还原热处理对铈锆铝复合氧化物性能的影响

引用本文: 肖益鸿, 杨黄根, 蔡国辉, 郑勇, 郑瑛, 魏可镁. 还原热处理对铈锆铝复合氧化物性能的影响[J]. 物理化学学报, 2012, 28(01): 245-250. doi: 10.3866/PKU.WHXB201228245 shu

Citation: XIAO Yi-Hong, YANG Huang-Gen, CAI Guo-Hui, ZHENG Yong, ZHENG Ying, WEI Ke-Mei. Influence of Reductive Treatment on the Performance of CeO₂-ZrO₂-Al₂O₃ Composite Oxide[J]. Acta Physico-Chimica Sinica, 2012, 28(01): 245-250. doi: 10.3866/PKU.WHXB201228245 shu

还原热处理对铈锆铝复合氧化物性能的影响

基金项目:
福建省工业科技重大项目(2010H6014)资助 (2010H6014)

摘要: 采用共沉淀法制备铈锆铝复合氧化物(CeO₂-ZrO₂-Al₂O₃, CZA)和铈锆复合氧化物(CeO₂-ZrO₂, CZ), 将样品分别在空气和10% H₂/Ar 气氛下进行热处理, 利用X射线粉末衍射(XRD)、O₂脉冲吸附、H₂程序升温还原(H₂-TPR)等手段研究了复合氧化物的结构及性能. 结果表明: CZA样品经950 °C还原热处理后出现CeAlO₃晶相, 热处理温度越高, 越有利于CeAlO₃物相生成. CZA 储氧量(OSC)随着还原热处理温度升高逐渐增大, 至900 °C达到1270.3 μmol·g^-1; 温度继续升高, OSC减小, 1100 °C还原热处理后CZA的OSC仅为23.2 μmol·g^-1. 研究发现还原热处理中形成CeAlO₃, 其显著影响CZA样品的储氧性能和还原性能.

关键词:

English

Influence of Reductive Treatment on the Performance of CeO₂-ZrO₂-Al₂O₃ Composite Oxide

1.
National Engineering Research Center of Chemical Fertilizer Catalyst, Fuzhou University, Fuzhou 350002, P. R. China
Received Date: 02 September 2011
Available Online: 29 December 2011
Fund Project:
福建省工业科技重大项目(2010H6014)资助

Abstract: A CeO₂-ZrO₂-Al₂O₃ composite oxide (CZA) and a CeO₂-ZrO₂ composite oxide (CZ) were prepared by the co-precipitation method. The samples were thermally aged in a flowing air atmosphere and in 10% H₂/Ar flow. The structure and performance of the composite oxides were studied by X-ray diffraction (XRD), oxygen storage capacity (OSC) measurements, and H₂ temperature-programmed reduction (H₂- TPR). The results show that a CeAlO₃ phase was formed after CZA was reductively aged at 950 °C and an increase in temperature benefited the formation of CeAlO₃. The OSC of CZA increased with an increase in the reductive treatment temperature and it was 1270.3 μmol·g^-1 when the temperature reached 900 °C. However, the OSC decreased with an increase in the temperature. After CZA was reduced at 1100 °C the OSC was only 23.2 μmol·g^-1. We found that the OSC and the reducibility of the material were remarkably influenced by the formation of a CeAlO₃ phase after CZA was reductively aged.

Key words:

1. [1]
  (1) Heck, R. M.; Farrauto, R. J. Appl. Catal. A 2001, 221, 443. (1) Heck, R. M.; Farrauto, R. J. Appl. Catal. A 2001, 221, 443.
2. [2]
  (2) Di Monte, R.; Fornasiero, P.; Desinan, S.; Kaspar, J. Chem. Mater. 2004, 16, 4273. (2) Di Monte, R.; Fornasiero, P.; Desinan, S.; Kaspar, J. Chem. Mater. 2004, 16, 4273.
3. [3]
  (3) Chuang, C. C.; Hsiang, H. I.; Hwang, J. S.;Wang, T. S. J. Alloy. Compd. 2009, 470, 387. (3) Chuang, C. C.; Hsiang, H. I.; Hwang, J. S.;Wang, T. S. J. Alloy. Compd. 2009, 470, 387.
4. [4]
  (4) Kaspar, J.; Fornasiero, P.; Hickey, N. Catal. Today 2003, 77, 419. (4) Kaspar, J.; Fornasiero, P.; Hickey, N. Catal. Today 2003, 77, 419.
5. [5]
  (5) Guo, J. X.; Yuan, S. H.; ng, M. C.; Zhang, L.;Wu, D. D.; Zhao, M.; Chen, Y. Q. Acta Phys. -Chim. Sin. 2007, 23 (1), 73. [郭家秀, 袁书华, 龚茂初, 张磊, 吴冬冬, 赵明, 陈耀强. 物理化学学报, 2007, 23 (1), 73.](5) Guo, J. X.; Yuan, S. H.; ng, M. C.; Zhang, L.;Wu, D. D.; Zhao, M.; Chen, Y. Q. Acta Phys. -Chim. Sin. 2007, 23 (1), 73. [郭家秀, 袁书华, 龚茂初, 张磊, 吴冬冬, 赵明, 陈耀强. 物理化学学报, 2007, 23 (1), 73.]
6. [6]
  (6) Wei, Z. L.; Li, H. M.; Zhang, X. Y.; Yan, S. H.; Lv, Z.; Chen, Y. Q.; ng, M. C. J. Alloy. Compd. 2008, 455, 322. (6) Wei, Z. L.; Li, H. M.; Zhang, X. Y.; Yan, S. H.; Lv, Z.; Chen, Y. Q.; ng, M. C. J. Alloy. Compd. 2008, 455, 322.
7. [7]
  (7) Zhang, X. Y.; Long, E.Y.; Li, Y. L.; Guo, J. X.; Zhang, L. J.; ng, M. C.;Wang, M. H.; Chen, Y. Q. J. Nat. Gas Chem. 2009, 18, 139. (7) Zhang, X. Y.; Long, E.Y.; Li, Y. L.; Guo, J. X.; Zhang, L. J.; ng, M. C.;Wang, M. H.; Chen, Y. Q. J. Nat. Gas Chem. 2009, 18, 139.
8. [8]
  (8) Cai, L.; Zhao, M.; Pi, Z.; ng, M. C.; Chen, Y. Q. Chin. J. Catal. 2008, 29, 108. [蔡黎, 赵明,皮展, 龚茂初, 陈耀强. 催化学报, 2008, 29, 108.] (8) Cai, L.; Zhao, M.; Pi, Z.; ng, M. C.; Chen, Y. Q. Chin. J. Catal. 2008, 29, 108. [蔡黎, 赵明,皮展, 龚茂初, 陈耀强. 催化学报, 2008, 29, 108.]
9. [9]
  (9) Cai, L.;Wang, K. C.; Zhao, M.; ng, M. C.; Chen, Y. Q. Acta Phys. -Chim. Sin. 2009, 25 (5), 859. [蔡黎, 王康才, 赵明, 龚茂初, 陈耀强. 物理化学学报, 2009, 25 (5), 859.](9) Cai, L.;Wang, K. C.; Zhao, M.; ng, M. C.; Chen, Y. Q. Acta Phys. -Chim. Sin. 2009, 25 (5), 859. [蔡黎, 王康才, 赵明, 龚茂初, 陈耀强. 物理化学学报, 2009, 25 (5), 859.]
10. [10]
  (10) Morikawa, A.; Suzuki, T.; Kanazawa, T.; Kikuta, K.; Suda, A.; Shinjo, H. Appl. Catal. B 2008, 78, 210. (10) Morikawa, A.; Suzuki, T.; Kanazawa, T.; Kikuta, K.; Suda, A.; Shinjo, H. Appl. Catal. B 2008, 78, 210.
11. [11]
  (11) Shyu, J. Z.;Weber,W. H.; Gandhi, H. S. J. Phys. Chem. 1988, 92 (17), 4964.(11) Shyu, J. Z.;Weber,W. H.; Gandhi, H. S. J. Phys. Chem. 1988, 92 (17), 4964.
12. [12]
  (12) Miki, T.; Ogawa, T.; Ueno, A.; Matsuura, S.; Sato, M. Chem. Lett. 1988, 565.(12) Miki, T.; Ogawa, T.; Ueno, A.; Matsuura, S.; Sato, M. Chem. Lett. 1988, 565.
13. [13]
  (13) Morikawa, A.; Kikuta, K.; Suda, A.; Shinjo, H. Appl. Catal. B 2009, 88, 542. (13) Morikawa, A.; Kikuta, K.; Suda, A.; Shinjo, H. Appl. Catal. B 2009, 88, 542.
14. [14]
  (14) Vidal, H.; Bernal, S., Ka?par, J. Catal. Today 1999, 54, 93. (14) Vidal, H.; Bernal, S., Ka?par, J. Catal. Today 1999, 54, 93.
15. [15]
  (15) Hietikko, M.; Lassi, U.; Kallinen, K.; Savim?ki, A.; H?rk?nen, M.; Pursiainen, J.; Laitinen, R. S.; Keiski, R. L. Appl. Cata. A 2004, 277, 107. (15) Hietikko, M.; Lassi, U.; Kallinen, K.; Savim?ki, A.; H?rk?nen, M.; Pursiainen, J.; Laitinen, R. S.; Keiski, R. L. Appl. Cata. A 2004, 277, 107.
16. [16]
  (16) Lassi, U.; Polvinen, R.; Suhonen, S.; Kallinen, K.; Savim?ki, A.; H?rk?nen, M.; Valden, M.; Keiski, R. L. Appl. Catal. A 2004, 263, 241. (16) Lassi, U.; Polvinen, R.; Suhonen, S.; Kallinen, K.; Savim?ki, A.; H?rk?nen, M.; Valden, M.; Keiski, R. L. Appl. Catal. A 2004, 263, 241.
17. [17]
  (17) Wang, J.;Wen, J.; Shen, M. Q. J. Phys. Chem. C 2008, 112, 5113. (17) Wang, J.;Wen, J.; Shen, M. Q. J. Phys. Chem. C 2008, 112, 5113.
18. [18]
  (18) Kishimoto, H.; Omata, T.; Otsuka-Yao-Matsuo,S.; Ueda, K.; Hosono, H.; Kawazoe, H. J. Alloy. Compd. 2000, 312, 94. (18) Kishimoto, H.; Omata, T.; Otsuka-Yao-Matsuo,S.; Ueda, K.; Hosono, H.; Kawazoe, H. J. Alloy. Compd. 2000, 312, 94.
19. [19]
  (19) Yamamoto, T.; Suzuki, A.; Nagai, Y.; Tanabe, T.; Dong, F.; Inada, Y.; Nomura, M.; Tada, M.; Iwasawa, Y. Angew. Chem. Int. Edit. 2007, 46, 9253. (19) Yamamoto, T.; Suzuki, A.; Nagai, Y.; Tanabe, T.; Dong, F.; Inada, Y.; Nomura, M.; Tada, M.; Iwasawa, Y. Angew. Chem. Int. Edit. 2007, 46, 9253.
20. [20]
  (20) Liotta, L. F.; Lon , A.; Pantaleo, G.; Di Carlo, G.; Martorana, A.; Cimino, S.; Russo, G.; Degandllo, G. Appl. Catal. B 2009, 90, 470. (20) Liotta, L. F.; Lon , A.; Pantaleo, G.; Di Carlo, G.; Martorana, A.; Cimino, S.; Russo, G.; Degandllo, G. Appl. Catal. B 2009, 90, 470.
21. [21]
  (21) Zhu, Q. C.; Li, X. M.; Li, H. M.; Zheng, L. M.; Chen, Y. Q.; ng, M. C. J. Inorg. Mater. 2010, 25 (1), 13. [祝清超, 黎秀敏, 李红梅, 郑灵敏, 陈耀强, 龚茂初. 无机材料学报, 2010, 25 (1), 13.](21) Zhu, Q. C.; Li, X. M.; Li, H. M.; Zheng, L. M.; Chen, Y. Q.; ng, M. C. J. Inorg. Mater. 2010, 25 (1), 13. [祝清超, 黎秀敏, 李红梅, 郑灵敏, 陈耀强, 龚茂初. 无机材料学报, 2010, 25 (1), 13.]
22. [22]
  (22) Nagai, Y.; Yamamoto, T.; Tanaka, T.; Yoshida, S.; Nonaka, T.; Okamoto, T.; Suda, A.; Sugiura, M. Catal. Today 2002, 74, 225. (22) Nagai, Y.; Yamamoto, T.; Tanaka, T.; Yoshida, S.; Nonaka, T.; Okamoto, T.; Suda, A.; Sugiura, M. Catal. Today 2002, 74, 225.
23. [23]
  (23) Wang, H. F.; Guo, Y. L.; Lu, G. Z.; Hu, P. Angew. Chem. Int. Edit. 2009, 48, 8289. (23) Wang, H. F.; Guo, Y. L.; Lu, G. Z.; Hu, P. Angew. Chem. Int. Edit. 2009, 48, 8289.
24. [24]
  (24) Prakash, A. S.; Shivakumara, C.; Hegde, M. S. Mater. Sci. Engin. B 2007, 139, 55. (24) Prakash, A. S.; Shivakumara, C.; Hegde, M. S. Mater. Sci. Engin. B 2007, 139, 55.
25. [25]
  (25) Kakuta, N.; Ikawa, S.; Eguchi, T.; Murakami, K.; Ohkita, H.; Mizushima, T. J. Alloy. Compd. 2006, 408-412, 1078.(25) Kakuta, N.; Ikawa, S.; Eguchi, T.; Murakami, K.; Ohkita, H.; Mizushima, T. J. Alloy. Compd. 2006, 408-412, 1078.
26. [26]
  (26) Damyanova, S.; Pawelec, B.; Arishtirova, K. Appl. Catal. A 2008, 337, 86. (26) Damyanova, S.; Pawelec, B.; Arishtirova, K. Appl. Catal. A 2008, 337, 86.
27. [27]
  (27) Fornasiero, P.; DiMonte, R.; Rao, G. R.; Kašpar, J.; Meriani, S.; Trovarelli, A.; Grazinai, M. J. Catal. 1995, 151 (1), 168.(27) Fornasiero, P.; DiMonte, R.; Rao, G. R.; Kašpar, J.; Meriani, S.; Trovarelli, A.; Grazinai, M. J. Catal. 1995, 151 (1), 168.
28. [28]
  (28) Yao, M. H.; Baird, R. J.; Kunz, F.W.; Hoost, T. E. J. Catal. 1997, 166 (1), 67.(28) Yao, M. H.; Baird, R. J.; Kunz, F.W.; Hoost, T. E. J. Catal. 1997, 166 (1), 67.

扫一扫看文章

计量

PDF下载量: 839
文章访问数: 2459
HTML全文浏览量: 6

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

还原热处理对铈锆铝复合氧化物性能的影响

English

Influence of Reductive Treatment on the Performance of CeO₂-ZrO₂-Al₂O₃ Composite Oxide

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

还原热处理对铈锆铝复合氧化物性能的影响

English

Influence of Reductive Treatment on the Performance of CeO2-ZrO2-Al2O3 Composite Oxide

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南： 你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

文章相关

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

Influence of Reductive Treatment on the Performance of CeO₂-ZrO₂-Al₂O₃ Composite Oxide

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs