Citation: YUN Huan, LIU Xin, WANG Jing, YAN Hua, CUI Fengyun, ZHANG Zhaohui. Rapid screening and confirming carcinogenic banned azo colorants in textiles by high performance liquid chromatography-linear ion trap/orbitrap high-resolution mass spectrometry[J]. Chinese Journal of Chromatography, ;2013, 31(9): 845-849. doi: 10.3724/SP.J.1123.2013.01031 shu

Rapid screening and confirming carcinogenic banned azo colorants in textiles by high performance liquid chromatography-linear ion trap/orbitrap high-resolution mass spectrometry

1.
Technology Center of Beijing Entry-Exit Inspection and Quarantine Bureau, Beijing 100026, China

Corresponding author: YUN Huan,
Received Date: 22 January 2013
Available Online: 8 March 2013
Fund Project: 国家质检总局科研项目(2010IK104,2012IK145). (2010IK104,2012IK145)

A method of high performance liquid chromatography-linear ion trap/orbitrap high-resolution mass spectrometry (HPLC-LTQ/Orbitrap MS) was used to screen and confirm banned azo colorants in textiles rapidly. The analytes were reduced to carcinogenic aromatic amines with sodium dithionite in citrate buffer solution. The reduced solution was extracted by diatomite, and loaded onto an Acquity UPLC BEH C18 column (50 mm×2.1 mm, 1.7 μm)with a gradient elution of methanol and 0.1%(v/v) methane acid aqueous solution, and finally detected by linear ion trap/orbitrap high-resolution mass spectrometry in positive ESI mode. In mass spectrometry method, the MS spectrum of high-resolution and the collision induced dissociation (CID) spectrum of data-dependent scan mode were used for screening analysis and conformation, respectively. The calibration curves showed a good linearity in the range of 0.05-2.00 mg/L, and the correlation coefficients (r) were higher than 0.99. By detecting spiked samples, the limits of quantification were 0.08 mg/kg for all the residues and the recoveries were in the range of 65.5%-111.5% with the relative standard deviations (RSDs) between 0.87% and 2.49%. The results indicate that the method is simple, rapid, sensitive and suitable for the qualitative and quantitative analysis of carcinogenic aromatic amines in textiles.
1. [1]
  [1] Lu S Y, Guan Z W. Journal of Environment and Health (鲁生业, 官志文. 环境与健康杂志), 2002, 19(5): 355
2. [2]
  [2] Pinheiroa H M, Touraudb E, Thomas O. Dyes Pigments, 2004, 61: 121
3. [3]
  [3] Yu L Y, Sun Y, Jin J. West Leather (俞凌云, 孙艳, 金晶. 西部皮革), 2011, 33(8): 49
4. [4]
  [4] Peng B, Xiao Q. China Textile Leader (鹏搏, 晓琴. 纺织导报), 1998(1): 41
5. [5]
  [5] GB/T 17592.1-3-1998
6. [6]
  [6] Li H Y. Chemistry & Bioengineering (李海燕. 化学与生物工程), 2006, 23(8): 55
7. [7]
  [7] Qian W J, Ruan Y, Zhang W D, et al. Shanghai Textile Science & Technology (钱微君, 阮勇, 张卫娣, 等. 上海纺织科技), 2010, 38(5): 55
8. [8]
  [8] Zhang W H, Sun Z S, Zhang Q Z, et al. Science and Technology Innovation Herald (张文皓, 孙忠松, 张清智, 等. 科技创新导报), 2010(3): 117
9. [9]
  [9] Shao Q R, Fang X Y, Ding X. Chinese Journal of Analysis Laboratory (邵秋荣, 方邢有, 丁晓. 分析试验室), 2010, 29(Suppl): 417
10. [10]
  [10] Yang J S, Xu Y Y, Jiang H. Dyeing and Finishing (杨继生, 徐逸云, 蒋华. 印染), 2005(6): 37
11. [11]
  [11] Shao X G, Li M Q. Chinese Journal of Chromatography (邵学广, 李梅青. 色谱), 2001, 19(2): 184
12. [12]
  [12] Wang H H, Niu Z Y, Ye X W, et al. Journal of Instrumental Analysis (王卉卉, 牛增元, 叶曦文, 等. 分析测试学报), 2009, 28(8): 944
13. [13]
  [13] Tang C J, Nie J M, Wang X N, et al. Chinese Journal of Analysis Laboratory (唐川江, 聂锦梅, 王晓宁, 等. 分析试验室), 2011, 30(9): 75
14. [14]
  [14] Ma Q, Bai H, Wang C, et al. Chinese Journal of Analytical Chemistry (马强, 白桦, 王超, 等. 分析化学), 2010, 38(1): 51
15. [15]
  [15] Ye H Y, Zheng S Q, Liang C, et al. Chinese Journal of Analytical Chemistry (叶海英, 郑水庆, 梁晨, 等. 分析化学), 2012, 40(11): 1674
16. [16]
  [16] Chen J X, Deng J W, Chen H, et al. Chinese Journal of Analytical Chemistry (陈建新, 邓洁薇, 陈红, 等. 分析化学), 2011, 39(12): 1858
17. [17]
  [17] Council Directive 96/23/EC
1. [1]
  Zitong Chen , Zipei Su , Jiangfeng Qian . Aromatic Alkali Metal Reagents: Structures, Properties and Applications. University Chemistry, 2024, 39(8): 149-162. doi: 10.3866/PKU.DXHX202311054
2. [2]
  Mingyang Men , Jinghua Wu , Gaozhan Liu , Jing Zhang , Nini Zhang , Xiayin Yao . 液相法制备硫化物固体电解质及其在全固态锂电池中的应用. Acta Physico-Chimica Sinica, 2025, 41(1): 2309019-. doi: 10.3866/PKU.WHXB202309019
3. [3]
  Wentao Lin , Wenfeng Wang , Yaofeng Yuan , Chunfa Xu . Concerted Nucleophilic Aromatic Substitution Reactions. University Chemistry, 2024, 39(6): 226-230. doi: 10.3866/PKU.DXHX202310095
4. [4]
  Yongpo Zhang , Xinfeng Li , Yafei Song , Mengyao Sun , Congcong Yin , Chunyan Gao , Jinzhong Zhao . Synthesis of Chlorine-Bridged Binuclear Cu(I) Complexes Based on Conjugation-Driven Cu(II) Oxidized Secondary Amines. University Chemistry, 2024, 39(5): 44-51. doi: 10.3866/PKU.DXHX202309092
5. [5]
  Yanhui Zhong , Ran Wang , Zian Lin . Analysis of Halogenated Quinone Compounds in Environmental Water by Dispersive Solid-Phase Extraction with Liquid Chromatography-Triple Quadrupole Mass Spectrometry. University Chemistry, 2024, 39(11): 296-303. doi: 10.12461/PKU.DXHX202402017
6. [6]
  Simin Fang , Wei Huang , Guanghua Yu , Cong Wei , Mingli Gao , Guangshui Li , Hongjun Tian , Wan Li . Integrating Science and Education in a Comprehensive Chemistry Design Experiment: The Preparation of Copper(I) Oxide Nanoparticles and Its Application in Dye Water Remediation. University Chemistry, 2024, 39(8): 282-289. doi: 10.3866/PKU.DXHX202401023
7. [7]
  Yi Yang , Xin Zhou , Miaoli Gu , Bei Cheng , Zhen Wu , Jianjun Zhang . S型ZnO/CdIn₂S₄光催化剂制备H₂O₂偶联苄胺氧化的超快电子转移飞秒吸收光谱研究. Acta Physico-Chimica Sinica, 2025, 41(6): 100064-. doi: 10.1016/j.actphy.2025.100064
8. [8]
  Feiya Cao , Qixin Wang , Pu Li , Zhirong Xing , Ziyu Song , Heng Zhang , Zhibin Zhou , Wenfang Feng . Magnesium-Ion Conducting Electrolyte Based on Grignard Reaction: Synthesis and Properties. University Chemistry, 2024, 39(3): 359-368. doi: 10.3866/PKU.DXHX202308094
9. [9]
  Zunxiang Zeng , Yuling Hu , Yufei Hu , Hua Xiao . Analysis of Plant Essential Oils by Supercritical CO₂Extraction with Gas Chromatography-Mass Spectrometry: An Instrumental Analysis Comprehensive Experiment Teaching Reform. University Chemistry, 2024, 39(3): 274-282. doi: 10.3866/PKU.DXHX202309069
10. [10]
  Zian Lin , Yingxue Jin . Matrix-Assisted Laser Desorption/Ionization Mass Spectrometry (MALDI-MS) for Disease Marker Screening and Identification: A Comprehensive Experiment Teaching Reform in Instrumental Analysis. University Chemistry, 2024, 39(11): 327-334. doi: 10.12461/PKU.DXHX202403066
11. [11]
  Xiuyun Wang , Jiashuo Cheng , Yiming Wang , Haoyu Wu , Yan Su , Yuzhuo Gao , Xiaoyu Liu , Mingyu Zhao , Chunyan Wang , Miao Cui , Wenfeng Jiang . Improvement of Sodium Ferric Ethylenediaminetetraacetate (NaFeEDTA) Iron Supplement Preparation Experiment. University Chemistry, 2024, 39(2): 340-346. doi: 10.3866/PKU.DXHX202308067
12. [12]
  Aoyu Huang , Jun Xu , Yu Huang , Gui Chu , Mao Wang , Lili Wang , Yongqi Sun , Zhen Jiang , Xiaobo Zhu . Tailoring Electrode-Electrolyte Interfaces via a Simple Slurry Additive for Stable High-Voltage Lithium-Ion Batteries. Acta Physico-Chimica Sinica, 2025, 41(4): 100037-. doi: 10.3866/PKU.WHXB202408007
13. [13]
  Zhen Yao , Bing Lin , Youping Tian , Tao Li , Wenhui Zhang , Xiongwei Liu , Wude Yang . Visible-Light-Mediated One-Pot Synthesis of Secondary Amines and Mechanistic Exploration. University Chemistry, 2024, 39(5): 201-208. doi: 10.3866/PKU.DXHX202311033
14. [14]
  Xiaowu Zhang , Pai Liu , Qishen Huang , Shufeng Pang , Zhiming Gao , Yunhong Zhang . Acid-Base Dissociation Equilibrium in Multiphase System: Effect of Gas. University Chemistry, 2024, 39(4): 387-394. doi: 10.3866/PKU.DXHX202310021
15. [15]
  Qi Li , Pingan Li , Zetong Liu , Jiahui Zhang , Hao Zhang , Weilai Yu , Xianluo Hu . Fabricating Micro/Nanostructured Separators and Electrode Materials by Coaxial Electrospinning for Lithium-Ion Batteries: From Fundamentals to Applications. Acta Physico-Chimica Sinica, 2024, 40(10): 2311030-. doi: 10.3866/PKU.WHXB202311030
16. [16]
  Hao Wu , Zhen Liu , Dachang Bai . ¹H NMR Spectrum of Amide Compounds. University Chemistry, 2024, 39(3): 231-238. doi: 10.3866/PKU.DXHX202309020
17. [17]
  Chongjing Liu , Yujian Xia , Pengjun Zhang , Shiqiang Wei , Dengfeng Cao , Beibei Sheng , Yongheng Chu , Shuangming Chen , Li Song , Xiaosong Liu . Understanding Solid-Gas and Solid-Liquid Interfaces through Near Ambient Pressure X-Ray Photoelectron Spectroscopy. Acta Physico-Chimica Sinica, 2025, 41(2): 100013-. doi: 10.3866/PKU.WHXB202309036
18. [18]
  Kexin Dong , Chuqi Shen , Ruyu Yan , Yanping Liu , Chunqiang Zhuang , Shijie Li . Integration of Plasmonic Effect and S-Scheme Heterojunction into Ag/Ag₃PO₄/C₃N₅ Photocatalyst for Boosted Photocatalytic Levofloxacin Degradation. Acta Physico-Chimica Sinica, 2024, 40(10): 2310013-. doi: 10.3866/PKU.WHXB202310013
19. [19]
  Yinuo Wang , Siran Wang , Yilong Zhao , Dazhen Xu . Selective Synthesis of Diarylmethyl Anilines and Triarylmethanes via Multicomponent Reactions: Introduce a Comprehensive Experiment of Organic Chemistry. University Chemistry, 2024, 39(8): 324-330. doi: 10.3866/PKU.DXHX202401063
20. [20]
  Peipei Sun , Jinyuan Zhang , Yanhua Song , Zhao Mo , Zhigang Chen , Hui Xu . 引入内建电场增强光载流子分离以促进H₂的生产. Acta Physico-Chimica Sinica, 2024, 40(11): 2311001-. doi: 10.3866/PKU.WHXB202311001

Get Citation

PDF

XML

Metrics

PDF Downloads(0)
Abstract views(352)
HTML views(79)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142