Advanced Search

Citation: Niu Yan-hua, Liang Wen-bin, Zhang Yin-ling, Chen Xue-lian, Lai Shih-yaw, Li Guang-xian, Wang Du-jin. Crosslinking Kinetics of Polyethylene with Small Amount of Peroxide and Its Influence on the Subsequent Crystallization Behaviors[J]. Chinese Journal of Polymer Science, ;2016, 34(9): 1117-1128. doi: 10.1007/s10118-016-1819-z shu

Crosslinking Kinetics of Polyethylene with Small Amount of Peroxide and Its Influence on the Subsequent Crystallization Behaviors

a.
College of Polymer Science and Engineering, State Key Laboratory of Polymer Materials Engineering of China, Sichuan University, Chengdu 610065, China
b.
Performance Material Center, National Institute of Clean-and-low-carbon Energy (NICE), Beijing 102209, China
c.
CAS Key Laboratory of Engineering Plastics, Beijing National Laboratory for Molecular Sciences, Institute of Chemistry, Chinese Academy of Sciences, Beijing 100190, China

Corresponding author: Niu Yan-hua, yhniu@scu.edu.cn
Received Date: 1 March 2016
Revised Date: 23 March 2016
Accepted Date: 23 March 2016

Fund Project: the Technical Innovation Project of National Institute of Clean and Low-Carbon Energy No. 15H0543the Open Project of State Key Laboratory of Polymer Materials Engineering of China (Sichuan University) No. sklpme2015-4-11

Crosslinking reactions of high density polyethylene with low peroxide concentrations ranging from 0.1 wt% to 1.0 wt% at temperatures of 170, 180 and 190℃ were monitored by rheological measurements. A critical gel forms at the peroxide concentration of 0.2 wt%, where the transition from long chain branching generation to crosslinking network formation could occur. Rheokinetics of crosslinking can be fitted well by Ding-Leonov’s model. The curing rate k₂ at the earlier stage exhibits about 3 times acceleration per 10℃ with increasing temperature, while the equilibrium modulus G′at the fully cured stage is almost independent of temperature. Influences of crosslinking on the subsequent crystallization behaviors were detected by DSC measurements. Above the critical gel concentration, crystallization is largely retarded as evidenced by the lower crystallization temperature T_c and crystallinity X_c due to the network formation. The secondary crystallization valley located at the temperature near 80℃ can be observed above the critical concentration, which becomes more evident with the increasing peroxide concentration and curing temperature. This phenomenon provides another evidence of crystallization retardation by the crosslinking network.
- Polyethylene,
- Rheology,
- Crosslinking kinetics,
- Crystallization
1. [1]
  Chodák, I., Prog. Polym. Sci., 1995, 20: 1165 doi: 10.1016/0079-6700(95)98859-N
2. [2]
  Satti, A.J., Andreucetti, N.A., Quijada, R., Sarmoria, C. and Vallés, E.M., Radi. Phys. Chem., 2010, 79: 9 doi: 10.1016/j.radphyschem.2009.08.008
3. [3]
  Nilsson, S., Hjertberg, T. and Smedberg, A., Eur. Polym. J., 2010, 46: 1759 doi: 10.1016/j.eurpolymj.2010.05.003
4. [4]
  Khonakdar, H.A., Morshedian, J., Wagenknecht, U. and Jafari, S.H., Polymer, 2003, 44: 4301 doi: 10.1016/S0032-3861(03)00363-X
5. [5]
  Pérez, C.J., Cassano, G.A., Vallés, E.M., Failla, M.D. and Quinzani, L.M., Polymer, 2002, 43: 2711 doi: 10.1016/S0032-3861(02)00076-9
6. [6]
  Andersson, L.H.U. and Hjertberg, T., Polymer, 2006, 47: 200 doi: 10.1016/j.polymer.2005.11.023
7. [7]
  Whelan, A. and Craft, J.L., "Developments in plastics technology-2", Elsevier: London and New York, 1985
8. [8]
  Yamazaki, T. and Seguchi, T., J. Polym. Sci., Part A: Polym. Sci., 1997, 35: 279 doi: 10.1002/(ISSN)1099-0518
9. [9]
  Ding, R. and Leonov, A.I., J. Appl. Polym. Sci., 1996, 61: 455 doi: 10.1002/(ISSN)1097-4628
10. [10]
  Han, I.S., Chung, C.B. and Lee, J.W., Rubb. Chem. Technol., 2000, 73: 101 doi: 10.5254/1.3547572
11. [11]
  Liu, M.G., Zhou, C.X. and Yu, W., Polym. Eng. Sci., 2005, 45: 560 doi: 10.1002/(ISSN)1548-2634
12. [12]
  Ratna, D., "Handbook of thermoset resins”, iSmithers: UK, 2009
13. [13]
  Phillips, P.J. and Kao, Y.H., Polymer, 1986, 27: 1679 doi: 10.1016/0032-3861(86)90261-2
14. [14]
  Shaban, A.M. and Kinawy, N., Polymer, 1995, 36: 4767 doi: 10.1016/00323-8619(59)92923-
15. [15]
  Robertson, M.B., Ward, I.M., Klein, P.G. and Packer, K.J., Macromolecules, 1997, 30: 6893 doi: 10.1021/ma9708712
16. [16]
  Rizzo, P., Baione, F., Guerra, G., Martinotto, L. and Albizzati, E., Macromolecules, 2001, 34: 5175 doi: 10.1021/ma010121z
17. [17]
  Kao, Y.H. and Phillips, P.J., Polymer, 1986, 27: 1669 doi: 10.1016/0032-3861(86)90260-0
18. [18]
  Gohil, R.M. and Phillips, P.J., Polymer, 1986, 27: 1696 doi: 10.1016/0032-3861(86)90263-6
19. [19]
  Gohil, R.M. and Phillips, P.J., Polymer, 1986, 27: 1687 doi: 10.1016/0032-3861(86)90262-4
20. [20]
  Wunderlich, B. and Czornyj, G., Macromolecules, 1977, 10: 906 doi: 10.1021/ma60059a006
21. [21]
  Ferry, J.D., "Viscoelastic properties of polymers"; Wiley: New York, 1980
22. [22]
  Gahleitner, M., Prog. Polym. Sci., 2001, 26: 895 doi: 10.1016/S0079-6700(01)00011-9
23. [23]
  Winter, H.H. and Mours, M., Adv. Polym. Sci., 1997, 134: 165 doi: 10.1007/3-540-68449-2
24. [24]
  Akbar, S., Beyou, E., Chaumont, P. and Cassagnau, P., Mater. Chem. Phys., 2009, 117: 482 doi: 10.1016/j.matchemphys.2009.06.046
25. [25]
  Gloor, P.E., Tang, Y., Kostanska, A.E. and Hamielec, A.E., Polymer, 1994, 35: 1012 doi: 10.1016/0032-3861(94)90946-6
26. [26]
  Msakni, A., Chaumont, P. and Cassagnau, P., Rheol. Acta, 2007, 46: 933 doi: 10.1007/s00397-007-0176-9
27. [27]
  Inokuti, M., J. Chem. Phys., 1963, 38: 2999 doi: 10.1063/1.1733633
28. [28]
  Qiu, J., Xu, D.H., Zhao, J.C., Niu, Y.H. and Wang, Z.G., J. Polym. Sci., Part B: Polym. Phys., 2008, 46: 2100 doi: 10.1002/polb.v46:19
29. [29]
  Péreza, C.J., Alvarez, V.A., Valles, E.M. and Failla, M.D., Thermochimica Acta, 2012, 528: 15 doi: 10.1016/j.tca.2011.10.031
1. [1]
  Min Chen , Boyu Peng , Xuyun Guo , Ye Zhu , Hanying Li . Polyethylene interfacial dielectric layer for organic semiconductor single crystal based field-effect transistors. Chinese Chemical Letters, 2024, 35(4): 109051-. doi: 10.1016/j.cclet.2023.109051
2. [2]
  Jun Lu , Jinrui Yan , Yaohao Guo , Junjie Qiu , Shuangliang Zhao , Bo Bao . Controlling solid form and crystal habit of triphenylmethanol by antisolvent crystallization in a microfluidic device. Chinese Chemical Letters, 2024, 35(4): 108876-. doi: 10.1016/j.cclet.2023.108876
3. [3]
  Qiang Cao , Xue-Feng Cheng , Jia Wang , Chang Zhou , Liu-Jun Yang , Guan Wang , Dong-Yun Chen , Jing-Hui He , Jian-Mei Lu . Graphene from microwave-initiated upcycling of waste polyethylene for electrocatalytic reduction of chloramphenicol. Chinese Chemical Letters, 2024, 35(4): 108759-. doi: 10.1016/j.cclet.2023.108759
4. [4]
  Xiaxia Xing , Xiaoyu Chen , Zhenxu Li , Xinhua Zhao , Yingying Tian , Xiaoyan Lang , Dachi Yang . Polyethylene imine functionalized porous carbon framework for selective nitrogen dioxide sensing with smartphone communication. Chinese Chemical Letters, 2024, 35(9): 109230-. doi: 10.1016/j.cclet.2023.109230
5. [5]
  Zhihong LUO , Yan SHI , Jinyu AN , Deyi ZHENG , Long LI , Quansheng OUYANG , Bin SHI , Jiaojing SHAO . Two-dimensional silica-modified polyethylene oxide solid polymer electrolyte to enhance the performance of lithium-ion batteries. Chinese Journal of Inorganic Chemistry, 2024, 40(5): 1005-1014. doi: 10.11862/CJIC.20230444
6. [6]
  Yi Zhang , Biao Wang , Chao Hu , Muhammad Humayun , Yaping Huang , Yulin Cao , Mosaad Negem , Yigang Ding , Chundong Wang . Fe–Ni–F electrocatalyst for enhancing reaction kinetics of water oxidation. Chinese Journal of Structural Chemistry, 2024, 43(2): 100243-100243. doi: 10.1016/j.cjsc.2024.100243
7. [7]
  Yifei Zhang , Yuncong Xue , Laiwei Gao , Rui Liao , Feng Wang , Fei Wang . Merging non-covalent and covalent crosslinking: En route to single chain nanoparticles. Chinese Chemical Letters, 2024, 35(6): 109217-. doi: 10.1016/j.cclet.2023.109217
8. [8]
  Yi Herng Chan , Zhe Phak Chan , Serene Sow Mun Lock , Chung Loong Yiin , Shin Ying Foong , Mee Kee Wong , Muhammad Anwar Ishak , Ven Chian Quek , Shengbo Ge , Su Shiung Lam . Thermal pyrolysis conversion of methane to hydrogen (H₂): A review on process parameters, reaction kinetics and techno-economic analysis. Chinese Chemical Letters, 2024, 35(8): 109329-. doi: 10.1016/j.cclet.2023.109329

Metrics

PDF Downloads(0)
Abstract views(559)
HTML views(1)

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Address：Zhongguancun North First Street 2,100190 Beijing, PR China Tel: +86-010-82449177-888

Powered By info@rhhz.net

/

DownLoad: Full-Size Img PowerPoint