Citation: LIU Dan-Dan, XIE Yong-Min, LIU Jiang, WANG Jin-Xia. Preparation of NiO-YSZ-Graphite Aqueous Slurry and Its Application in Fabricating Solid Oxide Fuel Cells by Slip-Casting[J]. Acta Physico-Chimica Sinica, ;2014, 30(2): 331-337. doi: 10.3866/PKU.WHXB201312241 shu

Preparation of NiO-YSZ-Graphite Aqueous Slurry and Its Application in Fabricating Solid Oxide Fuel Cells by Slip-Casting

1.
1 The Key Laboratory of Fuel Cell Technology of Guangdong Province, School of Chemistry and Chemical Engineering, South China University of Technology, Guangzhou 510640, P. R. China;
2 New Energy Research Institute, College of Environment and Energy, South China University of Technology, Guangzhou 510006, P. R. China;
3 Department of Electronics & Information Engineering, Ningbo University of Technology, Ningbo 315016, Zhejiang Province, P. R. China

Received Date: 22 October 2013
Available Online: 24 December 2013
Fund Project: 国家自然科学基金(21276097) (21276097)浙江省自然科学基金(Y1090035)资助项目 (Y1090035)

Cermet of Ni-YSZ (yttrium-stabilized zirconia) is commonly used as the anode material of solid oxide fuel cells (SOFCs) and the properties of the NiO-YSZ slurry has a significant effect on the performance of SOFCs prepared by wet processes. The stability of the NiO-YSZ slurry was investigated through zeta potential analysis. The effects of six dispersants on the surface zeta potentials of NiO and YSZ were examined. It was found that the zeta potential of NiO was opposite to that of YSZ when the anionic or amphoteric dispersant existed. When the cationic dispersant poly(diallyldimethylammonium chloride) (PDAC) was used, the zeta potentials for both NiO and YSZ were positive and they could be simultaneously suspended in water. By adding graphite, which is used as the pore former when fabricating the SOFC anode, into the NiO-YSZ suspension and using polyvinylpyrrolidone (PVP) as the dispersant of graphite, a stable NiO-YSZgraphite aqueous slurry was successfully prepared. The slurry was used to fabricate anode supports for SOFCs with the slip-casting technique. A typical single anode-supported SOFC showed a maximum power density of 509 mW·cm^-2 at 800℃. The microstructure of the SOFC with the anode support was examined by scanning electron microscope (SEM) analysis and it was found that the electrolyte and anode bonded well and the pores were homogenously distributed in the anode.
- Solid oxide fuel cell,
- Slip-casting,
- Anode support,
- Suspension,
- Zeta potential,
- Dispersant
1. [1]
  
  (1) Minh, N. Q.; Singhal, C.;Williams, M. ECS Transactions 2009,17 (1), 211.
2. [2]
  (2) Tang, Y. B.; Liu, J. Acta Physico-Chimica Sinica 2010, 26 (5),1191. [唐玉宝, 刘江. 物理化学学报, 2010, 26 (5), 1191.]doi: 10.3866/PKU.WHXB20100502
3. [3]
  (3) Liu, M.; Dong, D.; Peng, R.; Gao, J.; Diwu, J.; Liu, X.; Meng,G. Journal of Power Sources 2008, 180 (1), 215. doi: 10.1016/j.jpowsour.2008.01.066
4. [4]
  (4) Koide, H.; Someya, Y.; Yoshida, T.; Maruyama, T. Solid State Ionics 2000, 132 (3-4), 253.
5. [5]
  (5) Dong, J.; Cheng, Z.; Zha, S.; Liu, M. Journal of Power Sources2006, 156 (2), 461. doi: 10.1016/j.jpowsour.2005.06.016
6. [6]
  (6) He, T.; Lu, Z.; Huang, Y.; Guan, P.; Liu, J.; Su,W. Journal of Alloys and Compounds 2002, 337 (1-2), 231.
7. [7]
  (7) Ding, J.; Liu, J.; Yuan,W.; Zhang, Y. Journal of the European Ceramic Society 2008, 28 (16), 3113. doi: 10.1016/j.jeurceramsoc.2008.05.033
8. [8]
  (8) Zhang, L.; He, H. Q.; Kwek,W. R.; Ma, J.; Tang, E. H.; Jiang,S. P. Journal of the American Ceramic Society 2009, 92 (2), 302.doi: 10.1111/jace.2009.92.issue-2
9. [9]
  (9) Ramanathan, S.; Krishnakumar, K. P.; De, P. K.; Banerjee, S.Journal of Materials Science 2004, 39 (10), 3339. doi: 10.1023/B:JMSC.0000026934.88520.67
10. [10]
  (10) Zhang, Y.; Liu, J.; Yin, J.; Yuan,W.; Sui, J. International Journal of Applied Ceramic Technology 2008, 5 (6), 568. doi: 10.1111/ijac.2008.5.issue-6
11. [11]
  (11) Ding, J.; Liu, J. Journal of Power Sources 2009, 193 (2), 769.doi: 10.1016/j.jpowsour.2009.04.049
12. [12]
  (12) Zürcher, S.; Graule, T. Journal of the European Ceramic Society2005, 25 (6), 863. doi: 10.1016/j.jeurceramsoc.2004.05.002
13. [13]
  (13) Lewis, J. A. Journal of the American Ceramic Society 2000, 83 (10), 2341.
14. [14]
  (14) Arevalo-Quintero, O.;Waldbillig, D.; Kesler, O. Surface and Coatings Technology 2011, 205 (21-22), 5218.
15. [15]
  (15) Zhang, L.; Jiang, S. P.;Wang,W.; Zhang, Y. Journal of Power Sources 2007, 170 (1), 55. doi: 10.1016/j.jpowsour.2007.03.080
16. [16]
  (16) Fonseca, C. G.; Basaglia, R. M. F.; Brant, M. C.; Matencio, T.;Domingues, R. Z. Powder Technology 2009, 192 (3), 352. doi: 10.1016/j.powtec.2009.01.022
17. [17]
  (17) Ramanathan, S.; Kakade, M. B. International Journal of Hydrogen Energy 2011, 36 (22), 14956. doi: 10.1016/j.ijhydene.2011.06.112
18. [18]
  (18) Ding, J.; Liu, J. Solid State Ionics 2008, 179 (21-26), 1246.
19. [19]
  (19) Zhu, H.; Zhang, C.; Tang, Y.;Wang, J.; Ren, B.; Yin, Y. Carbon2007, 45, 203. doi: 10.1016/j.carbon.2006.10.007
20. [20]
  (20) Moon, H.; Kim, S. D.; Park, E.W.; Hyun, S. H.; Kim, H. S.International Journal of Hydrogen Energy 2008, 33 (11),2826. doi: 10.1016/j.ijhydene.2008.03.024
21. [21]
  (21) Bai, Y.; Liu, J.; Gao, H.; Jin, C. Journal of Alloys and Compounds 2009, 480 (2), 554. doi: 10.1016/j.jallcom.2009.01.089
22. [22]
  (22) Jin, C.; Liu, J.; Li, L.; Bai, Y. Journal of Membrane Science2009, 341 (1-2), 233.
23. [23]
  (23) Bai, Y.; Liu, J.;Wang, C. International Journal of Hydrogen Energy 2009, 34 (17), 7311. doi: 10.1016/j.ijhydene.2009.07.004
24. [24]
  (24) Greenwood, R. Advances in Colloid and Interface Science 2003,106 (1-3), 55.
25. [25]
  (25) Fu, Y. P.; Chen, S. H. Ceramics International 2009, 35 (2), 821.doi: 10.1016/j.ceramint.2008.02.018
26. [26]
  (26) Greenwood, R.; Kendall, K. Journal of the European Ceramic Society 2000, 20 (1), 77. doi: 10.1016/S0955-2219(99)00091-6
27. [27]
  (27) Zhang, Y.; Gao, J.; Peng, D.; Guangyao, M.; Liu, X. Ceramics International 2004, 30 (6), 1049. doi: 10.1016/j.ceramint.2003.10.026
28. [28]
  (28) Wang, Y. H.; Liu, X. Q.; Meng, G. Y. Ceramics International2007, 33 (6), 1025. doi: 10.1016/j.ceramint.2006.03.011
29. [29]
  (29) Richardson, J.; Orte , J., Jr.; Coute, N.; Twigg, M. Catal Lett.1996, 41 (1-2), 17. doi: 10.1007/BF00811706
1. [1]
  Qianwen Han , Tenglong Zhu , Qiuqiu Lü , Mahong Yu , Qin Zhong . 氢电极支撑可逆固体氧化物电池性能及电化学不对称性优化. Acta Physico-Chimica Sinica, 2025, 41(1): 2309037-. doi: 10.3866/PKU.WHXB202309037
2. [2]
  Ru SONG , Biao WANG , Chunling LU , Bingbing NIU , Dongchao QIU . Electrochemical properties of stable and highly active PrBa_0.5Sr_0.5Fe_1.6Ni_0.4O_5+δ cathode material. Chinese Journal of Inorganic Chemistry, 2025, 41(4): 639-649. doi: 10.11862/CJIC.20240397
3. [3]
  Bowen Yang , Rui Wang , Benjian Xin , Lili Liu , Zhiqiang Niu . C-SnO₂/MWCNTs Composite with Stable Conductive Network for Lithium-based Semi-Solid Flow Batteries. Acta Physico-Chimica Sinica, 2025, 41(2): 100015-. doi: 10.3866/PKU.WHXB202310024
4. [4]
  Aoyu Huang , Jun Xu , Yu Huang , Gui Chu , Mao Wang , Lili Wang , Yongqi Sun , Zhen Jiang , Xiaobo Zhu . Tailoring Electrode-Electrolyte Interfaces via a Simple Slurry Additive for Stable High-Voltage Lithium-Ion Batteries. Acta Physico-Chimica Sinica, 2025, 41(4): 100037-. doi: 10.3866/PKU.WHXB202408007
5. [5]
  Tong Zhou , Jun Li , Zitian Wen , Yitian Chen , Hailing Li , Zhonghong Gao , Wenyun Wang , Fang Liu , Qing Feng , Zhen Li , Jinyi Yang , Min Liu , Wei Qi . Experiment Improvement of “Redox Reaction and Electrode Potential” Based on the New Medical Concept. University Chemistry, 2024, 39(8): 276-281. doi: 10.3866/PKU.DXHX202401005
6. [6]
  Xiaotian ZHU , Fangding HUANG , Wenchang ZHU , Jianqing ZHAO . Layered oxide cathode for sodium-ion batteries: Surface and interface modification and suppressed gas generation effect. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 254-266. doi: 10.11862/CJIC.20240260
7. [7]
  Fengqiao Bi , Jun Wang , Dongmei Yang . Specialized Experimental Design for Chemistry Majors in the Context of “Dual Carbon”: Taking the Assembly and Performance Evaluation of Zinc-Air Fuel Batteries as an Example. University Chemistry, 2024, 39(4): 198-205. doi: 10.3866/PKU.DXHX202311069
8. [8]
  Jiahong ZHENG , Jingyun YANG . Preparation and electrochemical properties of hollow dodecahedral CoNi₂S₄ supported by MnO₂ nanowires. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1881-1891. doi: 10.11862/CJIC.20240170
9. [9]
  Junli Liu . Practice and Exploration of Research-Oriented Classroom Teaching in the Integration of Science and Education: a Case Study on the Synthesis of Sub-Nanometer Metal Oxide Materials and Their Application in Battery Energy Storage. University Chemistry, 2024, 39(10): 249-254. doi: 10.12461/PKU.DXHX202404023
10. [10]
  Mingyang Men , Jinghua Wu , Gaozhan Liu , Jing Zhang , Nini Zhang , Xiayin Yao . 液相法制备硫化物固体电解质及其在全固态锂电池中的应用. Acta Physico-Chimica Sinica, 2025, 41(1): 2309019-. doi: 10.3866/PKU.WHXB202309019
11. [11]
  Yanan Liu , Yufei He , Dianqing Li . Preparation of Highly Dispersed LDHs-based Catalysts and Testing of Nitro Compound Reduction Performance: A Comprehensive Chemical Experiment for Research Transformation. University Chemistry, 2024, 39(8): 306-313. doi: 10.3866/PKU.DXHX202401081
12. [12]
  Yanhui Zhong , Ran Wang , Zian Lin . Analysis of Halogenated Quinone Compounds in Environmental Water by Dispersive Solid-Phase Extraction with Liquid Chromatography-Triple Quadrupole Mass Spectrometry. University Chemistry, 2024, 39(11): 296-303. doi: 10.12461/PKU.DXHX202402017
13. [13]
  Ping ZHANG , Chenchen ZHAO , Xiaoyun CUI , Bing XIE , Yihan LIU , Haiyu LIN , Jiale ZHANG , Yu'nan CHEN . Preparation and adsorption-photocatalytic performance of ZnAl@layered double oxides. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1965-1974. doi: 10.11862/CJIC.20240014
14. [14]
  Xueyu Lin , Ruiqi Wang , Wujie Dong , Fuqiang Huang . 高性能双金属氧化物负极的理性设计及储锂特性. Acta Physico-Chimica Sinica, 2025, 41(3): 2311005-. doi: 10.3866/PKU.WHXB202311005
15. [15]
  Ziliang KANG , Jiamin ZHANG , Hong AN , Xiaohua LIU , Yang CHEN , Jinping LI , Libo LI . Preparation and water adsorption properties of CaCl₂@MOF-808 in-situ composite moulded particles. Chinese Journal of Inorganic Chemistry, 2024, 40(11): 2133-2140. doi: 10.11862/CJIC.20240282
16. [16]
  Chuanming GUO , Kaiyang ZHANG , Yun WU , Rui YAO , Qiang ZHAO , Jinping LI , Guang LIU . Performance of MnO₂-0.39IrO_x composite oxides for water oxidation reaction in acidic media. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1135-1142. doi: 10.11862/CJIC.20230459
17. [17]
  Qingqing SHEN , Xiangbowen DU , Kaicheng QIAN , Zhikang JIN , Zheng FANG , Tong WEI , Renhong LI . Self-supporting Cu/α-FeOOH/foam nickel composite catalyst for efficient hydrogen production by coupling methanol oxidation and water electrolysis. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1953-1964. doi: 10.11862/CJIC.20240028
18. [18]
  Jiaxin Su , Jiaqi Zhang , Shuming Chai , Yankun Wang , Sibo Wang , Yuanxing Fang . Optimizing Poly(heptazine imide) Photoanodes Using Binary Molten Salt Synthesis for Water Oxidation Reaction. Acta Physico-Chimica Sinica, 2024, 40(12): 2408012-. doi: 10.3866/PKU.WHXB202408012
19. [19]
  Xiaofeng Zhu , Bingbing Xiao , Jiaxin Su , Shuai Wang , Qingran Zhang , Jun Wang . Transition Metal Oxides/Chalcogenides for Electrochemical Oxygen Reduction into Hydrogen Peroxides. Acta Physico-Chimica Sinica, 2024, 40(12): 2407005-. doi: 10.3866/PKU.WHXB202407005
20. [20]
  Xin Han , Zhihao Cheng , Jinfeng Zhang , Jie Liu , Cheng Zhong , Wenbin Hu . Design of Amorphous High-Entropy FeCoCrMnBS (Oxy) Hydroxides for Boosting Oxygen Evolution Reaction. Acta Physico-Chimica Sinica, 2025, 41(4): 100033-. doi: 10.3866/PKU.WHXB202404023

Get Citation

PDF

XML

Metrics

PDF Downloads(485)
Abstract views(957)
HTML views(82)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142