Citation: Xiangdong Feng, Jie Feng, Wenying Li. Insight into MgO promoter with low concentration for the carbon-deposition resistance of Ni-based catalysts in the CO₂ reforming of CH₄[J]. Chinese Journal of Catalysis, ;2018, 39(1): 88-98. doi: 10.1016/S1872-2067(17)62928-0 shu

Insight into MgO promoter with low concentration for the carbon-deposition resistance of Ni-based catalysts in the CO₂ reforming of CH₄

Xiangdong Feng ^a,b, ,
Jie Feng ^a,b ,
Wenying Li ^a,b

a Key Laboratory of Coal Science and Technology, Taiyuan University of Technology, Taiyuan 030024, Shanxi, China;
b Training Base of State Key Laboratory of Coal Science and Technology Jointly Constructed by Shanxi Province and Ministry of Science and Technology, Taiyuan University of Technology, Taiyuan 030024, Shanxi, China

Received Date: 5 July 2017
Revised Date: 17 September 2017

Fund Project: This work was supported by the National Natural Science Fundation of China (U1361202, 51276120).

The CO₂ reforming of CH₄ is studied over MgO-promoted Ni catalysts, which were supported on alumina prepared from hydrotalcite. This presents an improved stability compared with non-promoted catalysts. The introduction of the MgO promoter was achieved through the "memory effect" of the Ni-Al hydrotalcite structure, and ICP-MS confirmed that only 0.42 wt.% of Mg²⁺ ions were added into the Ni-Mg/Al catalyst. Although no differences in the Ni particle size and basicity strength were observed, the Ni-Mg/Al catalyst showed a higher catalytic stability than the Ni/Al catalyst. A series of surface reaction experiments were used and showed that the addition of a MgO promoter with low concentration can promote CO₂ dissociation to form active surface oxygen arising from the formation of the Ni-MgO interface sites. Therefore, the carbon-resistance promotion by nature was suggested to contribute to an oxidative environment around Ni particles, which would increase the conversion of carbon residues from CH₄ cracking to yield CO on the Ni metal surface.
- CO₂ reforming of CH₄,
- Carbon-deposition resistant,
- Activation of CO₂,
- Ni-based catalyst,
- Low concentration MgO promoter
1. [1]
2. [2]
3. [3]
4. [4]
5. [5]
6. [6]
7. [7]
8. [8]
9. [9]
10. [10]
11. [11]
12. [12]
13. [13]
14. [14]
15. [15]
16. [16]
17. [17]
18. [18]
19. [19]
20. [20]
21. [21]
22. [22]
23. [23]
24. [24]
25. [25]
26. [26]
27. [27]
28. [28]
29. [29]
30. [30]
31. [31]
32. [32]
33. [33]
34. [34]
35. [35]
36. [36]
37. [37]
38. [38]
39. [39]
40. [40]
41. [41]
42. [42]
43. [43]
44. [44]
45. [45]
46. [46]
47. [47]
48. [48]
49. [49]
50. [50]
51. [51]
52. [52]
53. [53]
54. [54]
55. [55]
56. [56]
57. [57]
58. [58]
59. [59]
60. [60]
1. [1]
  Zhiquan Zhang , Baker Rhimi , Zheyang Liu , Min Zhou , Guowei Deng , Wei Wei , Liang Mao , Huaming Li , Zhifeng Jiang . Insights into the Development of Copper-based Photocatalysts for CO₂ Conversion. Acta Physico-Chimica Sinica, 2024, 40(12): 2406029-. doi: 10.3866/PKU.WHXB202406029
2. [2]
  Bing WEI , Jianfan ZHANG , Zhe CHEN . Research progress in fine tuning of bimetallic nanocatalysts for electrocatalytic carbon dioxide reduction. Chinese Journal of Inorganic Chemistry, 2025, 41(3): 425-439. doi: 10.11862/CJIC.20240201
3. [3]
  Jie ZHAO , Huili ZHANG , Xiaoqing LU , Zhaojie WANG . Theoretical calculations of CO₂ capture and separation by functional groups modified 2D covalent organic framework. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 275-283. doi: 10.11862/CJIC.20240213
4. [4]
  Wei HE , Jing XI , Tianpei HE , Na CHEN , Quan YUAN . Application of solar-driven inorganic semiconductor-microbe hybrids in carbon dioxide fixation and biomanufacturing. Chinese Journal of Inorganic Chemistry, 2025, 41(1): 35-44. doi: 10.11862/CJIC.20240364
5. [5]
  Wen YANG , Didi WANG , Ziyi HUANG , Yaping ZHOU , Yanyan FENG . La promoted hydrotalcite derived Ni-based catalysts: In situ preparation and CO₂ methanation performance. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 561-570. doi: 10.11862/CJIC.20230276
6. [6]
  Qingqing SHEN , Xiangbowen DU , Kaicheng QIAN , Zhikang JIN , Zheng FANG , Tong WEI , Renhong LI . Self-supporting Cu/α-FeOOH/foam nickel composite catalyst for efficient hydrogen production by coupling methanol oxidation and water electrolysis. Chinese Journal of Inorganic Chemistry, 2024, 40(10): 1953-1964. doi: 10.11862/CJIC.20240028
7. [7]
  Xiaoning TANG , Shu XIA , Jie LEI , Xingfu YANG , Qiuyang LUO , Junnan LIU , An XUE . Fluorine-doped MnO₂ with oxygen vacancy for stabilizing Zn-ion batteries. Chinese Journal of Inorganic Chemistry, 2024, 40(9): 1671-1678. doi: 10.11862/CJIC.20240149
8. [8]
  Peng YUE , Liyao SHI , Jinglei CUI , Huirong ZHANG , Yanxia GUO . Effects of Ce and Mn promoters on the selective oxidation of ammonia over V₂O₅/TiO₂ catalyst. Chinese Journal of Inorganic Chemistry, 2025, 41(2): 293-307. doi: 10.11862/CJIC.20240210
9. [9]
  Caixia Lin , Zhaojiang Shi , Yi Yu , Jianfeng Yan , Keyin Ye , Yaofeng Yuan . Ideological and Political Design for the Electrochemical Synthesis of Benzoxathiazine Dioxide Experiment. University Chemistry, 2024, 39(2): 61-66. doi: 10.3866/PKU.DXHX202309005
10. [10]
  Xuejie Wang , Guoqing Cui , Congkai Wang , Yang Yang , Guiyuan Jiang , Chunming Xu . 碳基催化剂催化有机液体氢载体脱氢研究进展. Acta Physico-Chimica Sinica, 2025, 41(5): 100044-. doi: 10.1016/j.actphy.2024.100044
11. [11]
  Xue Liu , Lipeng Wang , Luling Li , Kai Wang , Wenju Liu , Biao Hu , Daofan Cao , Fenghao Jiang , Junguo Li , Ke Liu . Cu基和Pt基甲醇水蒸气重整制氢催化剂研究进展. Acta Physico-Chimica Sinica, 2025, 41(5): 100049-. doi: 10.1016/j.actphy.2025.100049
12. [12]
  Juntao Yan , Liang Wei . 2D S-Scheme Heterojunction Photocatalyst. Acta Physico-Chimica Sinica, 2024, 40(10): 2312024-. doi: 10.3866/PKU.WHXB202312024
13. [13]
  Zhanggui DUAN , Yi PEI , Shanshan ZHENG , Zhaoyang WANG , Yongguang WANG , Junjie WANG , Yang HU , Chunxin LÜ , Wei ZHONG . Preparation of UiO-66-NH₂ supported copper catalyst and its catalytic activity on alcohol oxidation. Chinese Journal of Inorganic Chemistry, 2024, 40(3): 496-506. doi: 10.11862/CJIC.20230317
14. [14]
  Lina Guo , Ruizhe Li , Chuang Sun , Xiaoli Luo , Yiqiu Shi , Hong Yuan , Shuxin Ouyang , Tierui Zhang . 层状双金属氢氧化物的层间阴离子对衍生的Ni-Al₂O₃催化剂光热催化CO₂甲烷化反应的影响. Acta Physico-Chimica Sinica, 2025, 41(1): 2309002-. doi: 10.3866/PKU.WHXB202309002
15. [15]
  Jingzhao Cheng , Shiyu Gao , Bei Cheng , Kai Yang , Wang Wang , Shaowen Cao . 4-氨基-1H-咪唑-5-甲腈修饰供体-受体型氮化碳光催化剂的构建及其高效光催化产氢研究. Acta Physico-Chimica Sinica, 2024, 40(11): 2406026-. doi: 10.3866/PKU.WHXB202406026
16. [16]
  .
  CCS Chemistry | 超分子活化底物为自由基促进高效选择性光催化氧化
  . CCS Chemistry, 2025, 7(10.31635/ccschem.025.202405229): -.
17. [17]
  Qiangqiang SUN , Pengcheng ZHAO , Ruoyu WU , Baoyue CAO . Multistage microporous bifunctional catalyst constructed by P-doped nickel-based sulfide ultra-thin nanosheets for energy-efficient hydrogen production from water electrolysis. Chinese Journal of Inorganic Chemistry, 2024, 40(6): 1151-1161. doi: 10.11862/CJIC.20230454
18. [18]
  Hailian Tang , Siyuan Chen , Qiaoyun Liu , Guoyi Bai , Botao Qiao , Fei Liu . Stabilized Rh/hydroxyapatite Catalyst for Furfuryl Alcohol Hydrogenation: Application of Oxidative Strong Metal-Support Interactions in Reducing Conditions. Acta Physico-Chimica Sinica, 2025, 41(4): 100036-. doi: 10.3866/PKU.WHXB202408004
19. [19]
  Ke Li , Chuang Liu , Jingping Li , Guohong Wang , Kai Wang . 钛酸铋/氮化碳无机有机复合S型异质结纯水光催化产过氧化氢. Acta Physico-Chimica Sinica, 2024, 40(11): 2403009-. doi: 10.3866/PKU.WHXB202403009
20. [20]
  Xue Dong , Xiaofu Sun , Shuaiqiang Jia , Shitao Han , Dawei Zhou , Ting Yao , Min Wang , Minghui Fang , Haihong Wu , Buxing Han . 碳修饰的铜催化剂实现安培级电流电化学还原CO₂制C₂₊产物. Acta Physico-Chimica Sinica, 2025, 41(3): 2404012-. doi: 10.3866/PKU.WHXB202404012

Get Citation

PDF

XML

Metrics

PDF Downloads(5)
Abstract views(1031)
HTML views(129)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Insight into MgO promoter with low concentration for the carbon-deposition resistance of Ni-based catalysts in the CO2 reforming of CH4

Metrics

通讯作者: 陈斌, bchen63@163.com

Insight into MgO promoter with low concentration for the carbon-deposition resistance of Ni-based catalysts in the CO₂ reforming of CH₄