稀土铈对铝合金LY12CZ微生物腐蚀行为的影响

引用本文: 赵勇, 薛文斌, 刘宏芳. 稀土铈对铝合金LY12CZ微生物腐蚀行为的影响[J]. 物理化学学报, 2011, 27(11): 2618-2624. doi: 10.3866/PKU.WHXB20111109 shu

Citation: ZHAO Yong, XUE Wen-Bin, LIU Hong-Fang. Effect of Rare Earth Ce³⁺ on the Microbial Induced Corrosion Behavior of Aluminum Alloy LY12CZ[J]. Acta Physico-Chimica Sinica, 2011, 27(11): 2618-2624. doi: 10.3866/PKU.WHXB20111109 shu

稀土铈对铝合金LY12CZ微生物腐蚀行为的影响

基金项目:
北京师范大学射线束技术与材料改性教育部重点实验室开放课题(201022)资助项目 (201022)

摘要: 采用紫外分光光度法(UVS)、最大可能数法(MPN)、循环阳极极化法、电化学阻抗谱(EIS)和表面荧光显微法(EFM)研究了不同含量稀土Ce³⁺离子对硫酸盐还原菌(SRB)生长及LY12CZ铝合金微生物腐蚀行为的影响. 结果表明: 低浓度的Ce³⁺离子能够促进SRB生长, 而高浓度时则抑制其生长; 循环阳极极化曲线表明, 稀土Ce³⁺离子的加入使铝合金LY12CZ的点蚀敏感性降低; 电化学阻抗谱表明, 在纯培养基中, 随稀土Ce³⁺离子浓度的增大, 铝合金耐蚀性增大. 而在接种1% SRB的培养基中, 当Ce³⁺浓度为0.376 mg·L^-1时, 生长旺盛的生物膜与Ce³⁺间产生协同作用, 增加了基体铝合金耐腐蚀性能. 随着Ce³⁺浓度的增加, SRB生长受到抑制, 不能形成致密的生物膜. 此时SRB的存在促进铝合金腐蚀, 显著减弱Ce³⁺对基体铝合金的保护作用.

关键词:

English

Effect of Rare Earth Ce³⁺ on the Microbial Induced Corrosion Behavior of Aluminum Alloy LY12CZ

1.
1. School of Chemistry and Chemical Engineering, Huazhong University of Science and Technology, Wuhan 430074, P. R. China;
2. Institute of Low Energy Nuclear Physics, Beijing Normal University, Beijing 100875, P. R. China
Received Date: 05 July 2011
Available Online: 27 October 2011
Fund Project:
北京师范大学射线束技术与材料改性教育部重点实验室开放课题(201022)资助项目

Abstract: The effect of rare earth Ce³⁺ on the growth of sulfate reducing bacterial (SRB) and the microbial induced corrosion (MIC) of aluminum alloy LY12CZ was studied by ultraviolet spectrophotometry (UVS), maximum probable number (MPN), cyclic anodic polarization, electrochemical impedance spectroscopy (EIS), and epi-fluorescence microscopy (EFM). The results showed that the low concentrations of Ce³⁺ could promote the growth of SRB while high concentrations had an inhibiting effect. Cyclic anodic polarization curves indicated that the pitting sensitivity of LY12CZ became lower in solutions containing rare earth Ce³⁺. EIS confirmed that corrosion resistance increased with an increase in the concentration of Ce³⁺. However, when inoculated with 1% SRB, the corrosion resistance was optimal at a Ce³⁺ concentration of 0.376 mg·L^-1 because of a synergistic effect between the biofilm and the rare earth conversion film. The growth of SRB was inhibited with an increase in the Ce³⁺ concentration which prevented the biofilm forming completely on the surface of the matrix. At the moment, the effect of MIC was more notable than the protection of rare earth conversion film that formed on the surface of aluminum alloy.

Key words:

1. [1]
  (1) Wagner, P.; Little, B. Mater. Performance 1993, 32, 65.(1) Wagner, P.; Little, B. Mater. Performance 1993, 32, 65.
2. [2]
  (2) Zhu, R. X.; Du, H. L. Corrosion and Protection in Petrochemical Industry 2002, 19, 28. [朱绒霞, 杜会玲. 石油化工腐蚀与防护, 2002, 19, 28.](2) Zhu, R. X.; Du, H. L. Corrosion and Protection in Petrochemical Industry 2002, 19, 28. [朱绒霞, 杜会玲. 石油化工腐蚀与防护, 2002, 19, 28.]
3. [3]
  (3) Gao, J. Z.; Long, Q. J.; Yang, T. Journal of Northwest Normal University (Natural Science) 2002, 38, 108. [高锦章, 龙全江, 杨韬. 西北师范大学学报: 自然科学版, 2002, 38, 108.](3) Gao, J. Z.; Long, Q. J.; Yang, T. Journal of Northwest Normal University (Natural Science) 2002, 38, 108. [高锦章, 龙全江, 杨韬. 西北师范大学学报: 自然科学版, 2002, 38, 108.]
4. [4]
  (4) Xi, B. Electroplating and Pollution Control 2008, 28, 24. [奚宝. 电镀与环保, 2008, 28, 24.](4) Xi, B. Electroplating and Pollution Control 2008, 28, 24. [奚宝. 电镀与环保, 2008, 28, 24.]
5. [5]
  (5) Davó, B.; Damborenea, J.J, de. Electrochim. Acta 2004, 49, 4957. (5) Davó, B.; Damborenea, J.J, de. Electrochim. Acta 2004, 49, 4957.
6. [6]
  (6) Mishra, A. K.; Balasubramaniam, R. Corrosion. Sci. 2007, 49, 1027. (6) Mishra, A. K.; Balasubramaniam, R. Corrosion. Sci. 2007, 49, 1027.
7. [7]
  (7) Xu, J. H.;Wang, X.;Wang, J.; Zheng, Q, J. Advanced Materials Research 2009, 79-82, 879.(7) Xu, J. H.;Wang, X.;Wang, J.; Zheng, Q, J. Advanced Materials Research 2009, 79-82, 879.
8. [8]
  (8) Tian, X.;Wang, L.M.;Wang, J. L.; Liu, Y. B.; An, J.; Cao, Z. Y. J. Alloy.s Compd. 2008, 465, 412. (8) Tian, X.;Wang, L.M.;Wang, J. L.; Liu, Y. B.; An, J.; Cao, Z. Y. J. Alloy.s Compd. 2008, 465, 412.
9. [9]
  (9) Mu, K. G.; Zhang, F. S.;Wang, C. J.; Zhang,W, J.; Hu, L. Journal of the Chinese Rare Earth Society 2003, 21, 1. [慕康国, 张富锁, 王成菊, 张文吉, 胡林. 中国稀土学报, 2003, 21, 1.](9) Mu, K. G.; Zhang, F. S.;Wang, C. J.; Zhang,W, J.; Hu, L. Journal of the Chinese Rare Earth Society 2003, 21, 1. [慕康国, 张富锁, 王成菊, 张文吉, 胡林. 中国稀土学报, 2003, 21, 1.]
10. [10]
  (10) Chen, A. M.; Si, Q. S.; Ou, Y. Y. S.; Chen, Y. B.; Tan, S. Z. Microbiology 2009, 36, 90. [陈爱美, 施庆珊, 欧阳友生, 陈仪本, 谭绍早. 微生物学通报, 2009, 36, 90.](10) Chen, A. M.; Si, Q. S.; Ou, Y. Y. S.; Chen, Y. B.; Tan, S. Z. Microbiology 2009, 36, 90. [陈爱美, 施庆珊, 欧阳友生, 陈仪本, 谭绍早. 微生物学通报, 2009, 36, 90.]
11. [11]
  (11) Calabrese, E. J.; Baldwin, L. A. International Journal of Toxicology 1997, 16, 545. (11) Calabrese, E. J.; Baldwin, L. A. International Journal of Toxicology 1997, 16, 545.
12. [12]
  (12) Murado, M. A.; Vázquez, J. A. Journal of the Oretical Biology 2007, 244, 489.(12) Murado, M. A.; Vázquez, J. A. Journal of the Oretical Biology 2007, 244, 489.
13. [13]
  (13) Zhao, R. M.; Liu, Y.; Li,W. H.; Shen, P.; Qu, S. S.; Yu, Z. N. Biol. Trace Elem. Res. 2003, 95, 269. (13) Zhao, R. M.; Liu, Y.; Li,W. H.; Shen, P.; Qu, S. S.; Yu, Z. N. Biol. Trace Elem. Res. 2003, 95, 269.
14. [14]
  (14) Liu, P.; Liu, Y.; Xie, Z. X.; Hou, A. X.; Shen, P.; Qu, S. S. Biol. Trace Elem. Res. 2005, 104, 275. (14) Liu, P.; Liu, Y.; Xie, Z. X.; Hou, A. X.; Shen, P.; Qu, S. S. Biol. Trace Elem. Res. 2005, 104, 275.
15. [15]
  (15) Zhao, R. M.; Liu, Y.; Xie, Z. X.; Shen, P.; Qu, S. S. J. Biochem. Bioph. Methods 2002, 46, 1.(15) Zhao, R. M.; Liu, Y.; Xie, Z. X.; Shen, P.; Qu, S. S. J. Biochem. Bioph. Methods 2002, 46, 1.
16. [16]
  (16) Zhao, R. M.; Liu, Y.; Xie, Z. X.; Shen, P.; Qu, S. S. Biol. Trace Elem. Res. 2002, 86, 167. (16) Zhao, R. M.; Liu, Y.; Xie, Z. X.; Shen, P.; Qu, S. S. Biol. Trace Elem. Res. 2002, 86, 167.
17. [17]
  (17) He, M. J.;Wu, X. Q.; Liu, Y. Q. Journal of Materials Science 2007, 42, 5118. (17) He, M. J.;Wu, X. Q.; Liu, Y. Q. Journal of Materials Science 2007, 42, 5118.
18. [18]
  (18) Liu, J. H.; Liang, X.; Li, S. M. Journal of the Chinese Society of Rare Earths 2006, 24, 81. [刘建华, 梁馨, 李松梅. 中国稀土学报, 2006, 24, 81.] (18) Liu, J. H.; Liang, X.; Li, S. M. Journal of the Chinese Society of Rare Earths 2006, 24, 81. [刘建华, 梁馨, 李松梅. 中国稀土学报, 2006, 24, 81.]
19. [19]
  (19) Mansfeld, F.;Wang, Y. Br. Corros. J. 1994, 29, 194.(19) Mansfeld, F.;Wang, Y. Br. Corros. J. 1994, 29, 194.
20. [20]
  (20) Rudd, A. L.; Breslin, C. B.; Mansfeld, F. Corrosion Sci. 2000, 42, 275. (20) Rudd, A. L.; Breslin, C. B.; Mansfeld, F. Corrosion Sci. 2000, 42, 275.
21. [21]
  (21) Wang, H. F.;Wang, Z. Q.; Hong, H. X.; Yin, Y. S. Mater. Chem. Phys. 2010, 124, 791. (21) Wang, H. F.;Wang, Z. Q.; Hong, H. X.; Yin, Y. S. Mater. Chem. Phys. 2010, 124, 791.
22. [22]
  (22) Long, H. Y.; Xiang, P.; Yang, Y.; Du, Z. J.; Huang, X. Z. Hi-Tech Fiber and Application 2010, 35, 23. [龙泓羽, 向萍, 杨怡, 杜作娟, 黄小忠. 高科技纤维与应用, 2010, 35, 23.](22) Long, H. Y.; Xiang, P.; Yang, Y.; Du, Z. J.; Huang, X. Z. Hi-Tech Fiber and Application 2010, 35, 23. [龙泓羽, 向萍, 杨怡, 杜作娟, 黄小忠. 高科技纤维与应用, 2010, 35, 23.]
23. [23]
  (23) Kaur, G.; Mandal, A. K.; Nihlani, M. C.; Lal, B. International Biodeterioration and Biodegration 2009, 63, 151. (23) Kaur, G.; Mandal, A. K.; Nihlani, M. C.; Lal, B. International Biodeterioration and Biodegration 2009, 63, 151.
24. [24]
  (24) Lin, S. Z.; Yu, S. Q. Procedure for Bbacteriological Analysis in Water to be Injected——Disappear Dilution method SY/T[S] 0532-93.1994-1-6. [林淑珍, 于淑琴. 油田注入水细菌分析方法——绝迹稀释法SY/T[S]. 0532-93.1994-1-6.](24) Lin, S. Z.; Yu, S. Q. Procedure for Bbacteriological Analysis in Water to be Injected——Disappear Dilution method SY/T[S] 0532-93.1994-1-6. [林淑珍, 于淑琴. 油田注入水细菌分析方法——绝迹稀释法SY/T[S]. 0532-93.1994-1-6.]
25. [25]
  (25) Song, S. Z. Electrochemical Corrosion Methods; Chemical Industry Press: Beijing, 1988; pp 187-188. [宋诗哲. 腐蚀电化学研究方法. 北京: 化学工业出版社, 1988: 187-188.](25) Song, S. Z. Electrochemical Corrosion Methods; Chemical Industry Press: Beijing, 1988; pp 187-188. [宋诗哲. 腐蚀电化学研究方法. 北京: 化学工业出版社, 1988: 187-188.]
26. [26]
  (26) Örnek, D.; Jayaraman, A.;Wood, T. K.; Sun, Z.; Hsu, C. H.; Mansfeld, F. Corrosion Sci. 2001, 43, 2121. (26) Örnek, D.; Jayaraman, A.;Wood, T. K.; Sun, Z.; Hsu, C. H.; Mansfeld, F. Corrosion Sci. 2001, 43, 2121.
27. [27]
  (27) Hinton, B. R.W.; Arnott, D. R.; Ryan, N. E. Mater. Forum 1986, 9, 162.(27) Hinton, B. R.W.; Arnott, D. R.; Ryan, N. E. Mater. Forum 1986, 9, 162.
28. [28]
  (28) Aldykewicz, A. J, Jr.; Isaacs, H. S.; Davenport, A. J. Electrochem. Soc. 1995, 142, 3342. (28) Aldykewicz, A. J, Jr.; Isaacs, H. S.; Davenport, A. J. Electrochem. Soc. 1995, 142, 3342.
29. [29]
  (29) Dong, Z. H.; Liu, T.; Liu, H. F. Biofouling 2011, 27, 487. (29) Dong, Z. H.; Liu, T.; Liu, H. F. Biofouling 2011, 27, 487.
30. [30]
  (30) Hsu, C. H.; Mansfeld, F. Corrosion Sci. 2002, 44, 2291. (30) Hsu, C. H.; Mansfeld, F. Corrosion Sci. 2002, 44, 2291.
31. [31]
  (31) Hamlaoui, L.; Tifouti, L. Pedraza, F. Corros. Sci. 2010, 52, 1883. (31) Hamlaoui, L.; Tifouti, L. Pedraza, F. Corros. Sci. 2010, 52, 1883.
32. [32]
  (32) Liu, H. F.; Xu, L. M.; Zheng, J. S. J. Chin. Soc. Corrosion Prot. 2000, 20, 41. [刘宏芳, 许立铭, 郑家燊. 中国腐蚀与防护学报, 2000, 20, 41.](32) Liu, H. F.; Xu, L. M.; Zheng, J. S. J. Chin. Soc. Corrosion Prot. 2000, 20, 41. [刘宏芳, 许立铭, 郑家燊. 中国腐蚀与防护学报, 2000, 20, 41.]

扫一扫看文章

计量

PDF下载量: 1413
文章访问数: 2373
HTML全文浏览量: 20

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

稀土铈对铝合金LY12CZ微生物腐蚀行为的影响

English

Effect of Rare Earth Ce³⁺ on the Microbial Induced Corrosion Behavior of Aluminum Alloy LY12CZ

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

稀土铈对铝合金LY12CZ微生物腐蚀行为的影响

English

Effect of Rare Earth Ce3+ on the Microbial Induced Corrosion Behavior of Aluminum Alloy LY12CZ

CCS Chemistry：嵌段共聚物自组装成 “三明治”二维有机材料，实现纳米级压力传感功能

CCS Chemistry：颜徐州、鲍哲南： 你的皮肤可能是一片SPMs

CCS Chemistry：工作高效不疲劳，只须让催化剂动起来

CCS Chemistry：静电组装导向聚合- 聚电解质纳米凝胶量化制备新策略

CCS Chemistry：金黄色葡萄球菌醛基脱氢酶是如何识别特异性底物的？

计量

文章相关

通讯作者: 陈斌, bchen63@163.com

中国化学会秘书处

Effect of Rare Earth Ce³⁺ on the Microbial Induced Corrosion Behavior of Aluminum Alloy LY12CZ

CCS Chemistry：颜徐州、鲍哲南：你的皮肤可能是一片SPMs