Citation: LUO Yong-Chun, ZHANG Tie-Jun, WANG Duo, KANG Long. Influence of Ball-Milling on Hydrogen Storage and Electrochemical Properties of (Ti Cr)_0.497V_0.42Fe_0.083/30%(w) (LaRMg)(NiCoAl)_3.5 Alloy Electrodes[J]. Acta Physico-Chimica Sinica, ;2010, 26(09): 2397-2404. doi: 10.3866/PKU.WHXB20100845 shu

Influence of Ball-Milling on Hydrogen Storage and Electrochemical Properties of (Ti Cr)_0.497V_0.42Fe_0.083/30%(w) (LaRMg)(NiCoAl)_3.5 Alloy Electrodes

1.
1. College of Materials Science and Engineering, Lanzhou University of Technology, Lanzhou 730050, P. R. China;
2. State Key Laboratory of Gansu Advanced Non-Ferrous Metal Materials, Lanzhou University of Technology, Lanzhou 730050, P. R. China

Received Date: 18 February 2010
Available Online: 7 July 2010
Fund Project:

Changes in phase structure, hydrogen storage and electrochemical properties of the (Ti Cr)_0.497V_0.42Fe_0.083+ 30% (w) (LaRMg)(NiCoAl)_3.5 alloy after treatment by ball-milling for different time (t=0, 0.5, 1, 3, 5, 10 h) were investigated systematically. X-ray diffraction (XRD), scanning electron microscopy (SEM), and transmission electron microscopy (TEM) showed that the particle size of the milled composite samples decreased gradually and the powder appears aggregated. The A₂B₇ alloy particles were uniformly dispersed and encapsulated on the surface of the V based alloy particles that were formed after increasing the ball-milling time. It was found that nanocrystalline composites were formed and partial amorphization occurred when the milling time was more than 5 h. The crystal parameter a and the cell volume V of the BCC phase structure in the composite both showed a decrease. Hydrogen storage capacity of the single V based alloy was 3.11%(w), with an increase in milling time hydrogen storage capacity of the milled composites decreased and the maximum hydrogen absorption capacity at room temperature approached 2.47%(w). Electrochemical studies showed that the electrochemical properties of the milled composite were enhanced and the maximum discharge capacity was 425.8 mAh·g^-1. The cyclic stability of the composite electrode improved noticeably. After 100 charge-discharge cycles the discharge capacity retention rate C₁₀₀/C_max of the milled composite electrode was 97%, and it had a better cycle life than that of the A₂B₇ type alloy electrode.
- V-Ti-Cr-Fe and rare earth based alloy,
- Modification by ball-milling,
- Hydrogen storage property,
- Electrochemical property
1. [1]
  
  1. Billur, S.; Farida, L. D.; Michael, H. International Journal of Hydrogen Energy, 2007, 32: 1121
2. [2]
  2. Zhu, Y. F.; Pan, H. G.; Gao, M. X.; Wang, Q. D. International Journal of Hydrogen Energy, 2002, 27: 287
3. [3]
  3. Dou, T.; Wu, Z.; Mao, J. F.; Xu, N, X. Mater. Sci. Eng. A-struct. Mater. Prop. Microstruc. Process., 2008, 476(1-2):34
4. [4]
  4. Pan, H. G.; Zhu, Y. F.; Gao, M. X. J. Alloy. Compd., 2004, 370: 254
5. [5]
  5. Li, Q. A.; Lei, Y. Q.; Wang, C. S. J. Power Source, 1998, 75: 288
6. [6]
  6. Tsukahara, M.; Takahashi, K.; Mishima, T. J. Alloy. Compd., 1995, 231: 616
7. [7]
  7. Tsukahara, M.; Takahashi, K.; Mishima, T.; Sakai, T.; Miyamura, H.; Kuriyama, N.; Uehara, I. J. Alloy. Compd., 1995, 224: 162
8. [8]
  8. Tsukahara, M.; Takahashi, K.; Mishima, T. J. Alloy. Compd., 1996, 245: 59
9. [9]
  9. Zhu, Y. F.; Pan, H. G.; Gao, M. X.; Li, R. International Journal of Hydrogen Energy, 2004, 29: 313
10. [10]
  10. Pan, H. G.; Li, R.; Gao, M. X.; Liu, Y. F. International Journal of Hydrogen Energy, 2006, 31: 1188
11. [11]
  11. Chen, L. X; Li, L.; Wang, X. H.; Dai, F. B.; Zheng, F. P.; Lei, Y. Q. Acta Phys. -Chim. Sin., 2006, 22(5): 523 [陈立新,李露,王新华, 代发帮,郑坊平,雷永泉.物理化学学报, 2006, 22(5): 523]
12. [12]
  12. Liu, F. Y.; Chen, L. X.; Li, L.; Jia, Y. M.; Lei, Y. Q. Acta Phys. - Chim. Sin., 2008, 24(9): 1694 [刘飞烨, 陈立新,李露, 贾彦敏,雷永泉. 物理化学学报, 2008, 24(9): 1694]
13. [13]
  13. Lu, L.;Wang, W. J.; Fan, X. L; Jin, X. F.;Wang, H.; Lei, Y. Q.; Wang, Q. D.; Chen, L. X. International Journal of Hydrogen Energy, 2007, 32: 2434
14. [14]
  14. Jia, Y. M.; Liu, F. Y.; Xiao, X. Z.; Hang, Z. M.; Lei, Y. Q.; Chen, L. X . Acta Phys. -Chim. Sin, 2009, 25(2): 247 [贾彦敏,刘飞烨, 肖学章,杭州明, 雷永泉, 陈立新.物理化学学报, 2009, 25(2): 247]
15. [15]
  15. Wang, Y. Z.; Zhao, M. S.; Wang. L. M. International Journal of Hydrogen Energy, 2009, 34: 2646
16. [16]
  16. Yu, X. B.; Li, F.; Wu, Z.; Xia, B. J. Physics Letters A, 2004, 320: 312
17. [17]
  17. Chu, H. L.; Qiu, S. J.; Sun, L. X. Electrochimica Acta, 2007, 52: 6700
18. [18]
  18. Liu, Y. F.; Zhang, S.; Li, R. International Journal of Hydrogen Energy, 2008, 33: 728
19. [19]
  19. Parka, J. Y.; Parka, C. N.; Park, C. J. International Journal of Hydrogen Energy, 2007, 32: 4215
20. [20]
  20. Liu, X. Studies on the electrochemical properties of Ti0.8Zr0.2V2.7Mn0.5Cr0.7Ni1.75/La1.5Mg0.5Ni6.7Al0.3 hydrogen storage composite material [D]. Lanzhou: LanzhouUniversity of Technology, 2008 [刘夏. Ti0.8Zr0.2V2.7Mn0.5Cr0.7Ni1.75/La1.5Mg0.5Ni6.7Al0.3复合储氢材料的电化学性能研究[D]. 兰州: 兰州理工大学, 2008]
21. [21]
  21. Wang, D. H.; Xu, G. S.; Luo, Y. C.; Kong, L. Journal of Lanzhou University of Technology, 2006, 32(6): 13 [王大辉,徐广胜, 罗永春,康龙. 兰州理工大学学报, 2006, 32(6): 13]
22. [22]
  22. Yan, Y. G.; Chen, Y. G.; Liang, H. Rare Metal Materials and Engineering, 2006, 35(5): 686 [严义刚, 陈云贵,梁浩.稀有金属与工程, 2006, 35(5): 686]
23. [23]
  23. Yan, Y. G.; Chen, Y. G.; Liang, H. J. Alloy. Compd., 2007, 427: 110
24. [24]
  24. Singh, B. K.; Shim, G. C.; Cho, S. W. International Journal of Hydrogen Energy, 2007, 32: 4961
25. [25]
  25. Hang, Z. M.; Zheng, F. P.;Wang, C. T. Journal of Xi忆an Jiaotong University, 2008, 42(1): 114 [杭州明,郑坊平,王春涛.西安交通大学学报, 2008, 42(1): 114]
26. [26]
  26. Wang, J. H.; Pan, H. G.; Li, R.; Zhong, K.; Gao, M. X. International Journal of Hydrogen Energy, 2007, 32: 3381
1. [1]
  Xinpeng LIU , Liuyang ZHAO , Hongyi LI , Yatu CHEN , Aimin WU , Aikui LI , Hao HUANG . Ga₂O₃ coated modification and electrochemical performance of Li_1.2Mn_0.54Ni_0.13Co_0.13O₂ cathode material. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1105-1113. doi: 10.11862/CJIC.20230488
2. [2]
  Kun Xu , Xinxin Song , Zhilei Yin , Jian Yang , Qisheng Song . Comprehensive Experimental Design of Preferential Orientation of Zinc Metal by Heat Treatment for Enhanced Electrochemical Performance. University Chemistry, 2024, 39(4): 192-197. doi: 10.3866/PKU.DXHX202309050
3. [3]
  Jiahong ZHENG , Jiajun SHEN , Xin BAI . Preparation and electrochemical properties of nickel foam loaded NiMoO₄/NiMoS₄ composites. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 581-590. doi: 10.11862/CJIC.20230253
4. [4]
  Hongyi LI , Aimin WU , Liuyang ZHAO , Xinpeng LIU , Fengqin CHEN , Aikui LI , Hao HUANG . Effect of Y(PO₃)₃ double-coating modification on the electrochemical properties of Li[Ni_0.8Co_0.15Al_0.05]O₂. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1320-1328. doi: 10.11862/CJIC.20230480
5. [5]
  Qingtang ZHANG , Xiaoyu WU , Zheng WANG , Xiaomei WANG . Performance of nano Li₂FeSiO₄/C cathode material co-doped by potassium and chlorine ions. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1689-1696. doi: 10.11862/CJIC.20240115
6. [6]
  Yuanchao LI , Weifeng HUANG , Pengchao LIANG , Zifang ZHAO , Baoyan XING , Dongliang YAN , Li YANG , Songlin WANG . Effect of heterogeneous dual carbon sources on electrochemical properties of LiMn_0.8Fe_0.2PO₄/C composites. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 751-760. doi: 10.11862/CJIC.20230252
7. [7]
  Jiahong ZHENG , Jingyun YANG . Preparation and electrochemical properties of hollow dodecahedral CoNi₂S₄ supported by MnO₂ nanowires. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1881-1891. doi: 10.11862/CJIC.20240170
8. [8]
  Yongming Zhu , Huili Hu , Yuanchun Yu , Xudong Li , Peng Gao . Construction and Practice on New Form Stereoscopic Textbook of Electrochemistry for Energy Storage Science and Engineering: Taking Basic Course of Electrochemistry as an Example. University Chemistry, 2024, 39(8): 44-47. doi: 10.3866/PKU.DXHX202312086
9. [9]
  Zhihuan XU , Qing KANG , Yuzhen LONG , Qian YUAN , Cidong LIU , Xin LI , Genghuai TANG , Yuqing LIAO . Effect of graphene oxide concentration on the electrochemical properties of reduced graphene oxide/ZnS. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1329-1336. doi: 10.11862/CJIC.20230447
10. [10]
  Qin ZHU , Jiao MA , Zhihui QIAN , Yuxu LUO , Yujiao GUO , Mingwu XIANG , Xiaofang LIU , Ping NING , Junming GUO . Morphological evolution and electrochemical properties of cathode material LiAl_0.08Mn_1.92O₄ single crystal particles. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1549-1562. doi: 10.11862/CJIC.20240022
11. [11]
  Qi Li , Pingan Li , Zetong Liu , Jiahui Zhang , Hao Zhang , Weilai Yu , Xianluo Hu . Fabricating Micro/Nanostructured Separators and Electrode Materials by Coaxial Electrospinning for Lithium-Ion Batteries: From Fundamentals to Applications. Acta Physico-Chimica Sinica, 2024, 40(10): 2311030-. doi: 10.3866/PKU.WHXB202311030
12. [12]
  Limei CHEN , Mengfei ZHAO , Lin CHEN , Ding LI , Wei LI , Weiye HAN , Hongbin WANG . Preparation and performance of paraffin/alkali modified diatomite/expanded graphite composite phase change thermal storage material. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 533-543. doi: 10.11862/CJIC.20230312
13. [13]
  Ming ZHENG , Yixiao ZHANG , Jian YANG , Pengfei GUAN , Xiudong LI . Energy storage and photoluminescence properties of Sm³⁺-doped Ba_0.85Ca_0.15Ti_0.90Zr_0.10O₃ lead-free multifunctional ferroelectric ceramics. Chinese Journal of Inorganic Chemistry, 2024, 40(4): 686-692. doi: 10.11862/CJIC.20230388
14. [14]
  Linbao Zhang , Weisi Guo , Shuwen Wang , Ran Song , Ming Li . Electrochemical Oxidation of Sulfides to Sulfoxides. University Chemistry, 2024, 39(11): 204-209. doi: 10.3866/PKU.DXHX202401009
15. [15]
  Xin XIONG , Qian CHEN , Quan XIE . First principles study of the photoelectric properties and magnetism of La and Yb doped AlN. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1519-1527. doi: 10.11862/CJIC.20240064
16. [16]
  Jiaxing Cai , Wendi Xu , Haoqiang Chi , Qian Liu , Wa Gao , Li Shi , Jingxiang Low , Zhigang Zou , Yong Zhou . 具有0D/2D界面的InOOH/ZnIn₂S₄空心球S型异质结用于增强光催化CO₂转化性能. Acta Physico-Chimica Sinica, 2024, 40(11): 2407002-. doi: 10.3866/PKU.WHXB202407002
17. [17]
  Liangzhen Hu , Li Ni , Ziyi Liu , Xiaohui Zhang , Bo Qin , Yan Xiong . A Green Chemistry Experiment on Electrochemical Synthesis of Benzophenone. University Chemistry, 2024, 39(6): 350-356. doi: 10.3866/PKU.DXHX202312001
18. [18]
  Jinyao Du , Xingchao Zang , Ningning Xu , Yongjun Liu , Weisi Guo . Electrochemical Thiocyanation of 4-Bromoethylbenzene. University Chemistry, 2024, 39(6): 312-317. doi: 10.3866/PKU.DXHX202310039
19. [19]
  Yong Zhou , Jia Guo , Yun Xiong , Luying He , Hui Li . Comprehensive Teaching Experiment on Electrochemical Corrosion in Galvanic Cell for Chemical Safety and Environmental Protection Course. University Chemistry, 2024, 39(7): 330-336. doi: 10.3866/PKU.DXHX202310109
20. [20]
  Zhengli Hu , Jia Wang , Yi-Lun Ying , Shaochuang Liu , Hui Ma , Wenwei Zhang , Jianrong Zhang , Yi-Tao Long . Exploration of Ideological and Political Elements in the Development History of Nanopore Electrochemistry. University Chemistry, 2024, 39(8): 344-350. doi: 10.3866/PKU.DXHX202401072

Get Citation

PDF

XML

Metrics

PDF Downloads(1425)
Abstract views(2456)
HTML views(6)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Influence of Ball-Milling on Hydrogen Storage and Electrochemical Properties of (Ti Cr)0.497V0.42Fe0.083/30%(w) (LaRMg)(NiCoAl)3.5 Alloy Electrodes

Metrics

通讯作者: 陈斌, bchen63@163.com

Influence of Ball-Milling on Hydrogen Storage and Electrochemical Properties of (Ti Cr)_0.497V_0.42Fe_0.083/30%(w) (LaRMg)(NiCoAl)_3.5 Alloy Electrodes