10.1016/j.matchemphys.2004.06.003
32. [32]
  (41) Khaled, K. F.; Al-Qahtani, M. M. Mater. Chem. Phys. 2009, 113, 150. doi: 10.1016/j.matchemphys.2008.07.060
33. [33]
  (42) Li, X. H.; Deng, S. D.; Xie, X. G. Corrosion Sci. 2014, 81, 162. doi: 10.1016/j.corsci.2013.12.021
34. [34]
  (43) Garrigues, L.; Pebere, N.; Dabosi, F. Electrochim. Acta 1996, 41, 1209. doi: 10.1016/0013-4686(95)00472-6
35. [35]
  (44) Noor, E. A. Mater. Chem. Phys. 2009, 114, 533. doi: 10.1016/j.matchemphys.2008.09.065
36. [36]
  (45) Bessone, J.; Mayer, C.; Jutter, K.; Lorenz,W. Electrochim. Acta 1983, 28, 171. doi: 10.1016/0013-4686(83)85105-6
37. [37]
  (46) Brett, C. M. A. Corrosion Sci. 1992, 33, 203. doi: 10.1016/0010-938X(92)90145-S
38. [38]
  (47) Burstein, G. T.; Cinderey, R. J. Corrosion Sci. 1992, 32, 1195. (48) Metlkoš -Hukovi?, M.; Babi?, R.; Grubac, Z. J. Appl. Electrochem. 1998, 28, 433. doi: 10.1023/A:1003200808093
39. [39]
  (49) Lebrini, M.; Lagrenée, M.; Vezin, H.; Traisnel, M.; Bentiss, F. Corrosion Sci. 2007, 49, 2254. doi: 10.1016/j.corsci.2006.10.029
40. [40]
  (50) Amin, M. A.; Mohsen, Q.; Hazzai, O. A. Mater. Chem. Phys. 2009, 114, 908. doi: 10.1016/j.matchemphys.2008.10.057
41. [41]
  (51) Lenderink, H. J.W.; Linden, M. V. D.; DeWit, J. H.W. Electrochim. Acta 1993, 38, 1989. doi: 10.1016/0013-4686(93)80329-X
42. [42]
  (52) Kilner, C. A.; Halcrow, M. A. Polyhedron 2006, 25, 235. doi: 10.1016/j.poly.2005.06.034
43. [43]
  (53) Beaufort, L.; Benvenuti, F.; Noels, A. F. I. J. Mol. Catal. AChem. 2006, 260, 210. doi: 10.1016/j.molcata.2006.07.005
44. [44]
  (54) Abd El Rehim, S. S.; Hassan, H. H.; Amin, M. A. Mater. Chem. Phys. 2001, 70, 64. doi: 10.1016/S0254-0584(00)00468-5
45. [45]
  (55) Osório,W. R.; Moutinho, D. J.; Peixoto, L. C.; Ferreira, I. L.; Garcia, A. Electrochim. Acta 2011, 56, 8412. doi: 10.1016/j.electacta.2011.07.028
46. [46]
  (56) Lagrenée, M.; Mernari, B.; Bouanis, M.; Traisnel, M.; Bentiss, F. Corrosion Sci. 2002, 44, 573. doi: 10.1016/S0010-938X(01)00075-0
47. [47]
  (57) Lorenz,W. J.; Mansfeld, F. Corrosion Sci. 1981, 21, 647. doi: 10.1016/0010-938X(81)90015-9
48. [48]
  (58) Tang, H. G.; Zheng,W. D.; Chen, Z. D. Chin. Agri. Sci. Bull. 2005, 21, 114. (59) Li, H. Y.; Sun, J. Y.; Zhang, J. M.; Shou, D. Chin. Traditional Patent Medi. 2004, 26, 208. (60) Li, X. H.; Deng, S. D.; Fu, H.; Xie, X. G. Corrosion Sci. 2014, 78, 29. doi: 10.1016/j.corsci.2013.08.025
49. [49]
  (61) Gao, Z. Q.; Xu, Q.; Song, Z. R.;Wang, L. Chem. World 2008, 49, 439. (62) Fukui, K. Angewandte Chemie International Edition in English 1982, 21, 801. (63) Li, X. H.; Xie, X. G. Acta Phys. -Chim. Sin. 2013, 29, 2221. [李向红, 谢小光. 物理化学学报, 2013, 29, 2221.] doi: 10.3866/PKU.WHXB201307301
1. [1]
  Zeyu XU , Anlei DANG , Bihua DENG , Xiaoxin ZUO , Yu LU , Ping YANG , Wenzhu YIN . Evaluation of the efficacy of graphene oxide quantum dots as an ovalbumin delivery platform and adjuvant for immune enhancement. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1065-1078. doi: 10.11862/CJIC.20240099
2. [2]
  Guang Huang , Lei Li , Dingyi Zhang , Xingze Wang , Yugai Huang , Wenhui Liang , Zhifen Guo , Wenmei Jiao . Cobalt’s Valor, Nickel’s Foe: A Comprehensive Chemical Experiment Utilizing a Cobalt-based Imidazolate Framework for Nickel Ion Removal. University Chemistry, 2024, 39(8): 174-183. doi: 10.3866/PKU.DXHX202311051
3. [3]
  Wei Li , Jinfan Xu , Yongjun Zhang , Ying Guan . 共价有机框架整体材料的制备及食品安全非靶向筛查应用——推荐一个仪器分析综合化学实验. University Chemistry, 2025, 40(6): 276-285. doi: 10.12461/PKU.DXHX202406013
4. [4]
  Jingke LIU , Jia CHEN , Yingchao HAN . Nano hydroxyapatite stable suspension system: Preparation and cobalt adsorption performance. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1763-1774. doi: 10.11862/CJIC.20240060
5. [5]
  Hui Wang , Abdelkader Labidi , Menghan Ren , Feroz Shaik , Chuanyi Wang . 微观结构调控的g-C₃N₄在光催化NO转化中的最新进展：吸附/活化位点的关键作用. Acta Physico-Chimica Sinica, 2025, 41(5): 100039-. doi: 10.1016/j.actphy.2024.100039
6. [6]
  Huiying Xu , Minghui Liang , Zhi Zhou , Hui Gao , Wei Yi . Application of Quantum Chemistry Computation and Visual Analysis in Teaching of Weak Interactions. University Chemistry, 2025, 40(3): 199-205. doi: 10.12461/PKU.DXHX202407011
7. [7]
  Xueli Mu , Lingli Han , Tao Liu . Quantum Chemical Calculation Study on the E2 Elimination Reaction of Halohydrocarbon: Designing a Computational Chemistry Experiment. University Chemistry, 2025, 40(3): 68-75. doi: 10.12461/PKU.DXHX202404057
8. [8]
  Peng XU , Shasha WANG , Nannan CHEN , Ao WANG , Dongmei YU . Preparation of three-layer magnetic composite Fe₃O₄@polyacrylic acid@ZiF-8 for efficient removal of malachite green in water. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 544-554. doi: 10.11862/CJIC.20230239
9. [9]
  Jing Wang , Pingping Li , Yuehui Wang , Yifan Xiu , Bingqian Zhang , Shuwen Wang , Hongtao Gao . Treatment and Discharge Evaluation of Phosphorus-Containing Wastewater. University Chemistry, 2024, 39(5): 52-62. doi: 10.3866/PKU.DXHX202309097
10. [10]
  Fugui XI , Du LI , Zhourui YAN , Hui WANG , Junyu XIANG , Zhiyun DONG . Functionalized zirconium metal-organic frameworks for the removal of tetracycline from water. Chinese Journal of Inorganic Chemistry, 2025, 41(4): 683-694. doi: 10.11862/CJIC.20240291
11. [11]
  Ping ZHANG , Chenchen ZHAO , Xiaoyun CUI , Bing XIE , Yihan LIU , Haiyu LIN , Jiale ZHANG , Yu'nan CHEN . Preparation and adsorption-photocatalytic performance of ZnAl@layered double oxides. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1965-1974. doi: 10.11862/CJIC.20240014
12. [12]
  Aili Feng , Xin Lu , Peng Liu , Dongju Zhang . Computational Chemistry Study of Acid-Catalyzed Esterification Reactions between Carboxylic Acids and Alcohols. University Chemistry, 2025, 40(3): 92-99. doi: 10.12461/PKU.DXHX202405072
13. [13]
  Supin Zhao , Jing Xie . Understanding the Vibrational Stark Effect of Water Molecules Using Quantum Chemistry Calculations. University Chemistry, 2025, 40(3): 178-185. doi: 10.12461/PKU.DXHX202406024
14. [14]
  Yanan Jiang , Yuchen Ma . Brief Discussion on the Electronic Exchange Interaction in Quantum Chemistry Computations. University Chemistry, 2025, 40(3): 10-15. doi: 10.12461/PKU.DXHX202402058
15. [15]
  Yaqin Zheng , Lian Zhuo , Meng Li , Chunying Rong . Enhancing Understanding of the Electronic Effect of Substituents on Benzene Rings Using Quantum Chemistry Calculations. University Chemistry, 2025, 40(3): 193-198. doi: 10.12461/PKU.DXHX202406119
16. [16]
  Jiabo Huang , Quanxin Li , Zhongyan Cao , Li Dang , Shaofei Ni . Elucidating the Mechanism of Beckmann Rearrangement Reaction Using Quantum Chemical Calculations. University Chemistry, 2025, 40(3): 153-159. doi: 10.12461/PKU.DXHX202405172
17. [17]
  Anqiu LIU , Long LIN , Dezhi ZHANG , Junyu LEI , Kefeng WANG , Wei ZHANG , Junpeng ZHUANG , Haijun HAO . Synthesis, structures, and catalytic activity of aluminum and zinc complexes chelated by 2-((2,6-dimethylphenyl)amino)ethanolate. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 791-798. doi: 10.11862/CJIC.20230424
18. [18]
  Wenkai Chen , Yunjia Shen , Xiangmeng Kong , Yanli Zeng . Quantum Chemistry Calculation of Key Physical Quantity in Circularly Polarized Luminescence: Introducing an Exploratory Computational Chemistry Experiment. University Chemistry, 2025, 40(3): 83-91. doi: 10.12461/PKU.DXHX202405018
19. [19]
  Jia Zhou . Constructing Potential Energy Surface of Water Molecule by Quantum Chemistry and Machine Learning: Introduction to a Comprehensive Computational Chemistry Experiment. University Chemistry, 2024, 39(3): 351-358. doi: 10.3866/PKU.DXHX202309060
20. [20]
  Xiumei LI , Yanju HUANG , Bo LIU , Yaru PAN . Syntheses, crystal structures, and quantum chemistry calculation of two Ni(Ⅱ) coordination polymers. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 2031-2039. doi: 10.11862/CJIC.20240109

Get Citation

PDF

XML

Metrics

PDF Downloads(414)
Abstract views(767)
HTML views(15)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142