Pd/MnOx+Pd/γ-Al2O3整体式催化剂降解地表臭氧

引用本文: 周丽娜, 陈耀强, 任成军, 龚茂初. Pd/MnO_x+Pd/γ-Al₂O₃整体式催化剂降解地表臭氧[J]. 无机化学学报, 2013, 29(11): 2363-2369. doi: 10.3969/j.issn.1001-4861.2013.00.357 shu

Citation: ZHOU Li-Na, CHEN Yao-Qiang, REN Cheng-Jun, GONG Mao-Chu. Pd/MnO_x+Pd/γ-Al₂O₃ Monolith Catalysts for Ground-Level Ozone Decomposition[J]. Chinese Journal of Inorganic Chemistry, 2013, 29(11): 2363-2369. doi: 10.3969/j.issn.1001-4861.2013.00.357 shu

Pd/MnO_x+Pd/γ-Al₂O₃整体式催化剂降解地表臭氧

基金项目:
四川大学化学学院基地能力提高项目基金(No.J1103315)资助项目。 (No.J1103315)

摘要: 用高锰酸钾与硝酸锰氧化还原反应制备了高活性的氧化锰(MnO_x)催化组分,用胶溶法制备了高比表面积的γ-Al₂O₃载体,分别用等体积浸渍法制备了Pd/MnO_x和Pd/γ-Al₂O₃催化剂,然后将两者机械混合涂覆于堇青石上制得Pd/MnO_x+Pd/γ-Al₂O₃整体式催化剂。采用X射线衍射(XRD)、X射线光电子能谱(XPS)、程序升温还原(H₂-TPR)和低温N₂吸附-脱附对催化剂进行了表征。考察了在300至700℃焙烧MnO_x对催化剂降解地表O₃活性的影响。结果表明,Pd和MnO_x之间存在协同作用;MnO_x焙烧温度对催化剂活性有一定的影响,其中以600℃焙烧时催化剂的活性最高,O₃的起始(12℃)转化率达到88%,完全转化温度为18℃。MnO_x的物相和催化剂表面的吸附氧物种对催化活性影响较大,适当比例的MnO₂和Mn₂O₃共存有利于O₃分解,表面吸附氧为O₃分解的活性氧物种。

关键词:

锰氧化物;钯;臭氧;催化降解;焙烧温度

English

Pd/MnO_x+Pd/γ-Al₂O₃ Monolith Catalysts for Ground-Level Ozone Decomposition

1.
Key Laboratory of Green Chemistry & Technology of the Ministry of Education, College of Chemistry, Sichuan University, Chengdu 610064, China
Received Date: 25 February 2013
Fund Project:
四川大学化学学院基地能力提高项目基金(No.J1103315)资助项目。

Abstract: Ahighly active MnO_x materials were prepared by an oxidation-reduction reaction between KMnO₄ and Mn(NO₃)₂. The γ-Al₂O₃ support with large surface area was synthesized by the peptizing method. Subsequently, Pd was loaded on MnO_x and γ-Al₂O₃ by incipient wetness impregnation, respectively. Then, the Pd/MnO_x and Pd/γ-Al₂O₃ were mixed and coated on the cordierite. Finally, the Pd/MnO_x+Pd/γ-Al₂O₃ monolithic catalysts were obtained. The catalysts were characterized by X-ray diffraction (XRD), X-ray photoelectron spectroscopy (XPS), Temperature-programmed reduction (H₂-TPR) and low temperature N₂ adsorption/desorption measurement, respectively. Asynergetic effect took place between Pd and MnO_x when O₃ was decomposed on the surface of the Pd/MnO_x+Pd/γ-Al₂O₃ catalysts. The effect of calcination temperature on the catalytic performance for the decomposition of ground-level ozone was investigated. It revealed that the activity of catalysts was considerably influenced by the calcination temperature of MnO_x. When the MnO_x was calcined at 600 ℃, the catalyst had the highest activity, where ozone conversion reached 88% at 12 ℃ and it was completely decomposed at 18 ℃. The results show that catalytic activity mainly depends on the MnO_x phase and oxygen species adsorbed on the surface of catalysts. The MnO₂ and Mn₂O₃ with proper proportion can efficiently promote the decomposition of ozone. And oxygen adsorbed on the surface of catalysts is active oxygen species during ozone decomposition.

Key words:

manganese oxide;palladium;ozone;catalytic decomposition;calcination temperature

1. [1] Dhandapani B, Oyama S T. Appl. Catal. B, 1997,11(2):129-166[1] Dhandapani B, Oyama S T. Appl. Catal. B, 1997,11(2):129-166
2. [2] CHEN Ye-Pu(陈烨璞), JIANG Ai-Li(蒋爱丽), TAN Gui-Xia (谭桂霞), et al. Industrial Catal. (Gongye Cuihua), 2006,14 (5):52-55[2] CHEN Ye-Pu(陈烨璞), JIANG Ai-Li(蒋爱丽), TAN Gui-Xia (谭桂霞), et al. Industrial Catal. (Gongye Cuihua), 2006,14 (5):52-55
3. [3] FU Jia-Yuan(傅嘉媛), FENG Yi-Jun(冯易君), ZHONG Bing (钟兵), et al. Sichuan Environ. (Sichuan Huanjing), 2001,20 (3):10-14[3] FU Jia-Yuan(傅嘉媛), FENG Yi-Jun(冯易君), ZHONG Bing (钟兵), et al. Sichuan Environ. (Sichuan Huanjing), 2001,20 (3):10-14
4. [4] LI Wei(李伟), SUN De-Zhi(孙德智), LIU Chang-An (刘长安), et al. J. Harbin Institute Technol. (Harbing Gongye Daxue Xuebao), 2004,36(5):624-627[4] LI Wei(李伟), SUN De-Zhi(孙德智), LIU Chang-An (刘长安), et al. J. Harbin Institute Technol. (Harbing Gongye Daxue Xuebao), 2004,36(5):624-627
5. [5] Wu M C, Kelly N A. Appl. Catal. B., 1998,18(1/2):79-91[5] Wu M C, Kelly N A. Appl. Catal. B., 1998,18(1/2):79-91
6. [6] Terui S, Yokota Y. US Patent, 5187137. 1993-02-16[6] Terui S, Yokota Y. US Patent, 5187137. 1993-02-16
7. [7] Kameya T, Urano K. J. Environ. Eng. 2002,128(3):286-292[7] Kameya T, Urano K. J. Environ. Eng. 2002,128(3):286-292
8. [8] Zhang X, Zhang F, Chan K Y. Mater. Lett., 2004,58(22/23): 2872-2877[8] Zhang X, Zhang F, Chan K Y. Mater. Lett., 2004,58(22/23): 2872-2877
9. [9] Kitaguchi S, Terui S, et al. US Patent, 5296435.1994-03-22[9] Kitaguchi S, Terui S, et al. US Patent, 5296435.1994-03-22
10. [10]YAO Yan-Ling(姚艳玲), FANG Rui-Mei(方瑞梅), SHI Zhong-Hua(史忠华), et al. Chin. J. Catal. (Cuihua Xuebao), 2011,32(4):589-594[10]YAO Yan-Ling(姚艳玲), FANG Rui-Mei(方瑞梅), SHI Zhong-Hua(史忠华), et al. Chin. J. Catal. (Cuihua Xuebao), 2011,32(4):589-594
11. [11]Rezaei E, Soltan J, Chen N, et al. Chem. Eng. J., 2013,214: 219-228[11]Rezaei E, Soltan J, Chen N, et al. Chem. Eng. J., 2013,214: 219-228
12. [12]Xu G P, Zhu Y X, Ma J, et al. Stud. Surf. Sci. Catal., 1997,112:333-338[12]Xu G P, Zhu Y X, Ma J, et al. Stud. Surf. Sci. Catal., 1997,112:333-338
13. [13]YU Quan-Wei(余全伟), ZHAO Ming(赵明), LIU Zhi-Ming (刘志敏), et al. Chin. J. Catal. (Cuihua Xuebao), 2009,30 (1):1-3[13]YU Quan-Wei(余全伟), ZHAO Ming(赵明), LIU Zhi-Ming (刘志敏), et al. Chin. J. Catal. (Cuihua Xuebao), 2009,30 (1):1-3
14. [14]Fu X B, Feng J Y, Wang H, et al. Catal. Commun., 2009,10 (14):1844-1848[14]Fu X B, Feng J Y, Wang H, et al. Catal. Commun., 2009,10 (14):1844-1848
15. [15]Berbenni V, Marini A. Mater. Res. Bull., 2003,38(14):1859-1866[15]Berbenni V, Marini A. Mater. Res. Bull., 2003,38(14):1859-1866
16. [16]Einaga H, Harada M, Futamura S. Chem. Phys. Lett., 2005, 408(4/5/6):377-380[16]Einaga H, Harada M, Futamura S. Chem. Phys. Lett., 2005, 408(4/5/6):377-380
17. [17]Santos V P, Pereira M F R, Órfǎo J J M, et al. Appl. Catal. B, 2010,99:353-363[17]Santos V P, Pereira M F R, Órfǎo J J M, et al. Appl. Catal. B, 2010,99:353-363
18. [18]Wei Y J, Yan L Y, Wang C Z, et al. J. Phys. Chem. B, 2004,108(48):18547-18551[18]Wei Y J, Yan L Y, Wang C Z, et al. J. Phys. Chem. B, 2004,108(48):18547-18551
19. [19]Ardizzone S, Bianchi C L, Tirelli D. Colloids. Surf. A, 1998, 134(3):305-312[19]Ardizzone S, Bianchi C L, Tirelli D. Colloids. Surf. A, 1998, 134(3):305-312
20. [20]Thota S, Prasad B, Kumar J. Mater. Sci. Eng. B, 2010,167 (3):153-160[20]Thota S, Prasad B, Kumar J. Mater. Sci. Eng. B, 2010,167 (3):153-160
21. [21]Chen H Y, Sayari A, Adnot A, et al. Appl. Catal. B, 2001,32:195-204[21]Chen H Y, Sayari A, Adnot A, et al. Appl. Catal. B, 2001,32:195-204
22. [22]Bulanin K M, Lavalley J C, Tsyganenko A A. Colloid Surface A, 1995,101(2/3):153-158[22]Bulanin K M, Lavalley J C, Tsyganenko A A. Colloid Surface A, 1995,101(2/3):153-158
23. [23]Li W, Oyama T. J. Am. Chem. Soc., 1998,120(35):9047-9052[23]Li W, Oyama T. J. Am. Chem. Soc., 1998,120(35):9047-9052

扫一扫看文章

计量

PDF下载量: 0
文章访问数: 414
HTML全文浏览量: 41

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Pd/MnO_x+Pd/γ-Al₂O₃整体式催化剂降解地表臭氧

English

Pd/MnO_x+Pd/γ-Al₂O₃ Monolith Catalysts for Ground-Level Ozone Decomposition

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处