Citation: XU Yong-Hua, WANG Na, LIU Jin-Ming. Research on Rapid Determination of Lignocellulosic Contents in Corn Stover Using Near Infrared Spectroscopy Based on Spectral Intervals Selection[J]. Chinese Journal of Analytical Chemistry, ;2022, 50(10): 1587-1596. doi: 10.19756/j.issn.0253-3820.221239 shu

Research on Rapid Determination of Lignocellulosic Contents in Corn Stover Using Near Infrared Spectroscopy Based on Spectral Intervals Selection

XU Yong-Hua ¹ ,
WANG Na ² ,
LIU Jin-Ming ^2,3,,

1.
School of Electrical and Information, Northeast Agricultural University, Harbin 150030, China;
2.
College of Information and Electrical Engineering, Heilongjiang Bayi Agricultural University, Daqing 163319, China;
3.
National Coarse Cereals Engineering Research Center, Daqing 163319, China

Corresponding author: LIU Jin-Ming, jinmingliu2008@126.com
Received Date: 15 May 2022
Revised Date: 2 July 2022

Fund Project: Supported by the National Natural Science Foundation of China (No.52076034), the Heilongjiang Province Science and Technology Plan, Provincial Academy Science and Technology Cooperation Project (No.YS20B01) and the Scientific Research Foundation for Talent of Heilongjiang Bayi Agricultural University (No.XDB202006).

The contents of lignocellulosic components (including cellulose, hemicellulose and lignin) have an important influence on the methane yield of anaerobic digestion (AD) with corn stover (CS) as feedstocks in biogas industry. Aiming at the time-consuming and high-cost issues of traditional chemical analytical techniques, the feasibility of near infrared spectroscopy (NIRS) combined with chemometrics methods to measure the contents of lignocellulose in corn stover was analyzed in this work. To improve the detection accuracy and efficiency of NIRS regressive model, the genetic simulated annealing interval support vector machine (GSA-iSVM) was constructed using genetic simulated annealing algorithm (GSA) combined with interval partial least squares (iPLS) and support vector machine (SVM), which was used for synchronous optimization of the NIRS characteristic intervals and SVM parameters. By comparison with the modeling performance of the characteristic spectral intervals selected by backward interval partial least squares and genetic simulated annealing interval partial least squares (GSA-iPLS), it was found that the calibration model for cellulose and lignin established by GSA-iSVM had the best predicted accuracy, and that of hemicellulose established by GSA-iPLS performed best. For the validation set, the determination coefficients of prediction, root mean squared error of prediction and residual predictive deviation of the best calibration models were 0.910, 0.881% and 3.283 for cellulose; 0.990, 0.707% and 10.235 for hemicellulose; and 0.939, 0.249% and 4.270 for lignin, respectively. The results indicated that NIRS coupled with characteristic intervals intelligent selection of GSA could be used as a reliable alternative strategy to measure contents of lignocellulosic components in the pretreated CS in AD process.
- Corn stover,
- Lignocellulose,
- Near infrared spectroscopy,
- Characteristic intervals,
- Partial least squares,
- Support vector machine
1. [1]
  CHU X, CHENG Q, XU Y, LUO L, WANG M, ZHENG G, ZHANG H, YI W, LIU X, SUN Y, SUN Y. Bioresource Technol., 2021, 341:125826.
2. [2]
  YANG G, LI Y, ZHEN F, XU Y, LIU J, LI N, SUN Y, LUO L, WANG M, ZHANG L. Bioresource Technol., 2021, 326:124745.
3. [3]
  JEONG S Y, LEE E J, BAN S E, LEE J W. Renew. Energ., 2021, 172:1341-1350.
4. [4]
5. [5]
  AI N, JIANG Y, OMAR S, WANG J, XIA L, REN J. Molecules, 2022, 27(2):335.
6. [6]
  SERAFIM C C, GUERRA G L, MIZUBUTI I Y, DE CASTRO F A B, PRADO-CALIXTO O P, GALBEIRO S, PARRA A R P, BUMBIERIS V H, PERTILE S F N, REGO F C D. Semina:Cienc. Agrar., 2021, 42(3):1287-1302.
7. [7]
  YU Y, ZHANG Q, HUANG J, ZHU J, LIU J. Infrared Phys. Technol., 2021, 116:103785.
8. [8]
  MEENU M, ZHANG Y, KAMBOJ U, ZHAO S, CAO L, HE P, XU B. Foods, 2022, 11(1):43.
9. [9]
  ZHANG Y Z, HUANG J P, ZHANG Q L, LIU J W, MENG Y L, YU Y. Appl. Optics, 2022, 61(12):3419-3428.
10. [10]
  BOIDO E, FARINA L, CARRAU F, COZZOLINO D, DELLACASSA E. Food Chem., 2022, 387:132927.
11. [11]
  WANG D, XIE L, YANG S X, TIAN F. Sensors, 2018, 18(10):3222.
12. [12]
  JIN X, CHEN X, SHI C, LI M, GUAN Y, YU C Y, YAMADA T, SACKS E J, PENG J. Bioresource Technol., 2017, 241:603-609.
13. [13]
  LI L, WANG Y, JIN S, LI M, CHEN Q, NING J, ZHANG Z. Spectrochim. Acta, Part A, 2021, 246:118991.
14. [14]
  LIU J, JIN S, BAO C, SUN Y, LI W. Bioresource Technol., 2021, 321:124449.
15. [15]
16. [16]
  LEARDI R, NORGAARD L. J. Chemom., 2004, 18(11):486-497.
17. [17]
18. [18]
  GUAN R, YUAN H, YUAN S, YAN B, ZUO X, CHEN X, LI X. Bioresource Technol., 2022, 349:126615.
19. [19]
  SUN Y, QU J, LI R, LI W, WANG Z, CHU X. J. Biobased Mater. Bioenergy, 2018, 12(5):432-440.
20. [20]
  VAN SOEST P J, ROBERTSON J B, LEWIS B A. J. Dairy Sci., 1991, 74(10):3583-3597.
21. [21]
  CHU X, AWASTHI M K, LIU Y, CHENG Q, QU J, SUN Y. Bioresource Technol., 2021, 320:124174.
22. [22]
  ZHANG H, HU X, LIU L, WEI J, BIAN X. Spectrochim. Acta, Part A, 2022, 270:120841.
23. [23]
  XIE S, DING F, CHEN S, WANG X, LI Y, MA K. Spectrochim. Acta, Part A, 2022, 273:120949.
24. [24]
  MULRENNAN K, MUNIR N, CREEDON L, DONOVAN J, LYONS J G, MCAFEE M. Sensors, 2022, 22(8):2835.
25. [25]
  SHUKLA S R, SHASHIKALA S, SUJATHA M. J. Near Infrared Spectrosc., 2021, 29(3):168-178.
1. [1]
  Qi Wang , Yicong Gao , Feng Lu , Quli Fan . Preparation and Performance Characterization of the Second Near-Infrared Phototheranostic Probe: A New Design and Teaching Practice of Polymer Chemistry Comprehensive Experiment. University Chemistry, 2024, 39(11): 342-349. doi: 10.12461/PKU.DXHX202404141
2. [2]
  Jin ZHANG , Yuting WANG , Bin YU , Yuxin ZHONG , Yufeng ZHANG . Corn straw-derived carbon/BiOBr composite: Synthesis and photocatalytic degradation performance for rhodamine B. Chinese Journal of Inorganic Chemistry, 2025, 41(7): 1397-1408. doi: 10.11862/CJIC.20250028
3. [3]
  Yang Wang , Yunpeng Fu , Xiaoji Liu , Guotao Zhang , Guobin Li , Wanqiang Liu , Jinglun Wang . Structural Analysis of Nitrile Solutions Based on Infrared Spectroscopy Probes. University Chemistry, 2025, 40(4): 367-374. doi: 10.12461/PKU.DXHX202406113
4. [4]
  Xiaoning TANG , Junnan LIU , Xingfu YANG , Jie LEI , Qiuyang LUO , Shu XIA , An XUE . Effect of sodium alginate-sodium carboxymethylcellulose gel layer on the stability of Zn anodes. Chinese Journal of Inorganic Chemistry, 2024, 40(8): 1452-1460. doi: 10.11862/CJIC.20240191
5. [5]
  Jiageng Li , Putrama . 数值积分耦合非线性最小二乘法一步确定反应动力学参数. University Chemistry, 2025, 40(6): 364-370. doi: 10.12461/PKU.DXHX202407098
6. [6]
  Lisha LEI , Wei YONG , Yiting CHENG , Yibo WANG , Wenchao HUANG , Junhuan ZHAO , Zhongjie ZHAI , Yangbin DING . Application of regenerated cellulose and reduced graphene oxide film in synergistic power generation from moisture electricity generation and Mg-air batteries. Chinese Journal of Inorganic Chemistry, 2025, 41(6): 1151-1161. doi: 10.11862/CJIC.20240202
7. [7]
  Chongjing Liu , Yujian Xia , Pengjun Zhang , Shiqiang Wei , Dengfeng Cao , Beibei Sheng , Yongheng Chu , Shuangming Chen , Li Song , Xiaosong Liu . Understanding Solid-Gas and Solid-Liquid Interfaces through Near Ambient Pressure X-Ray Photoelectron Spectroscopy. Acta Physico-Chimica Sinica, 2025, 41(2): 100013-. doi: 10.3866/PKU.WHXB202309036
8. [8]
  Jiahui CHEN , Tingting ZHENG , Xiuyun ZHANG , Wei LÜ . Research progress of near-infrared absorption inorganic nanomaterials in photothermal and photodynamic therapy of tumors. Chinese Journal of Inorganic Chemistry, 2024, 40(12): 2396-2414. doi: 10.11862/CJIC.20240106
9. [9]
  Han ZHANG , Jianfeng SUN , Jinsheng LIANG . Hydrothermal synthesis and luminescent properties of broadband near-infrared Na₃CrF₆ phosphor. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 349-356. doi: 10.11862/CJIC.20240098
10. [10]
  Zongyuan Chen , ChunSheng Shi , Yiwen Li , Ganlin Zu , Qiang Jin , Haishan Wang , Fujun Wang , Dekun Yan , Zhijun Guo , Wangsuo Wu . Measurement of Uranium Isotopes in Environmental Water Samples by Alpha-Spectroscopy: Design of an Undergraduate Radiochemistry Experiment. University Chemistry, 2025, 40(4): 353-358. doi: 10.12461/PKU.DXHX202406103
11. [11]
  Jiajie Li , Xiaocong Ma , Jufang Zheng , Qiang Wan , Xiaoshun Zhou , Yahao Wang . Recent Advances in In-Situ Raman Spectroscopy for Investigating Electrocatalytic Organic Reaction Mechanisms. University Chemistry, 2025, 40(4): 261-276. doi: 10.12461/PKU.DXHX202406117
12. [12]
  Zhuoming Liang , Ming Chen , Zhiwen Zheng , Kai Chen . Multidimensional Studies on Ketone-Enol Tautomerism of 1,3-Diketones By ¹H NMR. University Chemistry, 2024, 39(7): 361-367. doi: 10.3866/PKU.DXHX202311029
13. [13]
  Shijie Li , Ke Rong , Xiaoqin Wang , Chuqi Shen , Fang Yang , Qinghong Zhang . Design of Carbon Quantum Dots/CdS/Ta₃N₅ S-Scheme Heterojunction Nanofibers for Efficient Photocatalytic Antibiotic Removal. Acta Physico-Chimica Sinica, 2024, 40(12): 2403005-. doi: 10.3866/PKU.WHXB202403005
14. [14]
  Ran HUO , Zhaohui ZHANG , Xi SU , Long CHEN . Research progress on multivariate two dimensional conjugated metal organic frameworks. Chinese Journal of Inorganic Chemistry, 2024, 40(11): 2063-2074. doi: 10.11862/CJIC.20240195
15. [15]
  Liwei Wang , Guangran Ma , Li Wang , Fugang Xu . A Comprehensive Analytical Chemistry Experiment: Colorimetric Detection of Vitamin C Using Nanozyme and Smartphone. University Chemistry, 2024, 39(8): 255-262. doi: 10.3866/PKU.DXHX202312094
16. [16]
  Lewang Yuan , Yaoyao Peng , Zong-Jie Guan , Yu Fang . Insights into the development of 2D covalent organic frameworks as photocatalysts in organic synthesis. Acta Physico-Chimica Sinica, 2025, 41(8): 100086-0. doi: 10.1016/j.actphy.2025.100086
17. [17]
  Jingjing QING , Fan HE , Zhihui LIU , Shuaipeng HOU , Ya LIU , Yifan JIANG , Mengting TAN , Lifang HE , Fuxing ZHANG , Xiaoming ZHU . Synthesis, structure, and anticancer activity of two complexes of dimethylglyoxime organotin. Chinese Journal of Inorganic Chemistry, 2024, 40(7): 1301-1308. doi: 10.11862/CJIC.20240003
18. [18]
  Xiaoling LUO , Pintian ZOU , Xiaoyan WANG , Zheng LIU , Xiangfei KONG , Qun TANG , Sheng WANG . Synthesis, crystal structures, and properties of lanthanide metal-organic frameworks based on 2, 5-dibromoterephthalic acid ligand. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1143-1150. doi: 10.11862/CJIC.20230271
19. [19]
  Jianding LI , Junyang FENG , Huimin REN , Gang LI . Proton conductive properties of a Hf(Ⅳ)-based metal-organic framework built by 2,5-dibromophenyl-4,6-dicarboxylic acid. Chinese Journal of Inorganic Chemistry, 2025, 41(6): 1094-1100. doi: 10.11862/CJIC.20240464
20. [20]
  Hao Wu , Zhen Liu , Dachang Bai . ¹H NMR Spectrum of Amide Compounds. University Chemistry, 2024, 39(3): 231-238. doi: 10.3866/PKU.DXHX202309020

Get Citation

PDF

XML

Metrics

PDF Downloads(13)
Abstract views(640)
HTML views(90)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142